2019 VOLVO XC90 Complaints

The contact owned a 2019 Volvo XC90. The contact stated that while driving approximately 50-52 MPH, there smoke coming from the front passenger’s side wheel well of the vehicle. The contact stated that an off-duty Police Officer witnessed the failure and activated the Emergency Lights, allowing the contact to safely pull off the highway The contact immediately pulled over and stopped the vehicle. The grandson seated in the front passenger’s seat immediately exited the vehicle and the contact was able to unbuckle and removed the [XXX] from the second-row middle seat. The contact stated that moments later there were explosions, and there was black smoke and flames engulfing the vehicle. The vehicle was destroyed. There were no injuries sustained; however, all three occupants of the vehicle experienced emotional trauma from the vehicle catching on fire. Medical attention was not needed. A Police Report was filed at the scene and the vehicle was towed away. The contact stated that the car seat in the rear of the vehicle was destroyed. The vehicle was examined by an Insurance Adjuster, and it was determined that the fire had started in the engine compartment. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 61,511. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am writing to formally a repeated mechanical failure involving the HVAC evaporator systems in two Volvo vehicles that I purchased within a few months of each other. The vehicles involved are: • 2019 Volvo XC90 T6 Momentum VIN: [XXX] Purchased: November 2024 • 2020 Volvo XC60 T5 Momentum Purchased: January 2025 Within a six months apart, both vehicles suffered complete air conditioning system failure due to large evaporator leaks. In total, three evaporators have now been confirmed as leaking across these two vehicles. The 2020 XC60 experienced evaporator failure in May 2025 and required full evaporator replacement under its CPO warranty. The 2019 XC90 subsequently developed the same issue. After multiple independent inspections and a full diagnostic performed by Volvo, they have confirmed that both the front and rear evaporators were leaking. The total repair estimate exceeds seven thousand dollars. Despite the statistical improbability of two vehicles purchased months apart suffering identical HVAC system failures within months of ownership, Volvo Cars North America denied my goodwill assistance request. The denial was based solely on the fact that a prior owner of the XC90 had previously received an unrelated goodwill repair. I was not informed of this at the time of purchase and had no connection to that prior claim. I then filed a complaint with the BBB against Volvo Cars North America. Volvo did not respond at all. The BBB has now formally closed the case and recorded that Volvo failed to respond to the complaint. I have acted in good faith at every step. I paid for diagnostics. I provided complete documentation. I pursued proper escalation channels. I sought resolution through the BBB. Volvo has remained silent. This is not an isolated service matter. It reflects a potential systemic defect affecting multiple Volvo platforms and model years. The repeated evaporator failures raise serious concerns as far us intaking large freon amounts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Some back info: I keep the auto start/stop feature disabled. There are three identical incidents total. One about a year or two ago and two back to back a few weeks ago. The first time I was stopped at a drive through but in “drive” with my foot on the brake. All of the sudden the car completely turns off. Screens black, engine off. Completely black car no inside lights on. Within a couple of seconds, I hear the engine reengage and the car “starts” as normal like when you turn the switch. All of the lights and screens turn on and apple car play reconnects. The most recent two incidents were the same day and in drive having stopped at stoplights. The car goes “dead” then restarts all in drive with my foot on the brake. No warnings come up after the incident either. This time my husband and children were with me and can confirm it happened. I did not get these incidents checked out since the car was instantly back to normal with no warning messages. Very unnerving though and feels like the car is being remotely restarted somehow. The first time I just brushed it off, now I am concerned about this happening while in motion.

Upon driving a symbol with a turtle and engine cation sign flashed upon the dash displaying and reading reduced power train mode as this is being shown on dash the passenger next to me smelt smoke as we next seen smoke coming from the air conditioning system we immediately pulled over to the safest spot out of the ongoing traffic as smoke continued to worsen now under the hood when flames engulfed the engine and spread to rest of car.

Rear evaporator coil (Failure) The rear evaporator coil failed on my Volvo XC90 purchased new at the dealership in 2019. This car only had 27,000 miles on it when the evaporator coil went bad. Refrigerant smells entered the cabin when AC was on while my 2 year old daughter was in the back. Having refrigerant leaking into the cabin is not great for health, especially that of a toddler. Additionally this could have caused an inability to defrost windows creating a safety hazard. All refrigerant leaked out leading to a condition where I had to drive in 90 - 100 degree temperatures with my daughter.

While driving, the brakes completely failed without any warning. There were no signs, alerts, or symptoms prior to the failure. The braking ability was suddenly and entirely lost, creating an extremely dangerous situation. Upon inspection, it was determined that the brake booster had failed. This component failure directly caused the complete loss of braking power. Because this occurred without warning or prior indication and such an unexpected failure not only poses a significant safety risk to the driver and passengers but endangers everyone on the road, and it represents a severe safety hazard. A sudden brake booster failure can easily lead to loss of vehicle control, accidents, injury, or even fatalities. Immediate action is required to address this serious issue that threatens public safety.

Vehicle started experiencing stalling and when trying to accelerate it would not pick up on speed, I have been quoted by Volvo that the supercharger is bad on a car that is only 6 years old. That repair for this is $2,000 as the engine valve also has to get cleaned out. The vehicle started having issue with AC after 2 years and now the front evaporator has gone bad and with summer Time is when I realized of this defect. $5,000 repair for the evaporator.

After a software update the backup camera’s field of view is super focused on the tailgate, license plate, and the immediate ground below. This is a safety concern as there have been a few near misses at parking lot speeds.

Car shut off while driving and rebooted. Was precessed by the infotainment system crashing and then rebooting a minute prior. Car made a sound like a grunting sound right as it shut down.

There was a leak on the evaporator coil within the AC system for this car. We started having issues with the AC around the 56,500 mile mark ([XXX]). After a couple of rounds of recharging the system with refrigerant and looking for a leak, the repair shop finally found the leak on the evaporator coil system. The repair was quoted cost $4,854.03. The evaporator coil During the summers when the AC was not working, this was definitely a safety concern. Riding in the car with no AC in the summertime in Hawaii is brutal. The $4,854.03 cost for the evaporator coil replacement, did not include the amount of money we spent the first two go arounds looking for the leak and recharging the system with refrigerant. After doing some research and talking to the repair shop the evaporator coil replacement work it seems that this is a very common failure on this model/year Volvo. I also noticed it looks like they already had a similar recall out for this failure on other similar Volvos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I would like to have Volvo USA to address this issue and fix this common issue and recall this year model.