2005 VOLVO XC90 Complaints

2005 VOLVO XC90. CONSUMER WRITES IN REGARDS TO ENGINE BREAKDOWN. *SMD AN INITIAL INDEPENDENT MECHANIC BELIEVED THE PROBLEM WAS DUE TO A DECLARED DESIGN FLAW BY VOLVO IN THEIR 2005 MODELS. THE MECHANIC ADVISED THE CONSUMER, TO HAVE THE VEHICLE TOWED TO THE DEALER. THE DEALER HAD THE VEHICLE FOR 3 WEEKS AND DETERMINED THE CAUSE OF THE ENGINE BREAK DOWN WAS IN FACT A DESIGN FLAW. CORPORATE VOLVO STATED THE ISSUE WAS NOT PROBLEMATIC ENOUGH FOR THEM TO ISSUE A RECALL, AS PROBLEMS WERE EVALUATED ON A CASE-BY-CASE BASIS. VOLVO INFORMED THE DEALER TO RE-BUILD THE ENGINE, INSTEAD OF REPLACING IT. *JB

COMPLETE INSTRUMENT PANEL FAILURE WHILE DRIVING - NO ABILITY TO LET THE WINDOWS UP OR DOWN, NO SPEEDOMETER VISIBILITY, NO GAS READING . THERE WAS NO ABILITY FOR DEFOGGING WINDOW, NO ABILITY TO TURN ON HEAT OR AIR. THIS IS REALLY DANGEROUS WHEN DRIVING. THE PANEL GOES COMPLETELY BLANK. *JS

WE PURCHASED THIS 2005 VOLVO XC90 USED IN OCTOBER 2011 AND SINCE THAT TIME HAVE HAD TO REPLACE THE HEADLAMP MODULE 3 TIMES. THE LEFT HEADLIGHTS WOULD SOMETIMES WORK AND OTHER TIMES NOT. EACH TIME WE TOOK IT IN FOR DIAGNOSIS, WE WERE TOLD THAT THE HEADLAMP MODULE NEEDED TO BE REPLACE. THIS IS A $460 PART, ONE THAT HAS A LONG HISTORY OF FAILURE. MY WIFE IS AFRAID TO DRIVE THIS VEHICLE AT NIGHT, FOR FEAR THAT THE HEADLIGHTS WILL GO OUT. I CAN UNDERSTAND IF THE MODULE FAILED ONCE, OR MAYBE EVEN TWICE, BUT THREE TIMES IN ONLY 2.5 YEARS AND LESS THAN 20,000 MILES. IT APPEARS THAT THIS IS A RECURRING PROBLEM WITH OTHER VOLVO OWNERS AS WELL, YET VOLVO HAS NOT TAKEN STEPS TO REMEDY THE ISSUE. I CONSIDER THIS TO BE A SIGNIFICANT SAFETY ISSUE, ONE THAT NEED TO BE ADDRESSED. I AM VERY DISAPPOINTED WITH VOLVO'S LACK OF ACTION TO CORRECT THIS PROBLEM. CHECKING ONLINE, I SEE THAT MANY OTHER VOLVO XC90 OWNERS HAVE BEEN EXPERIENCING THE SAME PROBLEM. ANY ASSISTANCE WILL BE GREATLY APPRECIATED. THANK YOU. *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD JERK AND THE TURNING SIGNALS FAILED. THE CONTACT STATED THAT THE ELECTRONIC POWER STEERING SYSTEM, SRS AIR BAG SERVICE, ANTI-SKID, AND THE IMMOBILIZER WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CENTRAL ELECTRONIC MODULE, RACK AND PINION NUT, AND PINION SHAFT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 139,419.

WAS STARTING TO ACCELERATE AFTER A RED TRAFFIC LIGHT WHEN THE ENGINE SUDDENLY DIED AND CAR STOPPED RIGHT IN THE MIDDLE OF TRAFFIC. CAR WOULD NOT START AGAIN. BATTERY WAS GOOD, STARTED WORKED GOOD BUT IT SOUNDED LIKE NO GAS WAS GETTING TO THE ENGINE. BEING STUCK IN THE MIDDLE OF TRAFFIC, I WAS PUSHED BY THE CAR BEHIND ME TO A SAFE LOCATION OUT OF TRAFFIC. TOWED CAR TO SHOP AND STILL INVESTIGATING THE FAILURE. *TR

TL- THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED WHILE DRIVING 55 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THEY COULD NOT DIAGNOSE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 45,000. RK

TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WATER LEAKED INTO THE VEHICLE THROUGH THE SUN ROOF. THE WATER CAUSED DAMAGED TO THE HEADLINER AND FLOORBOARD CARPET. THE FAILURE ALSO CAUSED THE SEATS TO MOVE INDEPENDENTLY AND A GROWTH OF MOLD AND MILDEW INSIDE THE VEHICLE. THE CONTACT ALSO STATED THAT THERE WERE SEVERAL WATER BUGS AND OTHER TYPES OF INSECTS INFESTING THE VEHICLE DUE TO THE WATER ACCUMULATION. THE CONTACT SUFFERED FROM MEDICAL DISTRESS AS A RESULT OF THE FAILURE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSIS BUT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DECLINED TO REPAIR THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO TWO INDEPENDENT MECHANICS BUT THEY WERE UNABLE TO DRAIN THE SEVERAL GALLONS OF WATER THAT COULD BE HEARD FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 122,000. THE CURRENT VEHICLE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.

I BOUGHT THIS CAR AT 12/12/2013 WHEN I TEST DROVE THE CAR THE DEALER HAD THE RADIO ON AND I NEVER SUSPECTED ANY NOISE AT THE TIME.AFTER I BOUGHT THE CAR I KEPT HEARING THIS KNOCKING NOISE AT FIRST I THOUGHT IS WAS THE SKI RACK MAKING THE NOISE THEN WHEN MY HUSBAND DROVE IT HE SAID IT WAS COMING FROM THE TIRES SO I TOOK THE CAR TO MY MECHANIC AND HE CHECK IT A OUT AND FOUND MULTIPLE PROBLEMS THE SUSPENSION,INNER TIE RODS,AXLES,SWAY BAR, STEERING,BUSHINGS ETC HIS REPLY WAS HOW DID THIS CAR PASS INSPECTION WITH ALL THE PROBLEMS AVAILABLE TAKE THE CAR BACK AND ASK THE DEALER TO FIX THE PROBLEMS.I TOOK THE CAR BACK AND ASK THE DEALER TO COMPLY THEY WOULD NOT I TOLD THEM THEY HAD RECEIVED A FAULTY INSPECTIONS ON THE CAR SO I TOOK IT TO ANOTHER MECHANIC SAME RESPONSE. I THEN CALLED THE SAFETY INSPECTORS AND THEY CAME OUT TO CHECK OUT THE CAR AND FOUND NOTHING. I THEN TOOK IT TO ANOTHER DEALER AND THEY REPORTED THE SAME PROBLEMS AND ADDED A CRACKED ENGINE MOUNT. I THEN ASKED THE INSPECTOR TO COME AND LOOK AT ALL THE THINGS THAT VOLVO FOUND THAT THE SAFETY INSPECTORS MISSED HE AGREED AND SAW BUT ONLY WROTE A REPORT I STILL HAVE A BROKE CAR THAT WAS FAULTY INSPECTED. I WANT THE DEALER TO FIX MY PROBLEM AND THEY HAVE REFUSED I COULD SUE THEM FOR GETTING A FAULTY INSPECTION AND SELLING A LEMON BUT I FELL LIKE I AM STUCK I NEED TO KNOW WHAT TO DO FROM HERE I HAVE ALREADY PAID FOR SEVERAL THINGS THE RACK AND PINION IS THE MOST IMPORTANT I HAVE TO FIX BUT EXPENSIVE AND THE BUSHINGS AND TIE RODS ARE GOING TO BE THE NEXT THING I REPAIR I REALLY DON'T HAVE THE MONEY TO FIX THEM I AM PAYING 7000.00 FOR A USED CAR AND I FELL THAT THE DEALER AND THE INSPECTORS ARE CROOKS AND USED A FAULTY INSPECTION TO SELL A BROKE CAR PLEASE HELP. *TR

THE MOTOR FAILED ON MY 2005 VOLVO XC90 AS A RESULT OF THE COUNTERBALANCE SHAFT BEARINGS FAILING DUE TO MOISTURE IN THE MOTOR. I WAS NOT AWARE THIS MOTOR WAS SUBJECT TO FAILURE AT LESS THAN OR EVEN AROUND 100K MILES. VOLVO DEALERSHIP SAID THIS WAS THE CAUSE OF THE MOTOR FAILURE AND THEY SAID THERE WAS NO RECALL DONE. AFTER THIS HAPPENED I WENT TO SOME VOLVO WEBSITES(SWEDESPEED) ONLY TO FIND THIS SAME EXACT MOTOR FAILURE HAS HAPPENED TO VERY MANY OF THESE 2005 VOLVO XC90'S BECAUSE OF THE COUNTERBALANCE SHAFT BEARINGS FAILING. IN FACE THERE'S A FORUM CATEGORY TITLED "V8 COUNTERBALANCE SHAFT FAILURE THREAD" WHERE PEOPLE TALK ABOUT THIS EXACT PROBLEM HAPPENING OVER AND OVER AND VOLVO KNOWS ABOUT THIS ENGINE PROBLEM BUT WILL NOT DO A RECALL. SOMETHING HAS TO BE DONE WHERE VOLVO BACK THEIR PRODUCTS, ESPECIALLY THE ENGINE IN A VEHICLE. *TR

THIS CAR HAS BEEN A CONSTANT PROBLEM - I AM THE ORIGINAL OWNER AND THE COST TO REPAIR IS EXTREMELY HIGH.. I AM A RECENT WIDOW AND A SINGLE MOTHER OF 3 CHILDREN ON A FIXED INCOME... I AM SO TIRED OF THIS CAR BEING SO UNRELIABLE AND THE REPAIR COSTS ARE BANKRUPTING ME. I HAVE NO WHERE TO TURN THIS CAR HAS BEEN A LEMON FROM DAY ONE AND THE MANUFACTURER AND DEALER COULD CARE LESS. *TR