2005 VOLVO XC90 Complaints

VOLVO IS AWARE OF THE BALANCER SHAFT DEFECT THAT CAUSING A VERY PRICEY AND SERIOUS PROBLEM. THE FIX WAS TO DRILL A HOLE BUT NOT TO REPAIR ANY DAMAGE CAUSED BY THE DESIGN FLAW. I WAS INFORMED BY THE VOLVO DEALERSHIP THAT THIS IS A DESIGN FLAW IN THE 2005 CX90 AND THE COST WOULD BE AROUND $4000 TO FIX THE DAMAGE DONE TO THE BALANCE SHAFT BECAUSE OF THE DESIGN FLAW. *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE WINDSHIELD WIPERS BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC DIAGNOSED THAT THE CENTRAL ELECTRONIC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT HIS VEHICLE WAS NOT COVERED UNDER NHTSA CAMPAIGN NUMBER: 06V144000 (VISIBILITY). THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

KNOWN TRANSMISSION DEFECT WITH THIS MODEL HAS MANIFESTED ITSELF IN MY VEHICLE. CAR BEGAN LURCHING WHEN ACCELERATING AND TRANSITIONING INTO THE NEXT GEAR WHILE ATTEMPTING TO MERGE ONTO A BUSY INTERSTATE HIGHWAY. DEALER DIAGNOSED THE PROBLEM AND STATES THAT THE TRANSMISSION NEEDS TO BE REPLACED. APPARENTLY VOLVO HAS ACKNOWLEDGED THIS DEFECT WITH THE POWER-TRAIN AND IN 2012 AGREED TO SETTLE A CLASS ACTION LAWSUIT WITH REGARDS TO THIS PROBLEM. THIS FACT HOWEVER ONLY IMPACTS THOSE WHO PREVIOUSLY PAID TO HAVE THIS PROBLEM FIXED. STILL NO RECALL REGARDING THIS POTENTIALLY HAZARDOUS ISSUE FOR THOSE CURRENTLY IMPACTED. ALL VEHICLES EQUIPPED WITH THEIR ORIGINAL TRANSMISSIONS NEED TO BE RECALLED (2003, 2004 AND 2005). *TR

THE CENTRAL ELECTRONIC MODULE (CEM) WILL NOT PERFORM AS INTENDED. AS A RESULT, AUDIO SYSTEM, PARKING ASSIST, AND PASSENGER AIRBAG DOES NOT WORK. AUDIO SYSTEM TURNS ON SPORADICALLY BY ITSELF AND RUNS CONTINUOUSLY(I HAVE TO PULL OVER, TURN THE ENGINE OFF, THEN WAIT 3+ MINUTES TO STOP IT). AS A RESULT, THE FRONT WINDSHIELD WIPERS MIGHT RUN CONTINUOUSLY WHEN THE IGNITION IS ON. ALSO, THE TURN SIGNALS, HIGH BEAMS, AND HEADLIGHT SWITCH MIGHT NOT WORK. THIS ISSUE WAS RECALL 2014 VOLVO S60, S80, XC60 AND XC70. 2005 XC90 BUT IT SHOULD BE INCLUDED IN THIS RECALL BECAUSE MALFUNCTIONING ELECTRONIC SYSTEM (PASSENGER AIRBAGS, HEAD LAMPS, AND/OR TURN SIGNALS) INCREASE THE RISK OF A CRASH. IT'S NOT FAIR, WHEN SAME PROBLEM IS ACCEPTED AS REASON FOR RECALL FOR 2014 MODELS(XC60, S60, S80, XC70) BUT NOT 2005 XC90S. *TR

THE COUNTERBALANCE SHAFT BROKE RESULTING IN ENGINE FAILURE. VOLVO ESTIMATES REPAIR AT $5,0000. RIDICULOUS. WHY DOESN'T VOLVO FIX THIS WELL KNOWN ISSUE FOR LOYAL CUSTOMERS. I HAVE HAD 5 VOLVOS IN MY LIFE STARTING BACK IN THE 1980'S AND LOVE THE CARS BUT THIS LACK OF CARE FOR CUSTOMER WELFARE IS JUST WRONG. IT MAY BE MY LAST VOLVO IF THIS IS HOW THEY TREAT CUSTOMERS NOW DAYS. *TR

2005 VOLVO XC90 V8 - ENGINE NUMBER 6163 - COUNTER BALANCE SHAFT FAILURE DUE TO ENGINE DESIGN DEFECT. NO RECALL BY VOLVO DESPITE VERY HIGH VOLUME OF INCIDENTS AND THE SAFETY RISK TO DRIVERS AND PASSENGERS OF THEIR VEHICLES. NO CHECK ENGINE LIGHTS. VOLVO KNOWS ABOUT THIS ISSUE AND CHOOSES TO IGNORE IT, AUTHORITIES ARE A AWARE OF IT AND CHOSE NOT TO ENFORCE SAFETY STANDARDS ON VOLVO- "VOLVO FOR LIFE"...I THINK NOT.

WHILE DRIVING BACK FROM WORK THE PASSENGER LOW BEAM WENT OUT. I BOUGHT A NEW BULB AND THE LIGHT STILL DID NOT WORK L THEN CHECKED. THE WIRING GOING INTO THE HEADLIGHT AND THERE WAS NO POWER FOR THE LOW BEAM HOW DOES THIS HAPPEN IT WAS BAD ENOUGH I HAD TO REPLACE THE WHOLE TRANSMISSION JUST 3MONTHS AGO AND NOW THIS I ALSO READ NONLINEAR THEY HAD PROBLEMS WITH THE TRANNYS. *TR

I OWN A 2005 V8 XC90. LIKE SO MANY OTHERS I AM A RECENT MEMBER TO THE CB FAILURE CLUB. YEP. IT'S A CLUB. THE COUNTER BALANCE SHAFT FAILURE CLUB. THIS IS A DESIGN DEFECT THAT VOLVO IS AWARE OF AND DOES NOTHING TO REMEDY THE POOR SAPS WHO OWN A 2005 WITH THE FIRST 6883 ENGINES PRODUCED BY YAMAHA FOR VOLVO. AFTER 6883 VOLVO MADE CHANGES TO THE DESIGN OF THE COUNTER BALANCE SHAFT, BY DRILLING A WEEP HOLE TO LET MOISTURE OUT. UNFORTUNATELY, MY ENGINE WAS IN THE 4000S. I LIVE IN SOUTHERN CALIFORNIA. ABOUT THE DRIEST CLIMATE YOU CAN GET, BUT YET RUST HAS DESTROYED MY COUNTER BALANCE AND THUS DESTROYED MY ENGINE WITH ONLY 80000 MILES ON IT.BTW, I HAVE HAD MY ENGINE SERVICED REGULARLY. BUT THE COUNTER BALANCE SHAFT IS SOMETHING THAT CAN NOT BE SERVICED WITHOUT TEARING THE ENGINE APART. IT LIES IN THE VALLEY OF THE V8. IN MY CASE, AND IN ALL THE OTHER CASES I AM READING ABOUT, THE BEARINGS RUSTED AND THE SHAFT RUSTED AND IT TORE APART MY ENGINE BLOCK. HAD I BEEN DRIVING ON A FREEWAY WITH MY CHILDREN AND LOST POWER IT COULD HAVE BEEN FATAL. HOW IS IT THAT THIS DESIGN FLAW WHICH CAUSES CATASTROPHIC ENGINE FAILURE CAN BE ALLOWED NOT TO BE RECALLED? IN FACT, THANKS TO A OVERCHARGED ALTERNATOR, I HAD JUST PUT A NEW $1400 COMPUTER IN THE CAR. YET, THE COMPUTER NEVER READ CHECK ENGINE. WHY? BECAUSE THE COMPUTER IS NOT MONITORING THE LUBRICATION IN A SEALED BEARING. AND IT IS IMPOSSIBLE WITHOUT TEARING THE ENGINE DOWN FOR 10 HOURS (1200.00 IN LABOR) TO GET TO THE COUNTER BALANCE SHAFT TO SEE THE CONDITION OF IT. PLEASE, FOR THE SAKE OF OTHERS WHO MIGHT BE UNFORTUNATE ENOUGH TO DRIVE THIS CAR AND FIND THEMSELVES ON A FREEWAY WHEN THE ENGINE BLOWS DUE TO CHEAP RUSTED BEARINGS -- ISSUE A RECALL!!! *TR

JUST PURCHASED THIS CAR AND FOUND THAT THERE WERE RECALLS. I WOULD LIKE TO FIND OUT IF MY CAR HAS HAD THEM FIXED. THANK YOU. *TR

TL* THE CONTACT OWNS A 2005 VOLVO XC90.THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 57 MPH, ALL OF THE DASHBOARD WARNING LIGHTS FAILED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CENTRAL CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 106,000. *TR