2005 VOLVO XC90 Complaints

2006 VOLVO XC90 T6 AWD APRIL 21, 2013 APPROX 8:30 PM DRIVING AT APPROX 8:30 PM, TRAVELING AT ABOUT 55 MILES PER HOUR, REMOTE 2-LANE HIGHWAY (US191, EASTERN ARIZONA) ON TWISTY MOUNTAINOUS ROAD, SWITCHED FROM HIGH-BEAM TO LOW-BEAMS TO ACCOMMODATE ONCOMING VEHICLE APPROACHING AROUND A BEND. A MOMENT OR TWO AFTER SWITCHING TO LOW BEAMS, THE VOLVO'S HEADLIGHTS LIGHTS FLICKERED AND WENT OUT ALL-TOGETHER. ERROR MESSAGE READING SOMETHING TO THE EFFECT OF "LOW BEAM BULB FAILURE" APPEARED ON MESSAGE SCREEN. HIGH-BEAMS DIDN'T APPEAR TO BE OPERABLE EITHER. I ACTIVATED FOG LAMPS AND PROCEEDED CAUTIOUSLY TO DESTINATION (APPROX 25 MILES AWAY). APPROX 15 MILES FROM THAT POINT, I WAS PULLED OVER BY DPS PATROL ADVISING I HAD NO HEADLIGHTS...AND THAT MY LICENSE PLATE LIGHT WAS ALSO NOT OPERATING. THE NEXT MORNING, INVESTIGATED FURTHER, DISCOVERED THERE WERE NO ISSUES WITH THE HEADLIGHT BULBS (LOW BEAM AND HIGH BEAM) OR WITH LICENSE PLATE BULBS SPECIFICALLY (THEY WERE NOT BURNT OUT), NOR WERE THERE ANY ISSUES WITH ANY BLOWN FUSES RELATED TO THOSE EXTERIOR LIGHTS. I DID DISCOVER THAT THE DRL (DAYTIME RUNNING LIGHTS) WERE STILL OPERATING AS NORMAL (WHICH UTILIZE THE SAME BULB AS THE LOW HEADLIGHTS) CONFIRMING THAT THERE WERE NO ISSUES WITH THOSE BULBS. ALL RESEARCH SINCE THIS EVENT IS POINTING ME TO CONCLUSION THAT THIS MONUMENTALLY UNSAFE CONDITION WAS CAUSED BY A BAD/FAULTY CEM DESIGN BY VOLVO (ONLINE RESEARCH, SPEAKING WITH VOLVO MECHANICS AND REVIEWING SIMILAR NHTSA COMPLAINTS). THERE IS NO PREVENTATIVE MAINTENANCE THAT I COULD HAVE DONE TO PREVENT THIS FROM HAPPENING. THIS IS NOT AN OWNER MAINTENANCE ISSUE, THIS IS A DESIGN OR MATERIALS ISSUE. VOLVO SHOULD BE REQUIRED TO RECALL & REPAIR TO PREVENT THIS SAFETY ISSUE. I REQUEST NHTSA OPEN (RE-OPEN?) INVESTIGATION INTO THIS ISSUE, AS THIS VERY DANGEROUS SAFETY ISSUE THAT NEEDS ADDRESSING BEFORE MUCH WORSE CONSEQUENCES RESULT. *TR

I PURCHASED A 2005 VOLVO XC90 FOR $16,000. 6 MONTHS LATER THE ENGINE FREEZES UP. THAT COST $10,000.00 TO REPLACE THE ENGINE. LOOKED ON GOOGLE, VERY COMMON FOR THESE V8 ENGINES TO FREEZE UP. NOW THE HEADLIGHTS ARE ACTING UP. LOOKED ON GOOGLE AND FOUND THE HEADLIGHT ISSUE IS VERY COMMON. THIS WILL COST $3,000.00 TO REPAIR. THIS CAR IS GOING TO COST ME ALMOST AS MUCH TO REPAIR IT AS I PAID FOR IT!! VOLVO IS LOOSING CONTROL. I WOULD LIKE YOU TO ISSUE A RECALL FOR THESE ENGINE ISSUES AND ISSUE A RECALL FOR THESE HEADLIGHT ISSUES. PLEASE GOOGLE 2005 VOLVO XC90 V8 ENGINE AND GOOGLE THE SAME YEAR AND MODEL ABOUT THE HEADLIGHT ISSUE. YOU WILL BE ASTOUNDED BY ALL THE PAGES OF COMPLAINTS ABOUT WHAT IS SUPPOSED TO BE A GREAT CAR. THESE CARS WHERE $62,000.00 BRAND NEW, WHAT A JOKE THEY CAN SELL THIS CAR WITH SO MANY PROBLEMS. PLEASE ISSUE A RECALL. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

COUNTER BALANCE SHAFT BEARING FAILURE AND COMPLETE DESTRUCTION OF ENGINE WHILE TRAVELING DOWN A CROWDED I-95 GOING INTO NY CITY WITH TWO CHILDREN IN CAR. THIS IS SUCH A COMMON PROBLEM WITH THE VEHICLE, THAT IT'S CRIMINAL TO NOT HOLD VOLVO ACCOUNTABLE TO FIX THIS. *TR

WAS DRIVING ON FREE WAY, AS I WAS ACCELERATING I LOST ALL POWER AND STEERING.. THE ENGINE STALLED OUT AND I HAD TO VEER OFF TO SIDE SO THAT I WOULDN'T CAUSE AN ACCIDENT. *TR

AT 97000 MILES THE COUNTERBALANCE SHAFT BROKE RESULTING IN ENGINE FAILURE. SERVICE AT VOLVO SAYS I NEED A NEW ENGINE. 7000-10000 FOR A USED ENGINE. CONTACTED MANUFACTURER, WAITING FOR RESPONSE. *TR

AT 111,000 THOUSAND MILES THE COUNTER BALANCE SHAFT BEARING WENT INSIDE THE MOTOR. I DID A LITTLE RESEARCH ON LINE AND FOUND OUT THAT IT IS A DESIGN PROBLEM, THAT VOLVO KNOWS ABOUT. IT COULD COST ANY WHERE FROM $5000.00 TO $15000.00. I BELIEVE THAT THEY SHOULD BE FORCED TO DO A RECALL FOR THIS KNOWN PROBLEM, AND HELP THERE CUSTOMERS WITH THE REPAIRS. THANK YOU FOR YOUR HELP IN THIS MATTER. *TR

THE TRANSMISSION FAILED AT LESS THAN 85,000 MILES. THEN THE SECOND TRANSMISSION'S OUT-PUT SHAFT BEGAN LEAKING WITH LESS THAN 40,000 MILES ON IT, BECAUSE ACCORDING TO THE DEALER IT IS "OUT-OF-ROUND/TRUE". THE TRANSMISSION NEEDS TO BE REPLACED. THIS TRANSMISSION FLUID LEAK IS ALSO A FIRE HAZARD.

THIS COMPLAINT RELATES TO PE10025. I HAVE TO REPLACE CEM AND CASING FOR WIRING COST 5500.00. VOLVO SHOULD BE RESPONSIBLE FOR PART OR ALL OF THIS REPAIR. IT IS WATER SEEPAGE INTO THE CEM CASE. WATER DRIPS DOWN THROUGH HOOD OF THE CAR AND CORRODES THE WIRES. CAUSES MAJOR ELECTRICAL SHORTS. I CONSIDER THIS TO BE A MANUFACTURER DEFECT. WAY TO MANY CARS ARE EXPERIENCING THIS ISSUE AND IT IS EXTREMELY COSTLY. I WOULD SINCERELY WISH YOU TO CONSIDER MAKING VOLVO RESPONSIBLE. *TR

WHILE DRIVING ON A GENTLE INCLINE THE TRANSMISSION STARTED SLIPPING & SHIFTING BACK & FORTH BETWEEN GEARS. IT LOST POWER WHEN TRYING TO ACCELERATE. *TR

DRIVING IN PITCH BLACK NIGHT ON BACKROADS OF CHARLESTON, SC. LIGHTS WENT OUT AFTER LEFT HEADLIGHT FLICKERED FOR A FEW DAYS. LIGHTS WENT OUT AND CAR WENT OFF ROAD AS WE WERE IN A CURVE. REGAINED CONTROL AFTER SPINNING ON WET GRASS. I NEED THE HEADLIGHTS REPAIRED BY VOLVO AT THEIR EXPENSE AND REIMBURSEMENT FOR THE FAILED ENGINE I HAD TO REPLACE. *TR