VOLVO Complaints

I have had 5 visits with problems with engine , braking sensors, and automatic braking incidents when no obstruction is noted. Propulsion System failure has occurred 3+ times and turtle mode has come on and limited my speed to 30 MPG. It has also started bouncing and shaking while in reverse. I am extremely concerned about the safety threats and lack of consistency when taking it to be repaired.

Two different times, while stopped at a traffic light, suddenly and without cause the seat belt tensioners in the front seats activated until we released the buckles. They violently retracted into our bodies, causing chest pain and for me, a female, left breast pain. The first time was 09/15/2022. The second time was 04/22/2023. The current software is version 2.7. For the first time, the version was 2.2. To be clear, we weren't moving at all, nor was the car in line in front of us. We notified Volvo after the first time and will do so again now.

There is a know issue with suspension that Volvo is not addressing. XC 60 owners are reporting the car was shuttering and vibrating heavily under acceleration or coasting at different speed (at 30K miles). This is getting more severe with increased mileage. Volvo has redesign the CV joint, but has not advised owners. The issues: 1- The right drive axle had a play 2- Front Prob drive shaft CV Joint is defective: The dealer showed me the new redesigned version where it is marked with a green line. If you don't see the green line on your prob shaft, this means you might have the old design one and will probably be defective. Volvo has redesigned but not replacing the defective part. The vibrations becomes more severe with increased speed and adversely effects steering, maneuverability and control on the vehicle.

The affected component is part of the exhaust aftertreatment system, also known as the selective catalytic reduction (SCR) system. These systems were implemented in nearly all Class 8 truck engines in the U.S. to meet 2010 emissions standards. The degradation could put the engines out of compliance with emissions standards. This is a very costly repair in excess of $10,000 in a truck with only 466,000 miles on it. we have had in many times and lots of repair cost to try to keep the truck in compliance and continues to go in Derate.

The contact owns a 2010 Volvo XC90. The contact stated while driving 70 MPH, the vehicle stalled with the check engine warning light illuminated. The contact attempted to restart the vehicle, but the failure persisted. Due to failure, the vehicle was towed to the residence. An independent mechanic arrived at the residence and discovered a leak in the fuel line. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 10V147000 (Fuel System, Gasoline). The vehicle was not repaired. The failure mileage was approximately 125,000.

Water leaking every time it rains. Running down the windshield on the inside and making it difficult to see and dangerous as I’m having to wipe while I’m driving.

Got into my car, pulled out of a parking spot and approached a stop sign. The brakes suddenly became extremely mushy and the brake peddle went all the way to the floor. I didn't notice an issue when I pulled out of the parking spot. I was unable to continue driving as the brakes were not usable. I had the car towed to the dealer and they indicated the brake booster and vacuum pump failed due to "normal wear and tear". The vehicle was purchased at, and always maintained at our local Volvo dealer. Luckily no accident occurred.

My truck is going to neutral When ever I slow down and about to make a turn or for a stop light , and will not ho back in gear . Until I fully stop and put it in gear again - causing big problems -

Vehicle caught fire after exiting freeway. Warning light turned on to check oil, immediately followed by smoke and flames from engine bay. Driver exited vehicle, call 911, fire was dispatched and extinguished fire. Vehicle suffered extensive fire/smoke damage and is a total loss.

The contact owns a 2023 Volvo XC90. The contact stated that before exiting the vehicle, he pressed the park button and the vehicle inadvertently started to reverse. The vehicle was taken to a dealer where the vehicle was diagnosed but no cause for the failure was found. The contact stated that the gear shifter and parking brake failed to engage as needed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,000.