VOLVO Complaints

Fuel gauge doesn’t show actual fuel level. When full, it shows 50% left, and gauge doesn’t start to move till half the tank is empty.

In April 2021 I drove my newly acquired Volvo V70 wagon from Mississippi to my home in RI. Once I reached in and around NYC, the car began to surge forward as I applied the brakes at stop lights/signs. This became most pronounced at the GW Bridge Toll area, in high slow-moving traffic. Several times the car almost got out of control as the brakes were barely enough to stop the car from ramming into other vehicles. Cars and huge trucks were honking their horns as I broke, swerved, smoke clouds from high idling in neutral, and peeling rubber as I moved forward from standing still. I was trapped as there is no place to pull over to the sides to a breakdown lane. It eventually stopped surging but has threatened to do it in RI. I asked the mechanic about it when I had to get the car inspected. He basically said he would have to see the vehicle when it was happening. I am just funding out about Recall information and filing a report. I really want to have any necessary repairs made because the car performs well otherwise...AND I am hoping to give the car for my daughter to use as she starts her new job, but want to make sure it is safe first. I feel I would know how to handle it if it surges again (throw it in neutral, brake and pull to safe place, etc), but can't trust that she would be able to handle this emergency situation.

The gas gauge no longer reports accurate level of fuel in tank. Thousands of people have reported this issue, yet no recall exists, though this endangers lives - especially in the deserts of the southwest. Volvo service quotes are aways ripoffs, quoting $3000 minimum.

The sub frame located near the front exhaust has premature rust and corrosion to the point there are holes in the frame.

I purchased the 2009 Volvo on 10/5 at M&M Auto Sales LLC and on 10/9 at 6:20 am my vehicles check engine light turned on and a transmission service urgent light turned on. On 10/11 I went to AAMCO and they informed me that the transmission needed repairs costing up to 4k. When I purchased the car the dealership disclosed to me that the vehicle is in perfect condition. As of 10/21 I went to a Mechanic Shop called Pegoraro and ran a full auto diagnostic on the vehicle. With repairs on the vehicle costing $12,433.03 which involve fixes to the Timing Belt, Cooling System Fluid Exchange, Drive Belt Tensioner/Idle Assembly, Automatic Transmission Assembly, Remove and Install, Brake Fluid Exchange, and Lastly Disc Brake Pads, Rotors and Calipers (Rear). Obviously the vehicle isn't in "perfect condition". After getting this diagnostic I was informed that the vehicles Odometer has been tampered with as well as a bunch of other codes have been turned off before I purchased this vehicle. I just want a refund for this vehicle and to take my business elsewhere.

When top is down, at highway speeds, the driver-side door becomes ajar, interior light comes on and window goes down 1/2 inch. This seems to happen about 20 minutes into the drive. Will happen multiple times on long drives. This only seems to happen when the convertible top is down. Driving at highway speeds and having the door go ajar is not safe. Not sure why Volvo never took this seriously, as its reported by many others on the internet - same exact issue. Reported to Volvo (Leiken Volvo Cars Cleveland), they cannot reproduce and said everything looks correct. Offering to replace the lock mechanism. The issue is easy to reproduce, but just driving with the top down for longer than a 20 minute period.

Takata recall. The contact owns a 2001 Volvo S80. The contact received a notification for NHTSA Campaign Number: 21V766000 (Air Bags). The dealer had been notified about the recall; however, the contact was informed that the part was not yet available. The manufacturer was then notified and informed him that they were unaware of when the parts may have become available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnection.

Water is leaking down the inside of the windshield while driving in rain. It comes from the top edge and streaks down the drivers side (left side). I spoke with a mechanic that services my vehicle and was told if it was a sunroof drain issue it would be coming down the pillars and getting on the floor. They were confident that it was the windshield that was leaking and referred me to a local auto glass business for repair. I read on a car forum about other Volvo car owners having the exact same problem with their Volvos that are around the same age as mine. It seems to be a glass adhesion failure that consistently occurs on the top edge of the Volvo OEM windshields. The forum is located at https://beranek.agrrmag.com/2015/04/volvo-glass-bonding-issue/ I also contacted Volvo about what I had found and having it covered by them, and they asked me to first get it inspected by a Volvo dealer before they would decide whether or not they'd pay for the repair. I spoke with someone in the service department of my nearest Volvo dealer and they wanted to charge me $300 just to inspect it. The date of the incident I'm giving below is the date that I first experienced the water running down the inside of the windshield while driving. Thankfully I had something within reach to wipe it with as I was doing 60 MPH on the interstate highway.

The subframe is rotting prematurely and this issue is only present on the v8 equipped models. Cars in very good shape but the subframe is almost rotted totally through above the exhaust. Due to the poor layout of the exhaust which causes the paint on the welds to flake off and then the subframe begins to rust from the inside out.

I was driving down the freeway and the driverside door swung open while it was locked. This is after the door handle recall repair was performed. Prior to the recall repair, my door never came open like that while drving. This is dangerous because I could have fallen out, or a car could have hit my door! Also, the windshield leaks on the inside and has been doing that for a long while. Volvo service said it does not leak. It does leak when raining or ice/snow melt. This is dangerous because windshield wipers do not work on the interior part of the window to wipe away water so the driver can see.