VOLVO Complaints

The contact owns a 2002 Volvo S80. The contact received notification of NHTSA Campaign Number: 20V681000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer was notified and informed the contact that the part was not yet available. The vehicle was not repaired. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The brake rotors exceed the manufacturers run out specifications and tolerances. This has been happening vehicles as early as 2018 model year. In my specific case I bought the car with 3600 miles on it as a certified vehicle from a Volvo dealership. On my drive home I could feel the braking pulsation in the steering wheel. The dealership measured the run out and it exceeded the manufacturers specification on all four corners. I then joined a Facebook Volvo owners group and found out there are several members that have had their rotors replaced by the dealer in many cases multiple times because they are either installing a non-conforming brake rotor or the part becomes defective with use well within the warranty period. If the vibration caused by the rotor run out continues to increase without mitigation it may cause the brake pads to deteriorate at a high rate reducing stopping distance or cause the vehicle to swerve.

I would appreciate your deepest consideration for assistance with the problematic rear differential on the 2010 XC70 Volvo. I have spent considerable funds to maintain my vehicle at top working order through maintenance at Volvo. I have always asked the Volvo advisors for service recommendations on the vehicle to keep my car running economically to ensure main components did not fail due to lack of maintenance. Therefore, when I learned that my rear differential is failing and there is no recommended service on that particular part which can be seen on the Maintenance Service manual below, there seems to be a lack of knowledge shared on this part. Unfortunately, I just started to look into this matter once my rear differential starting to fail, this knowledge was not shared to me during regular periodic maintenance, my Volvo Service advisors never recommended changing the rear differential oil. Moreover, it is a known defect for Volvo cars built throughout the years of 2008-2014. Volvo and Land Rover use the same part and there are many examples of this happening to Volvo owners around the mid-90K mile range. The cost is extremely expensive at an estimated $5,580.00. Please look in to this matter, this should be a national recall for this vehicle!

On 3 occasions the brakes were seized when attempting to drive the car after being parked if the brakes had gotten wet prior to parking. There is a loud clunk and even at times grinding. The pads/rotors were replaced 2 times and it is going back in for the third time. Each time brake pad material broke off. This compromises the braking capability of the vehicle if the pads have pieces missing.

door opened on its own while driving. three times this week. door appears locked and warning illumination indicator does not recognize that door is open. door cannot be locked when in this condition but it indicates that it is locked. appears identical to issue in NHTSA campaign 19v849000.

The contact was test driving a 2022 Volvo XC40 equipped with Pirelli tires. Tire Line: Pirelli, Tire Size:2255/40R20, DOT: Not available. The contact stated while driving at 3 MPH and making a turn in her driveway, the vehicle bumped the curve and the driver-side rear tire blew out. The contact stated it was the original tire. The dealer was notified of the failure. The manufacturer was notified of the failure and advised the contact that they will follow up on the failure. The tire was replaced. The vehicle failure mileage and the tire failure mileages were unknown. The VIN was not available.

The contact owned a 2021 Volvo XC60. The contact stated that while driving approximately 25 mph, the vehicle suddenly began to accelerate and the brakes failed to stop. The vehicle crashed into a nearby fence causing the vehicle to flip. The air bags did deploy. The contact received injuries to their right shoulder and left knee. Medical attention was needed. A police report was filed. The vehicle was towed and had not been deemed totaled as of yet however, damage to the vehicle would be considered unrepairable. The dealer was informed of the incident however they were unable to assist. The manufacturer was not made aware of the failure. The approximate failure mileage was unknown.

I leased the vehicle in December, 2020. Periodically while the tailgate is open and I am underneath it, the tailgate has closed on me and hit me in the back. In February, 2021, the struts on the tailgate were replaced at Patrick Volvo, Fort Myers, Florida, after I received a recall letter from Volvo. On September 9, 2021 at approximately 11:00 a.m. (CST) I was under the opened tailgate and it closed three times in a row and hit me in the back. Each time that it hit me, it reversed direction and went back into the open position. I was not injured but my back was sore for the rest of the day. I brought the SUV into Patrick Volvo, Shaumburg, Illinois. The service representative (SR) explained to me that there is a sensor under the rear bumper that will open and close the tailgate if you waive your foot under one specific location. Which is approximately two feet from the left edge of the bumper. The SR explained to me that I must have accidentally waived my foot under the bumper and the sensor caused the tailgate to close. He further advised that it could not be deactivated. On September 18, 2021, at approximately 10:00 a.m. I was sitting in the cargo area putting on my golf shoes. The tailgate started to close. I ran as fast I could and avoided getting hurt or injured. My feet were not capable of engaging the sensor as they were in front of the bumper. I have advised Volvo Customer Service and Patrick Volvo of this new safety concern. Patrick Volvo has stated to me that they have never had this problem on any of their SUVS. They also do not know what is causing it. They are waiting for a loaner SUV to come back to their dealership and then I will bring the vehicle in, so they can attempt to solve this safety issue. In the meantime, I have to be very cautious when the tailgate is open. My fear is not only that it will hit me, but more so that it will not reverse direction and close on me.

On 9/8/2021, Niello Volvo Sacramento service replaced my fuel pressure sensor and fuel line. On 9/15/2021, my engine caught fire and the car was deemed a total loss by insurance company. I drove from my home in Plumas Lake 95961 to Marysville approximately 10 miles away at 9:50 AM, at approximately 10:00-10:05 as I was nearing the end of my trip, a trouble light came on that said “engine performance decreased” and the picture of a turtle appeared on my dash screen, shortly after that another light appeared that said “battery not charging”, I parked my car in the Save Mart parking lot and exited and noticed some smoke coming out of the hood, it was light at first but increased quickly so I called 911 immediately. As I was on the phone with 911, flames began shooting out from under the hood, so I grabbed my fire extinguisher out of the back of my car and tried to put the fire out, but extinguisher was too small, a man from the grocery store brought out a bigger extinguisher, but fire continued to grow, by now the fire dept. arrived, opened the hood and after about 10 minutes extinguished the fire with a hose. I contacted Niello Volvo but they seemed disinterested in getting involved and after a second call to them, the service manager [XXX] hung up on me. I could have been killed! If my elderly husband or mother had been in the car with me, it would have been difficult to get them out! I want to know what caused the fire! Faulty electrical system, faulty fuel sensor/fuel line which had just been installed 7 days prior? Faulty engine? There are still many 2015 Volvo XC60’s on the road and I fear for anyone driving one if there is a problem in need of recall. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The "passenger side door open" indicator suddenly showed on the dash while driving approximately 50MPH. As I slowed down , I asked my wife that was in the passenger seat to make sure her door was properly shut. The door opened right up without unlatching, she then promptly shut it and made sure it was secure. About 45 minutes later the same thing happened again. After investigating, I found this is a common issue with certain Volvo models. recalled for some models, not recalled for my model.