2021 VOLVO XC60 Complaints

Hood latch assembly corrodes making it impossible to open hood or service the vehicle.

My SUV has a had the check engine light on from a failed battery cell for my 2021 grey Volvo XC60 recharge (VIN [XXX]). I have been without the electric functionality (to charge the hybrid car or use electric power) since mid December and waiting on a warranty part since Dec. 23, 2025. I have been told April 2026 and then August 2026 for this warranty issue that both the dealership and Volvo corporate have agreed is under warranty and needs replaced to make the car functional as intended. They claim the part as been backordered for the entire 8 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After backing up out of a parking space, the side mirror on the drivers side moves to an unpredictable position and does not return to its original position. This is potentially dangerous because the driver is not aware of this change in position, and when changing lanes may rely on mirror that is in a faulty position. This appears to be some sort of flaw in the logic that tilts the mirror down when backing up and returns to original position when the car is put back in drive. Regardless of whether I turn this feature on or off, the same malfunction occurs.

The entire right ride of the car just stopped working. Back right door became permanently locked and could not open from outside or inside. When hitting lock/unlock buttons on key fob i) front passenger door would not lock/unlock and ii) right side mirror would not fold in/out. Blind spot monitor and TPMS said they needed service. Left side of car was fine and worked. Car would start normally. I checked all relevant fuses and none were blown. Then all of a sudden it all started working again. My fear is that in the heat of summer what if all doors became locked somehow and i did not have the key fob with the manual key? I have 2 children

An intermittent electrical failure occurred to my wife causing my 2021 Volvo XC60 to stop and then later go into limp mode while driving. The service light went on immediately and was very startling to her and made it difficult for the drivers following as the car speed was significantly reduced/ I suspect limp mode though it was not on the dashboard. When I called Volvo and then brought the car in... it is a known issue to Volvo. They purposively produce a vehicle that is known for sunroof leaks which knowingly leads to electrical issues exposing their customers to harm. Volvo (Geely) inspected the car, found the electrical issues from the front interior to the battery compartment that had water over an inch deep. the VGM (Vehicle Gateway Module) was replaced and reloaded, all connectors were separate/dried and several had to be cut/spliced and rewired due to corrosion damage. Carpets were removed, the gasket was replaced, the front and rear sun roof drains were cleaned out. Aside from the safety concern the shrinking of the rubber gasket caused the issue. Not funny, but Volvo/Geely states that the repair now has a lifetime warranty after I was charged over $4,000 USD. The vehicle is only about 5 years old!!

My 2021 Volvo XC60 experienced a fuel system failure at approximately 53,500 miles. Prior to the failure, the vehicle displayed multiple warning messages and entered reduced-power (limp mode), including the turtle symbol on the instrument cluster. The vehicle unexpectedly would not start despite multiple attempts. The failure occurred while I was at a physical therapy appointment approximately 25 minutes from my home. After approximately 10 minutes, the vehicle started and was able to be driven. Because of the warning messages, limp mode, and failure-to-start condition, the vehicle was taken to a Volvo dealership for diagnosis. The Volvo dealership diagnosed the vehicle with ECM fault code P008A00 (Low Fuel Pressure). According to the repair invoice, testing confirmed that fuel pressure was intermittently low, and the dealership determined that the in-tank fuel pump was faulty. The fuel pump was replaced to correct the condition. This failure created a safety concern because the vehicle became unexpectedly inoperable and would not start when needed. Had the failure occurred in a remote location, during extreme weather conditions, at night, or in an emergency situation, it could have left the vehicle occupants stranded without reliable transportation. The inability to start the vehicle occurred without warning and could have resulted in a more serious safety risk under different circumstances. The issue was reproduced and confirmed by an authorized Volvo dealership, which inspected the vehicle, diagnosed the fault, and replaced the fuel pump. Repair records are available for inspection upon request. The failure occurred at approximately 53,500 miles, which is relatively low mileage for a major fuel system component. Because fuel pump failures can render a vehicle unexpectedly inoperable, I am submitting this complaint for review and investigation.

Multiple times, with the Pilot Assist system engaged, the vehicle has pulled me out of my intended travel lane when on a curve, near an on / off ramp, and generally tends to drift from the left to right of the intended lane of travel on straight sections of road. It will drift to the rumble strip and sometimes into the next lane with both hands firmly on the wheel. I find myself fighting the system at these times. When it gets confused, with corners or merges, and on / off ramps, it will abruptly change lanes which is very dangerous. Twice it almost caused an accident. I have had it looked at many times now by Gengras Volvo in East Hartford where I bought the car. I was provided a loaner each time but the car has been in their shop for close to a month over these visits. It happend on one test drive with their repair tech driving the car, so the issue has been verified and recorded by Gengras. Multiple components of the system have been changed out and Volvo has downloaded and reviewed the telemetry twice. Volvo's stance is that the system is functioning correctly, and in times if inclement weather it may not work as intended. Most of my incidents happened on dry roads. Upon researching this on the internet, there are many other owners of Volvos of my year and others complaining of the exact same issues and behavior of the car. I feel it may be a design flaw but in my opinion the system is not safe to use. Volvo went to a completely different system soon after 2021. This was a very expensive option to purchase on the vehicle. We have a similar system in our Acura that works flawlessly on the same roads in any weather condition. I bought this vehicle certified by Volvo with roughly 15K miles for my son to drive when he had just gotten his license as Volvo has an incredible reputation for safely. I do not feel safe with him driving this vehicle as was intended. Latest diagnosis attached, Remainder available from Gengras Volvo, East Hartford CT.

After 5 times of phantom breaking at high speed I took the car to Betten Volvo. The did a system update to try to correct. The car has now 3 times in 2 weeks again triggered the break at highway speed. I have another appointment scheduled April 21, 2026. Having the brake applied for no reason at this speed is extremely jarring and dangerous.

The driver's side mirror repositions itself downward, upward, or outward when unlocking and opening a door. It infrequently repositions while driving as well. These occurrences put me and others at risk by increasing my blind spot when I need to change lanes. Two Volvo dealers have reproduced the mirror changing positions when unlocking and opening the door, but a few times they were not able to get the car to reproduce it. Technicians have performed software updates, deleted and reprogrammed the keys to the car, and performed a factory reset on the infotainment center to no avail.

Exiting a parking lot, attempting to break. The plastic break pedal cover fell off and was unable to break in time to avoid a front end accident.