VOLVO Complaints

TAKATA RECALL NOTHING HAS HAPPENED AS OF YET, BUT A WARNING LIGHT IS ON TELLING ME THERE IS SOMETHING SERIOUSLY WRONG WITH THE AIRBAGS AND NEEDS IMMEDIATE ATTENTION. BEFORE I TAKE IT IN & PAY FOR THE REPAIR I NEED TO KNOW IF THIS VEHICLE WAS PART OF THE RECALL. I COULDN'T SEE IT ONLINE BUT I AM CERTAINLY CONCERNED

2005 VOLVO V50 HAS INTERMITTENT STARTING ISSUES. THE ENGINE CRANKS AND FUEL PUMP CAN BE HEARD WHEN KEY IS TURNED IN IGNITION BUT THE ENGINE DOES NOT TURN OVER/START. AFTER 10-15 (SOMETIMES MORE) ATTEMPTS AT STARTING THE VEHICLE, FUEL PRESSURE APPEARS TO BUILD SLOWLY WITH EACH ATTEMPT AND THE ENGINE WILL SOMETIMES START. IF THE VEHICLE DOES START IT IS OPERABLE WITHOUT ADDITIONAL PROBLEMS AND CAN BE DRIVEN NORMALLY. THE CAR WILL RE-START WITHOUT ISSUE IF THE ENGINE HAS RUN WITHIN A FEW HOURS OF THE ATTEMPT. AFTER 24-36 HOURS OF BEING OFF THE VEHICLE WILL HAVE DIFFICULTY STARTING AGAIN. I BELIEVE THE PEM (PUMP ELECTRONICS MODULE) IS FAULTY IN MY VEHICLE - VOLVO ISSUED RECALL 190 TO ADDRESS THIS BUT NOW REFUSES TO REPAIR MY VEHICLE OR PROVIDE ME WITH DOCUMENTATION SUFFICIENT TO ENSURE ME THAT MY VEHICLE IS NOT COVERED BY THIS RECALL CAMPAIGN.

CONSTANT PROBLEMS/FAILURES WITH START/STOP FUNCTION. CAR'S ELECTRICAL SYSTEM WILL COMPLETELY SHUT DOWN FOR NO REASON WHILE IN TRAFFIC AND ENGINE WILL NOT RESTART. CAR HAS TO BE SHUT OFF AND SYSTEM HAS TO BE RE-BOOTED. DEALER SERVICE DEPT CAN FIND NO PROBLEM. MOST RECENTLY, CAR'S STARTER MOTOR FAILED AND HAD TO BE REPLACED UNDER WARRANTY BY THE DEALER. HAVING THE CAR'S ENGINE START/STOP SYSTEM CONSTANT FAIL IS A SERIOUS SAFETY RISK. WE HAD SERVERAL NEAR-MISS ACCIDENTS CAUSED BY THIS FAILURE. THE WORK AROUND HAS BEEN TO MANUALLY DISABLE THE START/STOP FUNCTION, WHICH HAS TO BE DONE EACH TIME THE CAR IS STARTED FOR THE FIRST TIME.

BD44 SRS AIR BAG TRIM HAS BECOME LOOSE ON THE BACK OF THE STEERING WHEEL RESULTING IN A SHARP HARD PLASTIC BEING EXPOSED RESULTING IN THE DRIVER CUTTING HIS FINGER ( DRAWING BLOOD) WHILE DRIVING ON THE HIGHWAY. SIGNIFICANTLY DISTRACTED THE DRIVER AS HE REMOVED ONE HAND FROM THE WHEEL IN RESPONSE TOM THE CUT. APPARENTLY THE GLUE FOR THE TRIM IS INADEQUATE TO KEEP IT SAFELY SECURED.

THE SUV HAS HAD LOTS OF PROBLEMS WITH THE ENGINE. THE ENGINE HAS STOPPED WITHOUT WARNING NUMEROUS TIMES WHILE IN MOTION. IT EVEN STOPPED ONE TIME ON THE HIGHWAY. THE VEHICLE LOSES POWER IN AN INSTANCE AND FEW TIMES WE HAVE HAD TO TOW THE VEHICLE TO OUR HOUSE AND TO THE DEALERSHIP FOR REPAIR. EVEN THOUGH THIS PROBLEM HAS OCCURED OVER AND OVER (WHICH THE DEALERSHIP HAS ATTRIBUTED TO THE PISTONS MISFIRING), THE DEALERSHIP CAN NOT SEEM TO REPAIR THE ISSUE. WE HAVE ASKED DEALERSHIP/VOLVO TO BUY BACK THE VEHICLE AS IT IS NOT DRIVEABLE AT ALL. EVERYTIME WE GET THE VEHICLE RETURNED AFTER THE REPAIR FROM THE DEALERSHIP, BETWEEN 100-300 MILES THE ENGINE LIGHT COMES ON AGAIN AND MAKES THE SUV NOT DRIVEABLE. WE HAVE COMPLAINED NUMEROUS TIMES TO THE DEALERSHIP TO NO AVAIL. THE SERVICE MANAGER HAS CONFIDED IN US THAT THIS ISSUE HAS OCCURED ON ALMOST ALL THE VOLVO XC90 FROM 2016 AND ONWARDS.

AFTER 30 MINUTES OF HIGHWAY DRIVING EXITED ONTO SECONDARY ROAD TO ADD OIL FOR LOW OIL LIGHT INDICATOR. ENGINE BEGAN SMOKING IN TWO MINUTES AND LIFTING HOOD CAUSED ENGINE TO BURST INTO FLAMES. CHEMICAL FIRE RETARDANT SPRAYED WITHIN THREE MINUTES. RESULT WAS INCINERATED ALTERNATOR AND ALL CODES ALARMED. CAR TURNS OVER. FUSES GOOD.

NEW VEHICLE (LESS THAN 19000 MILES) - VEHICLE WAS STATIONARY - IN A PARKING LOT, IGNITION OFF. APPROXIMATELY 10 TO 15 MINUTES LATER, FIRE IGNITED IN ENGINE BAY, RAPIDLY SPREADING TO THE WHOLE CAR... ENTIRE CARE BURNED TO SHELL.

THE CAB SUSPENSION IS AFFECTED BY SOME TYPE OF MANUFACTURE FAULT, THE CAB IS TWISTED 3 INCHS TO THE LEFT. I HAVE SEEN THE SAME COMPLAINT OF OTHER VOLVO'S VNL MODEL OWNERS. THIS IS A SAFETY CONCERN AND REALLY NEED A ATTENTION.

DRIVER DOOR OPENS WHILE DRIVING. IT HAPPENS WHILE LOCKED OR UNLOCKED, TOP UP, WINDOWS UP. IT HAS HAPPENED IN CITY AND ON HIGHWAY. TRAVELING AT HIGH SPEEDS AS WELL AS LOW SPEEDS. IT COMES AJAR AND THE INTERIOR LIGHT COMES ON AND MESSAGE THAT DRIVER DOOR IS OPEN.. IT HAPPENS INTERMITTENTLY BUT IS BECOMING MORE AND MORE FREQUENT UNTIL NOW IT IS ALMOST DAILY. IT BEGAN PROBABLY 2 YEARS AGO

PRIOR TO LATEST INCIDENT, THE CAR HAD OCCASIONALLY GONE INTO "LIMP" MODE, STICKING IN 3RD GEAR BUT DRIVABLE. THAT PROBLEM WOULD GO AWAY AFTER A DAY OR SO. LOCAL SHOP COULDN'T FIND ANYTHING DEFINITIVE. BIGGER PROBLEM WAS YESTERDAY EVENING'S LOSS OF THROTTLE CONTROL AND MULTIPLE ELECTRICAL ISSUES. IDLE THROTTLE SETTING (EG STOPPED AT LIGHTS) BECAME UNSTABLE, OCCASIONALLY REVVING UPTO TO ~2000RPM. MOMENTS LATER ON SUBURBAN DIVIDED MAIN STREET, THROTTLE STUCK AT ~2200RPM WHICH MEANT I WAS DOING 45MPH (STRAIGHT LINE) WITHOUT ANY PRESSURE APPLIED TO GAS PEDAL. SLOWED ON THE BRAKES UNTIL I SHIFTED INTO NEUTRAL AT WHICH TIME EVERYTHING DIED (ELECTRICAL) AND CAME TO A STOP, SHORT OF TRAFFIC LIGHTS. TIME OF INCIDENT APPROX 8PM EST (DARK), ROADWAY FULLY LIT THANKFULLY. CAR WAS PUSHED OFF STREET. SOME ELECTRICS CAME BACK ON WHEN TRIED BUT FULL CHRISTMAS TREE LIGHTS (IE EVERYTHING) ACROSS ENTIRE DASH. TOWED HOME. REMOVED IGNITION KEY (WAS INSERTED TO ENSURE STEERING WAS UNLOCKED) BUT RADIATOR COOLING FAN REMAINED ON (ENGINE HADN'T RUN FOR 2.5 HOURS BY THAT TIME). PULLED A FUSE UNDER THE HOOD TO STOP IT DUMPING THE BATTERY. CAR IS NO YOUNGSTER, MANUF 2003 IN NETHERLANDS, PURCHASED SECOND HAND IN 2005 WITH APPROX 20,000 MILES ON THE CLOCK. CURRENTLY AT 108,000 ISH. OTHER ISSUES WITH CAR (NOT SAFETY RELATED) MEANS I WONT BE HAVING IT FIXED GIVEN ITS AGE AND GENERAL COSMETIC CONDITION. IT WILL BE DONATED FOR SCRAP.