VOLVO Complaints

I am reporting a failure of the fuel pump system in my Volvo vehicle, which currently has approximately 60,000 miles. The failed component is available for inspection upon request. The issue was confirmed by an authorized Volvo dealership, which diagnosed the fuel pump as defective and requiring replacement. This appears to be a premature failure given the mileage and proper maintenance of the vehicle. This failure presents a serious safety risk. A faulty fuel pump can cause the vehicle to stall unexpectedly while driving, increasing the risk of a crash, especially at highway speeds or in traffic. Loss of engine power without warning places not only the driver and passengers at risk, but also other motorists on the road. Prior to the failure, the vehicle experienced symptoms consistent with fuel system issues, including difficulty starting and intermittent performance irregularities. These symptoms escalated until the vehicle became unreliable to operate. The problem has been confirmed by the manufacturer’s authorized service center, and the vehicle has been inspected accordingly. No external factors or misuse contributed to this failure. It is my understanding that Volvo has issued recalls and/or acknowledged similar fuel pump defects in other vehicles of comparable models and years. Based on the nature of this failure and its alignment with known issues, I believe this vehicle should be evaluated for inclusion under an existing recall or be subject to further investigation. Given the safety implications of fuel system failures, I respectfully request that this issue be formally reviewed to determine whether a broader defect trend exists that could impact other vehicles. The failure occurred at relatively low mileage and under normal operating conditions, raising concern of a systemic defect rather than normal wear and tear.

At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.

The car’s infotainment system repeatedly freezes and force restarts which causes the HVAC system to stop working and the windshield defroster to stop cleaning fog and frost leading to poor visibility.

My infotainment system continues to fail as well as my back up camera (happened within 10 minutes of driving off of the lot when purchased) despite all of the software updates they claim will fix the problem, including the most recent March 2026. Since this update, the failures have increased in frequency to multiple times in a single ride lasting 15-20 minutes. The car has subsequently landed back at the dealership since last Thursday with no answers on how to fix the problems. I am currently in a loaner car waiting for the dealership to hear back from Volvo corporate. It's Saturday and my new car is sitting outside in the weather with no fix in sight. After paying almost $60,000 for this vehicle, I'm feeling duped and gaslit and frustrated. I've been a loyal Volvo customer for years (4th Volvo, 3rd XC 60) and not had any issues, so I'm feeling confused, disappointed, and as mentioned frustrated.

The failure involves the instrument cluster (driver information display) on my 2017 Volvo XC90. This component is responsible for displaying speed, warning indicators, and all critical driving information. The failed component remains installed and is available for inspection. The issue began while driving on public roads. The display intermittently showed distorted, “barcode-like” patterns that would appear suddenly, disappear, and then return. The condition progressively worsened over time. The failure is now consistent and reproducible. When starting the vehicle, the cluster may appear normal for a few seconds before becoming severely distorted or completely unreadable. Now it is nonfunctional from the moment of ignition. This creates a significant safety hazard because I cannot view speed, warning lights, gear position, or any system alerts. The initial failures occurred while the vehicle was in motion, which increased the risk at the time of occurrence. The vehicle is not safely operable in this condition. The vehicle has approximately 24,000 miles, has never been in an accident, and has been properly maintained. There were no external factors that could explain the failure. The only prior symptoms were the intermittent display distortions described above. An authorized Volvo retailer inspected the vehicle and diagnosed the instrument cluster as failed, recommending replacement. No repair has been completed. Volvo Car USA declined goodwill assistance despite the extremely low mileage and safety-critical nature of the failure. I am aware of similar instrument cluster failures reported by other 2016–2017 Volvo XC90 owners, suggesting this may be part of a broader pattern.

The vehicle experienced a major electrical system malfunction involving multiple critical components. The issue began with the Volvo On Call system light remaining illuminated continuously, which suggested a possible communication or battery-related fault. Shortly after, additional systems failed, including the turn signal system, windshield wipers, and high beam headlights. These components are currently non-functional and can be made available for inspection upon request. The failure significantly impacted vehicle safety. The loss of turn signals made it impossible to properly indicate lane changes or turns to other drivers, increasing the risk of collisions. The failure of the windshield wipers created a serious hazard in adverse weather conditions, reducing visibility. Additionally, the loss of high beam headlights limited nighttime driving visibility. While daytime running lights and hazard lights remain functional, they are not sufficient substitutes for the failed systems. The problem has been consistent and reproducible. Each time the vehicle is operated, the same warning messages appear, including “Turn Indicator System Malfunction” and “Wiper Failure – Service Required,” and the affected systems do not respond. At this time, the issue has not yet been formally confirmed by a dealer or independent service center, but diagnostics codes (including communication-related fault codes) have been observed. The vehicle has not yet been inspected by the manufacturer, law enforcement, or insurance representatives. However, based on the symptoms, the issue appears to involve a failure in the vehicle’s central electronic or communication control systems. Prior to the complete failure, warning signs were present. The Volvo On Call light remained on persistently, indicating a potential underlying electrical or module communication issue. This warning appeared before the loss of the turn signals, wipers, and high beams, suggesting a progressive system failure.

I am reporting an ongoing and worsening defect condition involving a Volvo vehicle that has displayed repeated power steering / steering failure warnings and is now also showing additional symptoms consistent with a possible turbo / emissions-related failure. The steering-related warnings have remained active and unresolved over an extended period. The vehicle has displayed dashboard warnings for “Power steering” and “Power steering failure,” and the condition has not been reliably corrected despite prior service involvement and an ongoing repurchase dispute with the manufacturer. More recently, the vehicle developed additional failure symptoms consistent with a turbo / wastegate / emissions-related problem, which appears to be worsening. This is in addition to the pre-existing steering-related warnings and drivability concerns. I am filing this complaint because the manufacturer, Volvo Car USA, and its administrator, Sedgwick, closed the repurchase claim while these safety-related issues remained unresolved. I explicitly stated in writing that I had not declined the repurchase and remained willing to proceed once material questions were answered, but the file was closed anyway. This complaint is being submitted to document that the vehicle continues to present unresolved and worsening defect conditions, including steering-related warnings and additional drivability / emissions-related issues, despite the manufacturer’s closure of the repurchase process.

While driving the car the car will suddenly stop working, it will be unable to accelerate. When this happens a multitude of alerts display on the screen. The car is very dangerous to drive and I’m concerned someone may die if this car is not recalled for safety.

My vehicle was recalled for a faulty battery module. I turned the car into the dealer (Palo Alto Volvo in Palo Alto, Ca) on December 18 and the dealer has not been able to provide any ETA on repairs.

I drove the car (2021 Volvo XC 90) without incident on Sunday March 8, 2026 and at the end of the day parked the car in my garage. Monday morning, I came out to use the car and found that the seat back on the driver’s side had folded all the way forward and was immovable in a position that was unsafe to drive. Had the seat spontaneously folded all the way forward while I was driving, it would have pitched my body into the steering wheel and the results could have been catastrophic. At the time of the incident my car was approximately four years and seven months old from date of purchase with just 30,315 miles on it. Volvo reported that the seat-back motor had failed and needed to be replaced. The Cost was $1249.82. Volvo offered no explanation of the seat-back motor failure but stated they were aware of one other similar incident. I have no details of that incident. I have photos of the seat position and the seat-back motor after it was removed, but was unable to upload them. I still have the seat back motor in the same condition it was in as provided to me by Volvo Cars of Sarasota.