VOLVO Complaints

ELECTRONIC THROTTLE MODULE HAD TO BE REPLACED DUE TO FAILURE. THE WARNING LIGHTS CAME ON AND THE CAR REPEATEDLY JERKED DURING DRIVING. DEALER ASSESSED SITUATION AND HAD NO CHOICE BUT TO REPLACE. *JB

WHILE DRIVING HOME FROM WORK, A MESSAGE CAME UP ON THE INDICATOR (PERFORMANCE REDUCED." THE ENGINE STARTED "MISSING" BADLY AND WITHIN 30 SECONDS STOPPED, LOSING POWER STEERING, POWER BRAKES, AND THE ABILITY TO ACCELERATE, CREATING A DEFINITE SAFETY HAZARD FOR ME AS WELL AS OTHER CARS ON THE ROAD. I MANAGED TO ROLL TO THE SIDE OF THE ROAD, OUT OF TRAFFIC. AFTER ABOUT FIFTEEN MINUTES THE CAR STARTED AGAIN. I DROVE HOME AND MADE AN APPOINTMENT WITH THE VOLVO DEALER (VOLVO OF LANGHORNE, LANGHORNE, PA 215-741-1400) FOR THE NEXT DAY. I BROUGHT THE CAR IN AND WITHIN A HALF HOUR, THEY DIAGNOSED THE PROBLEM AS A "THROTTLE BODY" (ETM) FAILURE WITH NO OPTION OTHER THAN TO REPLACE IT AS THE CAR WILL NOT RUN PROPERLY IF AT ALL WITHOUT THE REPAIR. THE REPAIR COST $1005.99. THERE IS NO WAY A MAJOR COMPONENT SUCH AS THIS SHOULD FAIL WITH LESS THAN 58,000 MILES (57911 AT THE TIME OF THE REPAIR). A BRIEF SEARCH OF THE INTERNET REVEALED THAT THIS PARTICULAR COMPONENT IS VERY FAILURE PRONE, CERTAINLY WELL OUTSIDE WHAT COULD BE CONSIDERED ACCEPTABLE. THIS IS FOR A VOLVO S60 2.4T BUT IS NOT AVAILABLE AS A CHOICE IN THE FOLLOWING SCREENS. *NM

MY 1999 VOLVO V70 XC WITH 76,000 MILES HAD FLUTUATING IDLE AND STALLED OCCAISIONALLY WHEN COMING TO A STOP, LOSING CONTROL ( POWER STEERING AND ACCELERATION). ON 8 APRIL 2004 WE HAD TO REPLACE THE THROTTLE BODY (COST ~$1000). THIS MONTH (AUGUST 2005) WITH 99,000 MILES ON THE CAR, THE SAME SYMPTOMS OCCURED AGAIN. WE HAVE JUST REPLACED THE THROTTLE BODY AGAIN AT A COST OF $1000.

ELECTRONICE THROTTLE MODULE FAILURE. WHILE DRIVING ON A BUSY MAIN STREET THE CAR SUDDENLY WENT INTO A "LIMP MODE". TOOK IT TO OUR INDEPENDANT VOLVO MECHANIC AND HE HOOKED IT UP TO VADIS. THEN TOLD US THAT IT WAS AN ETM FAILURE. I CALLED VOLVO AND THEY SAID THERE WAS NTOHING THAT THEY COULD DO SINCE THE CAR WAS BOUGHT USED. I PAID OVER ONE THOUSAND DOLLARS TO GET THE ETM REPLACED.

ONLY 2 DAYS AFTER PURCHASING OUR 2001 V70 XC WITH 64,000 MILES WITH EXCELLENT DEALER SERVICING AND OIL CHANGES, IT STARTED IDLING VERY ERRATICALLY, AND WOULD STALL SEVERAL TIMES AFTER TRYING TO START IT. EVEN WHEN WARMED UP, THE IDLE WAS ALL OVER THE PLACE, RUNNING VERY ROUGH. WHEN DRIVING, ESPECIALLY AT LOWER SPEEDS, WE HAVE TO MAINTAIN A FOOT ON THE BRAKE DUE TO THE SURGING AND ERRATIC IDLE SO THAT WE DO NOT UNINTENTIONALLY HIT THE VEHICLES THAT ARE IN FRONT OF US OR AT TIMES MUST KEEP A FOOT ON THE GAS PEDAL TO KEEP THE RPM'S UP SO THAT IT WON'T STALL. THE CHECK ENGINE LIGHT HAS BEEN ON SINCE THE FIRST IDLE SYMPTOMS AND THE PROBLEM HAS BEEN DIAGNOSED AS AN ETM FAILURE. SINCE THE VEHICLE IS NO LONGER UNDER WARRANTY, WE HAVE NOT YET HAD THE PROBLEM FIXED. WE FEEL THIS POSES A SAFETY RISK AND SHOULD NOT BE AN ISSUE WITH JUST 64000 MILES ON THE CAR. *AK

ST: VEHICLE STALLED/DIED/LOST POWER WHILE DRIVING AT 20 MPH. DEALER REPLACED THROTTLE BODY. *AK *JB

1999 VOLVO S80; THROTTLE UNEXPECTEDLY STOPPED OPERATING AND VEHICLE WENT INTO A "LIMP HOME MODE". VEHICLE WAS TOWED TO A DEALER. DIAGNOSTIC TESTS REVEALED A FAULTY THROTTLE CONTROL MODULE (TCM). THE TCM WAS REPLACED AND NEW SOFTWARE DOWNLOADED. OLD PARTS WERE NOT PROVIDED BY THE DEALER. *NM

VEHICLE SPEED CONTROL. 1ST FAILURE OCCURRED WHEN I WAS DRIVING MY 9 YEAR OLD DAUGHTER AND 6 YEAR OLD NEIGHBOR. TRAFFIC WAS HEAVY AND THE SURGE ALMOST CAUSED ME TO REAR END THE CAR IN FRONT OF ME. LACK OF POWER WITH NORMAL ACCELERATION WHICH LEADS TO MORE PRESSURE TO THE ACCELERATOR LEADING TO AN EVENTUAL DANGEROUS SURGE. VERY NOTICEABLE AT A DEAD START, BUT DOES OCCUR AT DIFFERENT SPEEDS. EXPLAINED BY DEALERSHIP THAT ETM NEEDS REPLACING. REPLACEMENT COST WILL BE $800-$1200. *NM

THE ELECTRONIC THROTTLE WAS CREATING SURGES TO THE ENGINE CAUSING A BACK AND FORTH MOTION. APPARENTLY WE CAUGHT IT BEFORE IT GOT WORSE AND DANGEROUS. *NM

I AM THE OWNER OF A 1998 VOLVO S90 WITH 69,000 MILES. THE ETM UNIT ON THE CAR HAS FAILED. I DID SOME RESEARCH ON IT AND FOUND THAT IT IS A KNOWN PROBLEM WITH THAT CAR. IT CAUSES THE TRANSMISSION TO ACT ERRATICALLY. MY MECHANIC HAS TOLD ME THAT EVEN IF I CHANGE IT , IT WILL FAIL AGAIN IN A SHORT WHILE BECAUSE IT HAS A BAD DESIGN. I HAVE CONTACTED VOLVO ABOUT IT, AND THEY REFUSE TO DO ANYTHING ABOUT IT. I JUST WANT TO HAVE THIS COMPLAINT REGISTERED IN CASE VOLVO IS MADE TO CORRECT THIS THROUGH SOME LAWSUIT OR OTHER. *NM