VOLVO Complaints

I plugged my usb to usb-c charging cable into my iphone 20 seconds after starting the vehicle. I proceeded to exit my driveway when the infotainment screen went completely blank and the same thing to the driver's display 10 seconds later. I drove to the end of my street to a stop light where the car completely shut off and automatically restarted within a few seconds. I was traveling with my wife and [XXX] daughter. I have yet to reproduce the problem but have an appointment scheduled with the dealership later this week. Zero warnings or messages were present before, during or after the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Volvo XC90. The contact stated that after a rainstorm, there was water leaking from the rearview mirror, which leaked into the vehicle, causing the electrical system to fail. There was an abnormal sound of water swishing around inside the vehicle. The on-call warning and check engine warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed with a cracked sunroof cassette leak. The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 147,000.

When driving at about 10mph in my kids daycare driveway on a downward slope towards the main road, I depressed the brake pedal to stop and the car did not slow down. A few feet before intersecting the main road, I depressed the brake pedal fully to the floor and the car panic stopped. No braking action happened until the brake pedal was fully depressed to the floor.

The contact owns a 2025 Volvo XC90. The contact stated while driving at various speeds, the air bag light illuminated, and a message to return the vehicle to the dealer was displayed. The vehicle was taken to the dealer to be diagnosed. The vehicle was diagnosed with a software installation failure. The vehicle was repaired but the failure persisted. The vehicle was taken back to the dealer and remained with the dealer for further diagnostic testing. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,000.

The DIM (Driver Instrument Module) flickers intermittently and I have no idea when it's going to go out completely. It actually does go out and there's a solid white panel or colored lines, but it comes back in. This displays the speedometer & fuel. This is a safety issue. I would hate for this to go completely out while I am driving. I do not know the cause for the malfunction. However, per the Volvo tech; they're aware this is a reoccurring issue.

Three incidents have occurred in three months. Unintended Acceleration Incident #1. While turning right after a full stop on an uphill incline, the vehicle accelerated so quickly that the steering wheel couldn't be return to the neutral position before hitting a roadside signpost approximately 25 ft away. The impact was severe enough to cause the right front headlight to be broken, the right front wheel well liner to be ripped out, the right A-pillar to be dented, and the right mirror to be ripped off. No physical injuries occurred. Unintended Acceleration Incident #2, six weeks later. While on the same incline as incident #1, after removing my foot from the accelerator, the vehicle continued to accelerate, even during braking. Total time was approximately 2 sec. There was no damage to the vehicle, and no physical injury. I checked, and the floor mat was locked in place. Both incidents were reported to Volvo, and permission was given to extract data from the vehicle. The data was extracted at a Volvo service center. Unexpected Acceleration Incident #3 (after data extraction, before Volvo report). While turning right and into a parking space in front of a sidewalk and coming to a stop on an uphill incline, the vehicle quickly moved forward approximately 2 ft after my foot was removed from the brake. I was able to brake again to regain control and put the car in park. Unexpected Acceleration Incident #4 (after data extraction, before Volvo report). While traveling on an uphill incline, after removing my foot from the accelerator, the engine remained at a high enough RPM to sustain forward motion. Even after full-stop braking, the vehicle would move forward on its own, on an uphill incline, without depressing the accelerator. After incident #4, Volvo reported that they concluded that the vehicle was operating as designed at the time of their inspection and during a test drive, that no fault codes were found, and that no unintended acceleration was observed.

CONCERN: Volvo cars’ sunroofs are negligently designed, allowing sunroof drain obstructions to flood the vehicle’s internal electronics. This results in catastrophic and simultaneous system failures, including brake loss, airbag failure, and disabled traction control—posing an extreme and imminent safety risk. SUMMARY OF EVENTS: While driving at speed, I received a “BRAKE FAILURE / PLEASE STOP SAFELY” warning, followed by “ABS / ESC” and “SRS Airbag” failure messages. This led to a sudden and dangerous loss of braking power and airbag system failure, forcing me to pull over in an emergency maneuver. Diagnostics confirmed that water leaked into the car’s critical electronic systems via the sunroof. Like other manufacturers, Volvo sunroofs degrade over time and require drainage. However, Volvo’s design is fatally flawed—clogged drains lead to direct water ingress into the electronics, causing total vehicle system failure while in motion. No warning is provided before catastrophic failure occurs. This is not an isolated case. An identical failure occurred in our second Volvo (2020 V90 Cross Country), owned and operated in California. This proves a systematic design defect—the same critical safety failure occurred in two separate vehicles, in different environments, under identical circumstances. I am deeply alarmed by Volvo’s negligent sunroof drainage design, which puts drivers and the public at severe risk of fatal system failures. I am reporting this to NHTSA because I believe this fundamental design flaw in Volvo sunroofs endangers lives and demands urgent regulatory action. Thank you for your attention to this urgent safety issue.

Engine has failed and is unrepairable. The car has been maintained well according to the manufacturer’s guidelines with regular oil changes. It has only 94,875 miles. The mechanic said that there is probably a piston gasket failure leading to oil leak into the engine. This appears to have been reported with this year/model vehicles. I would like Volvo to take ownership of poor manufacturing and fix the problem to my satisfaction.

Purchased a used 2016 Volvo XC60 from a BMW dealership. A month after purchase, oil light came on - so we added oil. Not long after, it came on again. Finally took the car to a Volvo dealership and they confirmed we have the "oil consumption" issue. There was a class action lawsuit against Volvo and they extended the warranty for this issue for 8 years or 100k miles. Unfortunately, we purchased the car at 8 years, 6 months. We had no idea this issue existed. Volvo says they will do nothing about it. This is a known defect and they should fix it! If you google this you will find people reporting it all over. Some people have reported that their engines have caught fire while driving. This is very dangerous! Volvo should be made to fix this problem.

At 5pm while driving home, which was 2 hours away, I needed to stop and refuel. At the pump I pushed the fuel door and it would not release to open. After many tries it would not open. I called Volvo On Call and informed them of the problem. The agent relayed that I should go to the back of the car near the fuel door, and with the remote lock and unlock the door which should release the door. It did not work. I tried it again with no success. The agent then informed me that there is no other way to open the door and to go to a Volvo dealership to get repaired. I asked the agent is there a way to open the door from the trunk, for instance like a rope to pull to manually open the door. He said unfortunately no. So, I am no where near a dealership and if I was it would be closed, it is after 5pm on February 17 and its 20 degrees outside and I need fuel to get home. I get in my car and search the internet on a possible way to open the door and I see that this is a big problem with Volvo that has affected many families and individuals that, as I, have been put in a compromised possibly dangerous position. While at the gas station I fortunately saw a tow truck and asked the driver if I could borrow a screw driver to try to pry open the door to which I was successful. A simple pull cord in the trunk, as some vehicles have, would have solved this issue without putting anyone in a precarious situation. I took my car to a mechanic and he replaced the fuel door lock solenoid.