2019 VOLVO S60 Complaints

I was pulling into a parking spot in a strip mall parking lot. When I braked after turning into the parking spot, the brakes failed. The car moved forward and hit the Chevy Suburban parked in front of it and started to push it. The automatic collision avoidance system did not stop the car, either. The owner of the Suburban was in that vehicle and was able to put it in gear and move it out of the way. My car continued to move forward at the speed it had been going at when the brakes failed so apparently it was still accelerating. The car then ran into a concrete bollard, and that stopped the car. The control panel was completely blank and the car could not be restarted. The car incurred front end damage and was towed to a collision shop, where it is now. When returned, it will go to the Volvo dealership to be checked out. I don't know whether the problem can be reproduced; by the time the two truck arrive an hour after the incident, the car could be started and appeared to be operating normally.

The crimping on the A/C hose from the firewall to the compressor failed and leaked all the freon from the system. This is a design flaw, the mounting location causes excess vibration in the hose leading to the crimping failure. There are countless forum posts and other complaints filed by owners of the same vehicle for the exact same A/C hose. This should be a recall from Volvo. It is a major safety issue for customers like me who live in a humid environment, without A/C the windshield can fog over and hinder visibility. I contacted Volvo Customer Care for reimbursement and was denied as my car was not under warranty. My car only has 40,000 miles on it and this part shouldnt fail in this manner, especially at my low mileage. I have since purchased their extended warranty as this part will eventually fail again (from the design flaw in A/C system mounting location) and I don't want to pay the large repair costs again. The NHTSA should investigate this with all owners of this year/make/model and they will find Volvo needs to declare a recall and reimburse owners for the repair costs.

The DIM (Driver Instrument Module) flickers intermittently and I have no idea when it's going to go out completely. It actually does go out and there's a solid white panel or colored lines, but it comes back in. This displays the speedometer & fuel. This is a safety issue. I would hate for this to go completely out while I am driving. I do not know the cause for the malfunction. However, per the Volvo tech; they're aware this is a reoccurring issue.

Passenger seat was unbolted from floor during a service appointment and not secured when dealer returned vehicle to me. Passenger safety was at risk due to the seat rocking during acceleration and deceleration and in turns. The issue was confirmed by the dealer and has since been repaired. No warnings issued by vehicle. The dealer error occurred 10/16/24. It was corrected 10/17/24 after vehicle was returned to dealer. This was a result of dealer negligence.

2019 Volvo S60 headlamp system malfunction alert headlights/foglights to blink or turn off when turning the vehicle at night. I keep my headlights on auto so they are on during the day and I have only seen the error at night

Have there been complaints about the Pirelli tires with foam inlays falling apart because the foam comes unattached, then causing misalignment. Car becomes unsafe to drive as the tires start to disintegrate. My car started shaking so bad it became difficult to drive. Turned out foam inlay had become unattached which caused uneven wear and some tire disintegration along with the alignment getting out of whack. Tire size 235/40R19 96V pirelli p-zero - It happened with all four tires. Two in the front were relatively new and had less than 10000 miles on them

The passenger seat belt failed and will not retract. People riding in my car are not safe with the seatbelt hanging loose. I read this was a recall which included 2019 S60s but my specific VIN is not including for some reason.

Since purchase of my vehicle, the vehicle has had a vibration on the highway from 72-83mph with 2 different sets of wheels AND tires, both Pirelli tires but different models. My local Volvo dealer refused to address the issue due to the issue occurring over the speed limit. So they were no help. There are quite a few other 2019 and up Volvo S60 and XC90 owners that experience this same issue. The issue is felt through the bottom of the seats, backrest and steering wheel. You can also visually see the vibration if there is a bottle in the cup holder. The steering wheel "shakes" left to right.

Sudden, Extreme vibration of front tires on I-95 West Palm Beach FL. Drove immediately to Schumacher Volvo to keep initial service appointment. Service manager advised to replace all 4 tires due to previous experience with OEM Perelli tire failures on Volvo vehicles. Replaced all 4 tires at Costco at $1112+ cost. All photos show failure of foam/padding inside tires by Pirelli P Zero Run Flat. Tire size: 235/40/19 XL

235/40/19 XL RUN FLAT: At 20,750 miles, Sudden Extreme Vibration at Interstate Speed. Confirmed by Schumacher Volvo Service on 28 Oct 2023. Service Writer and Technician advised tire/s failing due to 'foam' separating inside tire. Rotated tires and could not determine which tire. Advised to replace all tires due to experience with same problem on same tires. Recommended purchasing another brand at Costco.