2003 WINNEBAGO JOURNEY Complaints

TL*THE CONTACT OWNS A 2003 WINNEBAGO JOURNEY EQUIPPED WITH MICHELIN X TIRES, SIZE P235/80/R22.5. TWO OF THE TIRES WERE PURCHASED AS REPLACEMENTS. THE CONTACT LATER FOUND OUT THAT ONE TIRE WAS MANUFACTURED SIX YEARS AND THE OTHER TIRE TEN YEARS BEFORE HE PURCHASED THEM. THE CONTACT WAS UNABLE TO RETURN THE TIRES SINCE THEY WERE PURCHASED FROM A TIRE FACILITY THAT WAS 700 MILES FROM HIS RESIDENCE. THE CONTACT DROVE THE VEHICLE BETWEEN 500 AND 700 MILES AND THEN IT WAS PARKED FOR THREE MONTHS. WHEN THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE AGAIN, HE NOTICED THAT THE TIRES WOULD NOT HOLD AIR. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO INFORMED THE CONTACT THAT THERE WERE HOLES IN THE TIRES. THE TIRES WERE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000. THE CURRENT MILEAGE WAS APPROXIMATELY 54,000.

VEHICLE CAUGHT ON FIRE AS A RESULT OF 2 SCREWS THAT MOUNTED AN ELECTRICA TRANSFER SWITCH, WERE INAPPORPERATELY SCREWED INTO THE ENGINES EXHAUST MUFFLER. AFTER ABOUT 18,000 MILES OF ENGINE TORQUE AND VIBRATION, THE SCREWS ENLARGED THE HOLES ON THE REAR OF THE ELECTRICAL COMPARTMENT AND IN THE MUFFLER, ALLOWING FIRE HOT DIESEL ENGINE EXHAUST FLAMES & GASES TO ENTER THE ELECTRICAL COMPARTMENT AND TORCH THE WOOD TRANFER SWITCH STRUCTURE., AS WELL AS SEND CORBON MONOXIDE INTO THE COACH. THIS PROBLEM CAUSE ME TO STOP MY VEHICLE ON A MAJOR US INTERSTATE, BACK UP TRAFFIC FOR MORE THEN A MILE, AND DO AN EMERGENCY EVACUATION OF MY WIFE AN OUR TWO YORKIES. THIS EVENT CAUSE EXTENSIVE SMOKE DAMAGE TO THE INTERIOR OF OUR COACH, CAUSED HEAT DAMAGE TO THE ELECTRICAL COMPARTMENT, AND MADE THE MUFFLER UNSAFE.*AK

VEHICLE CAUGHT ON FIRE AS A RESULT OF 2 SCREWS THAT MOUNTED AN ELECTRICA TRANSFER SWITCH, WERE INAPPORPERATELY SCREWED INTO THE ENGINES EXHAUST MUFFLER. AFTER ABOUT 18,000 MILES OF ENGINE TORQUE AND VIBRATION, THE SCREWS ENLARGED THE HOLES ON THE REAR OF THE ELECTRICAL COMPARTMENT AND IN THE MUFFLER ALLOWING FIREY HOT DIESEL ENGINE EXHAUST FLAMES & GASES TO ENTER THE ELECTRICAL COMPARTMENT AND TORCH THE WOOD TRANFER SWITCH STRUCTURE., AS WELL AS SEND CORBON MONOXIDE INTO THE COACH. THIS PROBLEM CAUSE ME TO STOP MY VEHICLE ON A MAJOR US INTERSTATE, BACK UP TRAFFIC FOR MORE THEN A MILE, AND DO AN EMERGENCY EVACUATION OF MY WIFE AN OUR TWO YORKIES. THIS EVENT CAUSE EXTENSIVE SMOKE DAMAGE TO THE INTERIOR OF OUR COACH, CAUSED HEAT DAMAGE TO THE ELECTRICAL COMPARTMENT, AND MADE THE MUFFLER UNSAFE.*AK

CONSUMER RECEIVED NHTSA RECALL 04V11400O REGARDING LP TANK. DEALERSHIP STILL DOES NOT HAVE THE PARTS AVAILABLE TO CONDUCT RECALL REPAIRS. VEHICLE WAS KEPT BY THE DEALER FOR OVER THREE WEEKS. *AK IT TOOK THE DEALER 3 WEEKS TO PERFORM A 3 HOUR RECALL. THE DEALER AND WINNEBAGO WERE NOT VERY COOPERATIVE. *NM

WHILE DRIVING AT APPROXIMATELY 35 MPH PLASTIC HINGE PIN SHEARED OFF, CAUSING THE THROTTLE PEDAL TO DETACH. ROADSIDE ASSISTANCE INSTALLED A TEMPORARY PIN, AND THE RECREATIONAL VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE TEMPORARY HINGE PIN WITH A PERMANENT STEEL HINGE PIN. *AK