HERCULES TIRES Complaints

The contact owns a 2006 Toyota Sienna equipped Hercules Tires, Tire Line: Roadtour 855 SPE, Tire Size: 215/65/R16, DOT Number: U96VH260H21. The contact stated while driving 35 MPH during a trip, the steering wheel started shuddering. The vehicle was taken to a tire shop, and the contact was informed that the two front tires had sustained tread belt separation and bulges. The two front tires were replaced. Additionally, the contact stated while driving 65-70 MPH, the TPMS warning light illuminated. The vehicle was taken to the tire shop, and the contact was informed that the rear passenger's side tire had sustained tread belt separation, and the metallic belt was poking through the rubber. The contact requested that the rear tires be replaced as a precautionary measure. The rear tires were replaced. All four tires were replacement tires. The dealer and the manufacturer were not notified of the failure. The vehicle failure mileage was 173,414. The tire failure mileage was approximately 16,022. The VIN was not available.

Brand new tire purchased in February 2025, date code 2424, less than 100 miles. Driving about 60MPH on [XXX] when the tire blew. This is a single axle trailer, the failed tire was on the passenger side. Partial loss of control for a moment, and was able to safely pull over and replace it with the spare. The entire sidewall is destroyed, with steel wires holding the tread on. I can see some areas in the tread pattern where there are strings coming through the rubber - which leads me to believe this is a manufacturing problem. The sister tire on the driver's side is still up and holding at 98PSI. Tire size is ST235/80R16. Tire was right at 100PSI, and I have a pressure monitoring system. There was some damage to the trailer, not catastrophic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

225/60R18 100H Mileage on car when tires purchased 33,410(11/4/2021 mileage when tire failed 40,702.(6/8/2023) These tires have a 50K warranty. At 40,846 (6/26/2023) two more tires failed. I was told tread separation was issue. This dealer put my family at Risk! When the car went in for shaking they said the tire was defective. They replaced it and charged me $214, the tire only cost $150 new. I asked if the other tires were OK, the girl I paid said "the bad tire was from a different batch than the three remaining tires and they were OK." 2 weeks later 2 more tires go bad, putting us back in the car with defective tires put my family at risk. This dealer is dishonest and Dangerous. They charged me for 4 new tires total cost $492.35 when the set only cost $600 new and we only received 15% of the use of the tire, before they went bad. 1 tire going bad is unfortunate, 3 tires same problem is a Defect and they should have been replaced NO Charge. Anyway you need to get these tires off the road before someone has a serious accident or possibly already has.

LT 275/ 70 R 18. Pieces of the tread are peeling away in chunks. The outer edges of the tread pattern appear to have been cut into and have gaps where rubber is missing. The salesperson at the place of purchase assured me that this is caused by driving on rocks. My 83 yo father has never seen anything like this on any tires. My 50,000 mile tires are down to the wear marks with approximately 22,000 miles. l no longer feel safe in my normal travels with these seemingly defective tires That may fail at any time.

Repeated sudden (5) flat tires in a span of a year - various positions on vehicle and all happening suddenly while driving. Not caused by any foreign debris or punctures. Repairs would not hold long, however. Have replaced all 4 tires due to fear of sudden flats causing accident. Tires: 2155017 HER Roadtour 455 215/50R17 DOT U96A H3U 0919

LT 265/75 R16 HERCULES TERRA TRAC A/T DELAMINATING THE SAME AS THEIR OTHER TIRES INVOLVED IN AN EARLIER RECALL DOT CODE UTW8 HWC 2705 46505-1 R 30104

TL* THE CONTACT OWNS A 1994 FORD PROBE EQUIPPED WITH HERCULES RAPTURE (NA) TIRES, SIZE: 18570R14 (NA). THE CONTACT STATED THAT THERE WAS A BUBBLE STICKING OUT OF THE TIRE TREAD AREA. THE TIRE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 166,000.

HERCULES ROADTOUR 655 TIRE DEVELOPED A LARGE BULGE IN SIDEWALL AREA. THIS WAS NOTICED AND THE TIRE WAS TAKEN OUT OF SERVICE AS BEING UNSAFE. THE LOCAL HERCULES TIRE DEALER SAID THAT THEY WOULD NOT REPLACE TIRE OR GIVE PARTIAL CREDIT ON A REPLACEMENT TIRE.

PURCHASED TIRES ON 2/27/2013 . TIRES HAVE 27,441 MILES ON THEM. THEY WERE ORIGINALLY WARRENTED FOR 40 MONTHS OR 50,000 MILES. ALL 4 TIRES HAVE SIDEWALL CRACKING CLOSE TO THE WHEEL RIM. DOT #'S ARE UTOT HWB 4212,UTOT HWB 5012, UTOT HWB 5012, UTOT HWB 5012

TL* THE CONTACT OWNS A 1989 FORD RANGER EQUIPPED WITH HERCULES H/P 4000 TIRES, SIZE: 215/70R14 (NA). THE CONTACT STATED THAT THE FRONT DRIVER SIDE TIRE WAS CRACKING AND EXPERIENCED TREAD SEPARATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS RECOMMENDED TO REPLACE ALL THE TIRES. THE TIRES WERE REPLACED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 150 AND THE VEHICLE FAILURE MILEAGE WAS 50,400.