MICHELIN TIRES Complaints

The contact owns a 2025 Mercedes-Benz GLE450 4Matic equipped with Michelin Tires, Tire Line: Primacy Tour AS, Tire Size: 275/50/R20, DOT Number: 1B9RF011X0925. While the contact's wife was driving 55 MPH, the vehicle drove over a speed bump and the rear tires jumped away from the vehicle 10–12 inches. The vehicle was taken to the dealer. The contact was informed that the issue was normal for the vehicle. The contact was informed that there was no fix for the vehicle. The contact stated that the vehicle was a safety hazard. The manufacturer was made aware of the failure, and a case was filed. The contact requested a vehicle buyback, which was denied. The failure mileage was approximately 15.

The contact owns a 2022 Tesla Model Y equipped with Michelin Tires, Tire Line: Michelin Pilot Sport, Tire Size: 255/35/ZR21, DOT Number: (N/A). The contact stated that while driving 65 MPH, the rear driver’s side tire experienced a blowout. The contact was able to safely pull off the roadway and wait for towing assistance. The local dealer was contacted. The vehicle was towed to American Depot Tires. The contact stated that all four tires were replaced, and the vehicle was repaired. The contact stated that the inner tread of the front tires were prematurely worn, and the vehicle required an alignment every three months instead of every six months. The manufacturer was notified of the failure and informed the contact to take the vehicle to the dealer and have the vehicle repaired out of pocket. The failure mileage was approximately 99,482.

Driving on I-69 in the right lane 18 miles south of Bloomington In. with our 2025 Honda CRV Hybrid Sport Touring in adapative cruise at 77 on a straight dry road the driver front tire blew out with 14 holes on the outside sidewall. There was a car passing me on the left and when it blew out it pulled me towards it as he moved left to avoid hitting, I turnrd off adaptive cruise immediately and slowly applied brakes to pull off the road on the right. No warning lights ever came on in the vehicle. Michelin Primacy A/S 235/55 R19 The vehicle was towed to Andy Moore Honda in Bloonington In. by road side Honda and the tire was replaced and a front end alignment was done. The vehicle had 2471 miles on the odometer at the time of the incident.

What component or system failed or malfunctioned, and is it available for inspection upon request? I purchased four tires from Belle Tires on April 1, 2026, 14 days ago (note: mileage at accident 10,776 vs mileage at tire purchase 10,360 or 416 miles of wear). On Wednesday, April 15th, I was about to change lanes after entering the Tri-State Expressway (route 294) going southbound from Half-Day Rd. (route 22), I had crossed the first two lanes without incident, and moving into the third lane, when I experienced a blowout of my driver’s-side rear tire. The car started a fishtail counter-clockwise spin and crossed the third and the fourth lanes (i.e., the far left lanes) before smashing into the concrete median, separating my Southbound lanes from the opposing traffic lanes. I have kept both the tire and rim in my garage. How was your safety or the safety of others put at risk? As I started sliding or spinning, I cannot honestly say, whether or not I hit the brakes or can really describe the spinning that occurred. As the rim of blowout tire was evenly torn up on its outer edge, I know that the tire was turning. All I can recall is hearing the car hit the concrete median twice. I know that it had to be counterclockwise since I started going southbound, and after the car came to a rest next to the median, I was facing southbound again. Has the problem been reproduced or confirmed by a dealer or independent service center? I took the tire on it’s rim to the Belle dealer who would not acknowledge a blowout, but he kept insisting that he is not an expert on crash interpretations. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Allstate Insurance, Toyota used a Bosch representative to retrieve the Electronic Data Recording (EDR) information. I have copy of this report available for expert interpretation. No warnings were given prior to this blowout.

Factory Ford 20” wheels with Factory Installed Michelin 275/65 R20 LTX A/T2 tires. Tires have just under 30,000 miles on them and still have more than 50% tread. Tread wear is even. Tires have been rotated. Truck has 73,000 miles but had different wheels and tires for first 43,000 miles. I stored these wheels and tires inside climate controlled building. When my aftermarket tires wore out, I put these back on. They had 10 miles on them when I took them off. I have had them on since April 2022. On Friday June 5th, 2026 I was traveling about 60 MPH and had a catastrophic blow-out of the passenger side rear tire. The tires blew completely apart and the wheel hit the ground and the back side of the wheel broke off, before I could get over to the side of the road the tire beat the bed and running board to pieces and even damaged the exhaust and bumper. The wheel was ruined. Thousands of dollars in damage. All the tires are in good condition, not dry rotted, no cracks, the truck has been indoors in a garage. They hold air. TMPS works and I check my pressure all the time. I had just set the air pressure early that morning before leaving. The tires are less than 10 years old which is the date for replacement. They have more than half their tread. No cracks. They hold pressure perfectly. They are worn evenly. No reason for the tire to have blown out other than a manufacturing defect. When I got stopped there was a huge hole in tire and no tread on it at all.

The passenger rear tire (235/60R19 - Michelin Primacy A/S) randomly blew out while driving at high speeds on the highway. No trauma via a pothole or other object was noted. Tire was inflated to the manufacture recommended PSI (33 PSI). No signs came up until the tire blew out. The tire just randomly decided to give out while driving.

TIRE SIZE 235 / 55 R 19. Vehicle is a 2024 IONIQ 5. Issue began at/around 10k miles of use. Sound dampening foam inside of the tires comes loose and bunches up in the tire, creating varying degrees of car shaking and vibration. At its worst, the steering wheel and tires violently shake, especially between 50 - 75 mph. On the highway this causes a very dangerous situation of the driver fighting the wheel to remain safely within their lane. This can happen with no warning (or very little) as the vibration may be subtle at lower speeds on local roads, only to become unexpectedly extreme and violent while speeding-up to join highway traffic. Local Hyundai dealership inspected and tried rotating and balancing which did not fix the problem. Finally they removed the tires and inspected the foam which fixed the issue on one single tire. Cost was passed to the consumer, who is not at fault. And with only one tire addressed, the potential remains for each tire to experience the same failure without warning as time goes by. This is a very dangerous issue, well known as evidenced by complaints since 2023 online, and is going to cause accidents. It is unacceptable that drivers have risk their safety and that of other drivers if they lose control of the car due to the inability to control the steering wheel. Then have to pay to fix this issue or pay for new tires after only 10-12k miles.

Tire size 235/40 R20. Both front tires extremely worn in an uneven way with 1 having metal showing. Discout Tire in Lafayette, IN inpected and stated, "Lucky to be alive given how dangerous it is to drive on tires with metal exposed." Ordered new tires. Wouldn't even let us leave the parking lot due to safety. Used spare tire we carry to get home. Michelin denied the warranty claim due to improper servicing. No warning alerts. Vehicle was recently serviced by Mercedes of Lafayette on 3-34-26. Collected payment and handed my wife the key without volunteering ANY issue of ANY kind. Wife questioned if they even check the warning alert about brakes. Stated brake pads were in the yellow. Riding in the vehicle several days later, I noticed a loud road noise. Could not initially detect any obvious damage like a nail. Sound persisted. Stopped again. Turned steering wheel to expose the inner part of the tires. Zero tread and sharp metal exposed. Immediately took to Discount Tire. Confirmed OBVIOUS alignment issue causing uneven wear. Shocked Mercedes didn't fix the issue, and didn't alert us about the dangerous situation. Midas fixed alignment $122. Dealer & MB USA hq were notified. Neither made ANY effort to make things right in over 1mon. Dealer violated Indiana Code 9-19-18-3. Maker not doing proper quality control checks. Filing small claims court case about this issue as well.

Hello NHTSA, On 05/15/26, I was driving on [XXX] southbound when the sidewall of my Michelin X Line Energy Z steer axle tire failed and blew out. The tire was purchased on 12/23/25 and was made in [XXX] . When the tire blew, dark thing spread onto the hood, bumper, and side of my truck. I have attached images showing the damage and the failed tire. Thankfully, I was driving at about 55 mph, remained in control of the vehicle, and no one was injured. The tire tread was still in excellent condition at the time of the incident. For safety reasons, I was forced to replace both steer tires immediately. I have also attached the invoice along with the photos I recorded. P.S. I was unable to upload/download the video file successfully. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Hello NHTSA, On 05/15/26, I was driving on [XXX] southbound when the sidewall of my Michelin X Line Energy Z steer axle tire failed and blew out. The tire was purchased on 12/23/25 and was made in [XXX] . When the tire blew, dark thing spread onto the hood, bumper, and side of my truck. I have attached images and videos showing the damage and the failed tire. Thankfully, I was driving at about 55 mph, remained in control of the vehicle, and no one was injured. The tire tread was still in excellent condition at the time of the incident. For safety reasons, I was forced to replace both steer tires immediately. I have also attached the invoice along with the photos and videos I recorded. Thank you. P.S. I was unable to upload/download the video file successfully. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)