2015 BMW 320I Complaints

The fuel system was causing my engine to shut down, and I got it replaced at a mechanic. About some time later, after fixing the fuel system, I received a letter from BMW telling me that they had extended the warranty on the Fuel tank, but when I took it in, they said that there was no such extended warranty. The letter is from April 2022, but I just recently found it.

My 2015 BMW 320 is having a performance issue. After I diagnosed this is due to corrosion on the wastegate actuator and has failed. The bushing and part corroded and the rod is dangling. This should be covered by the extended warranty on the part as it’s a known defect failure by BMW

Vehicle continues to have lighting and electrical issues. Particularly, the left rear turn signal. I’ve repaired it 5 times and it burns out immediately. Dealer assured me they would find issue. Still burned out next day again. Notified dealership and they just want you to keep bringing it back but won’t issue a recall despite the plethora of complaints online about the same issue.

The gas tank on my BMW 320i 4 door sedan is leaking gas. Yes; it is available for inspection upon request. I had picked up my son from school and ran an errand. We stopped for gas when we noticed the gas was leaking as soon as we filled up the tank. We were around the corner from our home and drove home very slow. We were prepared to stop and pull over if necessary as we were afraid of the vehicle catching fire. I have an appointment with Niello BMW at 8am on 9/22/25 in Sacramento, CA on Fulton Ave. There were no warning lamps/messages or other symptoms prior to the issue. I never received any recall notification.

I have barely driven this BMW 320i from 2015. It is a well taken car parked in the garage. It has 33,000 miles on it. The check engine light came on so I brought it in for a diagnostic. The error is N63R Engine - Replace Wastegate Actuators and Program the Vehicle. The mechanic told me most BMW's in 2015 had a recall for this issue and this car should have a recall. So, I called BMW and they said it does not have a recall. I checked on the NHTSA site and the car does not have a recall. However, after some research, I found that many models from this year have a recall for this exact issue. This BMW320i from 2015 should also have this recall! There is no coincidence that the Wastegate failed in several models in the same year. To exclude this model from the recalls is unfair.

The contact owns a 2015 BMW 320I. The contact stated that after his wife had refueled the vehicle, he noticed that the vehicle was leaking fuel on the driver's side rear. There was a puddle of fuel on the ground. There were no warning lights illuminated. The contact called an independent mechanic who stated that the failure was due to the pressurized fuel system. The contact called the local dealer and was informed that there were no recalls on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 145,000.

Fuel tank leaking, matches previous service bulletin for other models build in this year range [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine would completely shut down while driving you had to completely take foot off gas petal because it would not excellent to make the car run it would almost come to complete slow down and stop you could then push gas and it would pick up and start running again.was worse when raining. Then the brakes got to where they would not stop and would lock up.Iwas on busy road and on interstate when it happened several times I could have been hit in the rear end and it would have caused a major collision. There was no warning lights come on at any point and timethen the brakes started where they would get hot and start smoking and eventually they locked up could not even drive the car . I didn't have the money to try to get it fixed so my 2015 BMW 320i sit for months before I could get it looked at had to replace frount and back rotors,calipers and brakes, ABS system replaced. When they checked it out the man at KADENZA AUTO REPAIR SHOP said that was only the second BMW that they had worked on that had this problems and didn't know why or what caused the problem. They did the repairs but couldn't guarantee that it wouldn't happen again said it could be a manufacturer defects. It was really dangerous when it started doing it because I could have been hit in the back of the car and it would have caused a major car pile up accident. It started doing it several months back because I wasn't able to drive it for several months had to tow it in when I took it to KADENZA AUTO REPAIR .They specialize in foreign and domestic cars.

I have been getting P0420 code over 2 years now. Loss of power while driving caused multiple times sudden stop and slow speed. I328 has recall but mine is not on the recall list. I tried everything to fix it but the light still comes on. And also my car is having the Navigation display delaminating. It seems like common problem for bmw owners. There are no recalls.

The contact owns a 2015 BMW 320i. The contact stated that while driving at approximately 35 MPH the passenger side headlight stopped illuminating the road. The contact stated that there was no warning light illuminated. The contact stated that about one month later the driver's side headlight stopped illuminating and the "headlight" symbol illuminated on the instrument cluster. The contact stated that the headlights illuminated when she used the high beam setting but would not function on the low beam setting. The vehicle was not taken to a dealer or independent mechanic. The vehicle was not diagnosed and was not repaired. The contact had replaced both headlamp bulbs and the low beams would not illuminate. The manufacturer was not informed of the failure. The failure mileage was approximately 135,000.