2009 BMW R 1200 R Complaints

2009 BMW R1200RT MOTORCYCLE WITH 50,482 MILES. THROTTLE CABLE PULLEYS/CAMS BOTH SHOWING SIGNS OF MULTIPLE CRACKS. ONCE THEY CRACK COMPLETELY, THE MOTORCYCLE BECOMES UNRIDEABLE AND MUST BE TOWED. THROTTLE NO LONGER FUNCTIONS AND MOTORCYCLE JUST RETURNS TO IDLE. MUST EITHER REPLACE ENTIRE THROTTLE BODY OR REMOVE AND REPLACE EXISTING PLASTIC CAMS WHICH HAVE FAILED.

THE THROTTLE BODIES ON THIS MOTORCYCLE ARE CABLE-ACTUATED, WITH PLASTIC PULLEYS MOLDED ONTO THE THROTTLE SPINDLES. THESE PLASTIC PULLEYS WERE SEVERELY CRACKED AND I HAVE REPLACED THEM (I STILL HAVE THE OLD PARTS). I'M AWARE OF NUMEROUS BMW MOTORCYCLES OF THIS VINTAGE THAT HAVE DEVELOPED CRACKS IN THE THROTTLE PULLEYS. I DISCOVERED MY PROBLEM VIA INSPECTION IN MY GARAGE, BUT I'M CURRENTLY AWARE OF TWO OTHER OWNERS FOR WHOM THE PULLEYS DETACHED FROM THE SPINDLES WHILE RIDING, CAUSING A SUDDEN LOSS OF ENGINE POWER. THIS PROBLEM HAS ALSO MANIFESTED ON OTHER BMW MOTORCYCLES THAT USE THE SAME ENGINE (E.G. THE R1200GS).

TL* THE CONTACT OWNS A 2009 BMW R 1200 RT. THE CONTACT STATED UPON MERGING INTO TRAFFIC, THE MOTORCYCLE LOSS MOTIVE POWER WITHOUT WARNING. THE CONTACT PULLED OVER IN A PARKING LOT AND ATTEMPTED TO REPAIR THE MOTORCYCLE HIMSELF. THE MOTORCYCLE WAS THEN RIDDEN TO HIS RESIDENCE. THE MOTORCYCLE WAS NOT TAKEN TO A DEALER NOR INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.

FUEL PUMP OUTPUT FLANGE CRACKED, RESULTING IN FUEL LEAKING DOWN THE SIDE OF THE BIKE AND ONTO HOT COMPONENTS WHILE RIDING. THIS ISSUE HAS ALREADY BEEN THE SUBJECT OF A BMW RECALL - BUT APPARENTLY THE "INSPECT AND REINFORCE" SOLUTION ISN'T REALLY ADEQUATE LONG-TERM. THIS PUMP HAD BEEN "INSPECTED AND REINFORCED" - AND THE FLANGE STILL CRACKED AND CAUSED A DANGEROUS FUEL LEAK WITH THE POTENTIAL FOR BODILY INJURY OR WORSE.

TL* THE CONTACT OWNS A 2009 BMW R 1200 RT. THE CONTACT STATED THAT WHILE PARKED IN THE GARAGE, A ODOR OF FUEL WAS PRESENT. THE MOTORCYCLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK HAD CRACKED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS PREVIOUSLY REPLACED UNDER NHTSA CAMPAIGN NUMBER: 13V617000 (FUEL SYSTEM) IN 2014. THE MOTORCYCLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000.

TL* THE CONTACT OWNS A 2009 BMW R 1200 RT. WHILE DRIVING AT 55 MPH, THE REAR OF THE MOTORCYCLE STARTED TO WOBBLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CROWN BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 29,000. THE VIN WAS NOT AVAILABLE.

ABS SERVO FAILED. COMPLETE LOSS OF THE ANTI-LOCK BRAKE FEATURE ON MOTORCYCLE. I AM REPORTING THIS BECAUSE I FEEL THIS IS AN IMPORTANT SAFETY FEATURE FAILURE THAT OCCURRED WITH VERY FEW MILES ON THE MACHINE. I HAVE ALREADY REPLACED THE ENTIRE ELECTRIC FUEL PUMP (RECALLED) AND REAR WHEEL HUB (RECALLED). I AM AFRAID OF THE SAFETY OF THIS VEHICLE AND DOUBT THE ADVERTISED "RELIABILITY" TOUTED BY THE MANUFACTURER, BMW MOTRORAD.

STARTED THE BIKE AND FUEL STARTED SPRAYING ALL OVER THE TOP OF THE ENGINE. TOOK OFF THE FUEL TANK AND THERE IS A CRACK IN THE FUEL PUMP ASSEMBLY. *TR

BMW MODEL R1200RT YEARS 2005 - 2013 MAY BE SUBJECT TO THROTTLE CABLE ASSEMBLY FAILURE. THE THROTTLE BODY SYSTEM ON THE 2009 YEAR MODEL IS ASSEMBLED BY BING POWER IN NUREMBERG, GERMANY AND UTILIZED BY BMW IN MOTORCYCLES WITH THE 1170 CC BOXER MOTOR. (BING IS A LONGSTANDING COMPANY WHICH IN GENERAL MANUFACTURES FIRST-RATE PRODUCTS.)THE PRIMARY THROTTLE CABLE EXTENDS FROM THE HANDLE BAR TO A SPLITTER FROM WHICH TWO SEPARATE THROTTLE CABLES EXTEND TO LEFT AND RIGHT HAND THROTTLE BODIES WHICH HOUSE THE FUEL INJECTION SYSTEM. THOSE TWO CABLES ARE ROUTED OVER AND ANCHORED TO A CABLE PULLEY MADE OF MOLDED PLASTIC. THIS ENTIRE ASSEMBLY IS ATTACHED TO THE THROTTLE BODY. IF OR WHEN THE PLASTIC FAILS, THERE IS NO THROTTLE AND THE ENGINE GOES TO IDLE, THUS CREATING AN EXTREME SAFETY HAZARD IF ONE IS DRIVING IN TRAFFIC AND UNABLE TO MAINTAIN SPEED OR ACCELERATE. IN THIS CIRCUMSTANCE THE RIDER COULD BE FORTHRIGHTLY IN HARM'S WAY AND ENDANGERED. THIS SHOULD BE AN URGENT RECALL ISSUE FOR REPLACEMENT OF THE PLASTIC PART WITH A SOLID CABLE PULLEY WHICH WILL NOT BREAK. PREVIOUS MODELS USED METAL CABLE PULLEYS WHICH DID NOT FAIL. (SEE THIS BLOG FOR DISCUSSION POSTED BY ANOTHER RIDER, AMONG MANY, WITH THE SAME FAILURE ISSUE: HTTP://WWW.ASVRIDER.COM/FORUMS/SHOWTHREAD.PHP?T=967780&PAGE=3 ) BMW DOES NOT MAKE THE PLASTIC PART AVAILABLE FOR REPLACEMENT. THUS, A PLASTIC PART COSTING BUT A FEW DOLLARS RESULTS IN THE RIDER HAVING TO REPLACE BOTH THE LEFT AND RIGHT COMPLETE THROTTLE BODY ASSEMBLIES AT A COST OF MORE THAN $1,000. THE UNDER-DESIGNED PLASTIC CABLE PULLEY IS NOTHING LESS THAN A HAZARD AND CREATES A RISK TO ONE'S LIFE. A POLICE MOTORCYCLE COP RIDING HIS PATROL R1200RT LOOKED AT THE FAILED PART I SHOWED HIM AND HIS FIRST WORDS WERE, "THAT COULD GET YOU KILLED." I HAVE MADE BING AND BMW OF NORTH AMERICA AWARE OF MY EXPERIENCE VIA EMAIL BUT I CONTINUE TO WAIT FOR THEIR REPLY. *TR

ABS FAILURE. KNOWN ISSUE IN THE BMW COMMUNITY, GOT THE STEADY BURN "BRAKE FAILURE" LIGHT ON THE DASHBOARD, AND NO MATTER WHAT I DO CAN'T CLEAR. VERIFIED THAT I'VE LOST ALL ABS FRONT AND BACK. ABS MODULATOR FAILURE. *TR