CAN-AM Complaints

WHILE RIDING HOME FROM WORK MY REAR LIGHTS SUDDENLY WENT OUT. UPON INSPECTION THE NEXT DAY I FOUND THAT THE RIGHT FENDER SUPPORT HAD CUT INTO THE TAILLIGHT HARNESS CAUSING IT TO GROUND OUT. BOTH FENDER SUPPORTS HAD BEGUN TO SEPARATE TO THE POINT THAT THE REAR FENDER ITSELF WOULD EVENTUALLY COME OFF AND COMPLETELY SEVERING THE TAILLIGHT HARNESS. I TOOK PICTURES AND OPENED A CASE WITH THE DEALER. I WAS REJECTED FOR BEING OUT OF WARRANTY. THEY SAID I SHOULD PURCHASE PART # 219800246 WITH TWO NEW SUPPORTS TO FIX THE PROBLEM, WHICH I DID ALL AT MY COST AND LABOR. A WEBSITE SPYDERLOVERS.COM HAS CASES WHERE BRP HAD FIXED SOME BIKES WITH THIS PROBLEM OUT OF WARRANTY. OTHER INDIVIDUALS THAT ARE MECHANICALLY INCLINED WENT AHEAD AND MADE THE REPAIRS THEMSELVES LETTING BRP OFF THE HOOK. I WAS TOLD BY BRP THAT MY BIKE WAS TOO FAR OUT OF WARRANTY. IF BRP FIXED ONE BIKE THEY SHOULD FIX THEM ALL AND/OR OFFER A RECALL. I SPENT $254 ON PARTS AND 1 1/2HRS. LABOR. I HAVE THE DEFECTIVE FENDER SUPPORTS IN MY POSSESSION FOR INSPECTION AND PICTURES BEFORE THE REPAIR WAS MADE. THE REAR FENDER SUPPORTS ON THESE BIKES ARE A HAZARD WAITING TO HAPPEN. THAT IS WHY BRP CAME OUT WITH PART # 219800246 TO REMEDY THIS DESIGN FLAW ON THEIR BIKES. *TR

THIS VEHICLE HAS AN EXTREMELY DANGEROUS HEAT PROBLEM. HEAT BUILDS UP UNDER THE FIBERGLASS PANELS WHICH RESULTS IN THE GAS CAP BECOMING TOO HOT TO TOUCH WITH YOUR BARE HAND, AND GASOLINE BOILING IN THE TANK. ALSO, THE RADIATOR FAN BLOWS VERY HOT AIR ON MY RIGHT FOOT WHICH IS VERY UNCOMFORTABLE. ADDITIONALLY, I CAN SMELL GAS FUMES WHEN RIDING, AND THE FUMES ARE OVERPOWERING WHEN PARKING THE BIKE AFTER RIDING. I LEAVE THE BIKE OUTSIDE MY GARAGE UNTIL THE FUMES DISSIPATE, AS I FEEL THAT IT DANGEROUS TO PARK IN THE GARAGE WITH THE OVERPOWERING GAS FUMES. BRP AND THE DEALERS ARE AWARE OF THESE PROBLEMS, AND CAN OFFER NO FIX FOR THEM. THESE PROBLEMS HAVE BEEN ADDRESSED IN THE 2014 MODELS, SO OBVIOUSLY THERE IS A WAY TO REMEDY THEM. WHENEVER I AM ASKED HOW I LIKE THE BIKE, I TELL PEOPLE THAT THE GAS MILEAGE IS HORRENDOUS, THE HEAT PROBLEM IS UNCOMFORTABLE, AND THE GAS FUMES ARE UNBEARABLE AND DANGEROUS. I ADVISE THEM NOT TO BUY THIS VEHICLE. *TR

THIS VEHICLE HAS AN EXTREMELY DANGEROUS HEAT PROBLEM. HEAT BUILDS UP UNDER THE FIBERGLASS PANELS WHICH RESULTS IN THE GAS CAP BECOMING TOO HOT TO TOUCH WITH YOUR BARE HAND, AND GASOLINE BOILING IN THE TANK. ALSO, THE RADIATOR FAN BLOWS VERY HOT AIR ON MY RIGHT FOOT WHICH IS VERY UNCOMFORTABLE. ADDITIONALLY, I CAN SMELL GAS FUMES WHEN RIDING, AND THE FUMES ARE OVERPOWERING WHEN PARKING THE BIKE AFTER RIDING. I LEAVE THE BIKE OUTSIDE MY GARAGE UNTIL THE FUMES DISSIPATE, AS I FEEL THAT IT DANGEROUS TO PARK IN THE GARAGE WITH THE OVERPOWERING GAS FUMES. BRP AND THE DEALERS ARE AWARE OF THESE PROBLEMS, AND CAN OFFER NO FIX FOR THEM. THESE PROBLEMS HAVE BEEN ADDRESSED IN THE 2014 MODELS, SO OBVIOUSLY THERE IS A WAY TO REMEDY THEM. WHENEVER I AM ASKED HOW I LIKE THE BIKE, I TELL PEOPLE THAT THE GAS MILEAGE IS HORRENDOUS, THE HEAT PROBLEM IS UNCOMFORTABLE, AND THE GAS FUMES ARE UNBEARABLE AND DANGEROUS. I ADVISE THEM NOT TO BUY THIS VEHICLE. *TR

REPEATED PROBLEMS WITH ODOR OF FUEL AND INTERMITTENT STALLING. EVAP CANISTER WAS REPLACED TWICE (FUEL IN CANISTER) AND PURGE VALVE ONCE. APPEARS TO AFFECT RUNNING AS IT MISSES AND SURGES AT A CONSTANT SPEED (VERY SUBTLE). SINCE I PARK THIS IN MY ATTACHED GARAGE IT IS A CONCERN. VEHICLE HAS BEEN IN SHOP 5 TIMES FOR A TOTAL OF 2 1/2 MONTHS DURING MY 6 MONTHS OF OWNERSHIP. BRP HAS NOW TOLD ME THAT THEY WILL NO LONGER REPAIR THIS VEHICLE WHICH NOW HAS ONLY 2600 MILES. *JS

TL* THE CONTACT OWNS A 2012 CAN-AM SPYDER RT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE STALLED AND THE ELECTRONIC THROTTLE CONTROL WARNING LAMP ILLUMINATED. THE FAILURE OCCURRED ON SEVEN SEPARATE OCCASIONS. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 400 AND CURRENT MILEAGE WAS 107,000.

DURING ENGINE OPERATION; THE VEHICLE SENDS EXTREMELY HOT AIR OUT OF THE SPACE BETWEEN THE FORWARD EDGES OF THE SEAT AND UPPER AND SIDE BODY PANELS, THE UPPER SIDE PANELS ARE VERY HOT TO TOUCH, AND THE UNDERSEAT AREA ACCUMULATES AN EXCESSIVE AMOUNT OF HOT AIR ALLOWING THE FUEL CAP FOUND UNDER THE SEAT TO BECOME HOT TO THE TOUCH. THE SEAT HEAT PROBLEMS MAKE RIDING AND CONTROLLING THE VEHICLE DIFFICULT BECAUSE OF THE DISCOMFORT FELT BY THE DRIVER AND PASSENGER. IF THE DRIVER IS NOT WEARING THICK, PROTECTIVE GARMENTS COVERING THEIR LEGS THERE IS A POSSIBILITY OF BURNS ABOUT THE UPPER LEGS OR LOWER TORSO. THIS ISSUE IS ESPECIALLY EVIDENT WHEN THE OAT IS ABOVE 80 DEG FARENHEIT. *TT

WHEN STOPPING AT STOP SIGNS, TRAFFIC LIGHTS OR JUST STOPPING TO PARK THERE IS AN EXCESSIVE GAS SMELL COMING FROM THE VEHICLES EVAP CANISTER. THIS ALL STARTED WHEN THE OUTSIDE TEMPERATURES EXCEEDED 70 DEGREES. THIS SMELL OCCURS IF THE FUEL TANK IS FULL, HALF FULL OR NEARLY EMPTY. ON SUNDAY 4/13/14 WHEN COMING HOME FROM A LONG RIDE I DECIDED TO CHECK OVER SOME THINGS AND DISCOVERED THE GASOLINE IN THE FUEL TANK WAS BOILING! THE EXAUST PIPE ON THIS MACHINE RUNS VERY CLOSE TO THE FUEL TANK. *TT

HERE IS A LIST OF ISSUES WITH MY MOTORCYCLE, AND HUNDREDS OF CAN AM OWNERS 1- GAS SMELL 2- GAS BOILING AFTER RIDING 3- OVERHEATING, BURNING IF YOU TOUCH IT BOMBARDIER IS NOT FIXING IT, BUT THEY CHANGE THE DESIGN ON THE 2014 WITH NEW VENTS AND THEY ARE ASKING US TO PAY FOR THE FIX. MY BIKE IS SO HOT THAT MY WIFE HAVE ASK ME NOT TO RIDE ANYMORE, SHE ALSO ASK ME TO TO TAKE THE KIDS OR HER FOR RIDES BECAUSE OF THE SAFETY ISSUES, IF YOU CHECK ON THE SPYDERLOVER.COM FORUM YOU WILL SEE THAT BRP IS NOT DOING ANYTHING TO HELP THE HEAT ISSUES WE HAVE, MANY CALLS AND VISITS TO MY DEALER BAY HARBOR MOTORS IN NEW YORK, PLEASE HELP US BEFORE SOMETHING TRAGIC HAPPENS WHEN WE ARE RIDING A DEFECTIVE PRODUCT. *TT

RAW FUEL SMELL AFTER TRIKE WARMS UP AND COMES TO A STOP. RIGHT LEG AND FOOT ALOS BECOMES HOT WHILE RIDING. GAS CAP HOT WHEN REMOVING TO FILL UP. WAS TOLD BY DEALER THAT THERE IS NOTHING THEY CAN DO AND IS A VERY COMMON COMPLAINT. THE WARMER IT GETS THE WORSE THE RAW FEUL ODOR, AND HEAT BUILD UP GETS. DEALER CLAIMS THAT THE GAS ACTUALLY BOILS IN THE FUEL TANK AND VAPORIZE. THEY ALSO SAID THAT THERE IS NO FIX FOR THIS CURRENTLY. I WAS IN CONTACT WITH THE MANUFACTURE (BRP) AND THEY ISSUED ME A CASE NUMBER FOR REFERENCE WHILE DENYING ANY COMPLAINTS ABOUT THIS. MY FEAR IS THE TRIKE CATCHING FIRE, AS MY RESEARCH HAS FOUND THIS TO HAPPEN. I USUALLY HAVE A PASSENGER WITH ME AND I FEAR SHOULD A FIRE OCCUR MY PASSENGER WON'T HAVE ENOUGH TIME TO GET AWAY. THIS ALSO INCLUDES MYSELF GETTING AWAY. SEARCH SYDERLOVERS.COM AND YOU WILL SEE MANY POSTS ON THIS ISSUE. I FEEL THAT THE NHTSA NEEDS TO STEP IN AND TAKE A SERIOUS LOOK INTO THIS PROBLEM AND MAKE BRP ADDRESS THIS BEFORE SOMEONE GETS KILLED DUE TO SHEAR IGNORANCE. B *TT

MY RIGHT FOOT BECOMES EXTREMELY HOT WHILE RIDING FOR GREAT THEN 60 MIN AT HIGHWAY SPEEDS. EVEN MY WIFE AS A PASSENGER COMPLAINS. I ALSO NOTICED MY DRIVER SEAT AND GAS CAP GET QUITE HOT ALSO. PLEASE FIX THE HEAT ISSUE COULD BE VERY DANGEROUS. *JS