2020 CHEVROLET BOLT EV Complaints

The car has 80,000 miles. The backup camera has always had an intermittent issue after rain but now has stopped working. I cannot see properly to back up. I understand that this is an issue with quite a few Chevy Bolts and can/has caused problems with backing accidents. I also understand that the company has known about this for a while, but has done nothing about the issue.

Steering would not return to center after a turn only for LEFT turns, even at higher speeds. Steering would be sticky at low speeds. Resulted in challenging to predict cornering particularly for left turns. Manufacturer replaced steering gear under warranty. OK now.

I first noticed an issue with the steering wheel not returning to center after a turn, and also when in a slow sweeping curve that the wheel would hold the position and keep in the turn/curve unless corrected by manually turning it straight. I had new tires installed on 11/6/2024 and the alignment was checked and was correct. The tires that I chose turned out to be way harsher riding and noisy then the OEM's so I went with a different tire that was more EV specific. Nothing changed in regards to the steering issue. I checked online at the Chevy Bolt EV forum site to see if anyone else was having this problem and it appears to be a common issue with these cars. The steering rack should not be failing after 33K miles of use. It creates an unsafe condition when the steering does not return to center after a turn, or proceeding through a curve, and I'm sure it will only get worse as time/miles go by. I have a 2023 Chevy Bolt EUV that does not do this.....yet....but I have less than 2k miles on that vehicle.

Right brake caliper sticking intermittently, causing massive vibration in steering wheel and a caliper too hot to touch. In doing research on the Chevy Bolt forum, there were many people talking about this issue. In fact, GM issued a TSB about this issue, but when I entered my VIN in the GM site, it said that my VIN as not impacted; however, it was! I suggest that the NTSB do a further investigation to include all VINs affected with this issue. I had to spend several hundred dollars for a repair shop to replace the right brake caliper. Since the repairs were completed, I've had no issues whatsoever. Thank you.

The contact owns a 2020 Chevrolet Bolt EV. The contact stated that upon starting the vehicle, the message "Propulsion Power Reduced - Service Soon" was displayed, and check engine warning light was illuminated. The contact stated that upon investigation, it was discovered that the power output was limited. Despite the failure, the contact was able to drive the vehicle to the dealer. The contact was informed that the battery needed to be replaced. The contact was then informed that the battery replacement was on an indefinite backorder. The contact was not provided an estimate for when the battery would become available. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 25,100.

Steering wheel does not return to center on its own after a turn. The wheel will remain turned, and the car will continue turning, until it is forced back to center by the driver.

Backup camera system repeatedly shows as unavailable and may cause death due to low visibility.

This car several times while driving has shaken and then shifted into neutral. I have had to pull the car off to the side of the road during normal vehicle operation. The car will then not shift into drive. There is a warning sign "Conditions Not Correct For Shift." The first incident was March 2023. The vehicle was towed to a Chevrolet dealer and the power inverter module was replaced under warranty. This next occurred in December 2024. The vehicle was towed to a dealer again and reprogrammed. The cost was $400. The vehicle was fine for two months and about 1,000 miles when it happened again in March 2025. This time the dealer states that the engine harness needs to be replaced for about $1,500 (not covered under warranty). These incidents all occur while driving the vehicle (it has happened while approaching an intersection and once while going through an intersection).

On January 8, 2025 the battery in my car began to fail and had a message in the display to take it to my dealer. I drove it to the nearest dealer on January 10, 2025, about 10 miles (Billion Automotive in Iowa City.) While driving the power steering and braking began to fail. The dealer said that GM would need to replace the battery. It has been at the dealer for 2 months, and I was told today that it will be at least another 2 months before GM will replace the battery. The car is well under warranty.

The steering doesn't return to center when making turns on occasion. This issue can cause an overcorrection, this does seem to be a fairly common issue seen in various forums and appears to be a very expensive fix.