2003 CHEVROLET EXPRESS Complaints

I WAS TRAVELING ON THE HIGHWAY AT THE SPEED OF 50 MPH AND THE VAN SUDDENLY BEGAN TO VIOLENTLY SHAKE AND SHUDDER FROM THE FRONT WHEELS AND UP AND INCLUDING THE SHAKE OF THE STEERING WHEEL. I SLOWED THE VEHICLE DOWN BY BRAKING TO 35 MPH AND IT SLOWLY STOPPED SHAKING. THIS HAS BECOME A REGULAR ISSUE WITH THE VEHICLE AND I HAVE TAKEN IT FROM SHOP TO SHOP AND MECHANICS CANNOT FIGURE OUT THE PROBLEM. I FEAR FOR MY FAMILY'S SAFETY AS WELL AS MY OWN WHEN DRIVING ALONE IN THIS VEHICLE. IT HAS BEEN A YEAR SINCE THIS HAS BEGUN. MECHANIC HAS CHANGED THE SHOCKS FOR THE VAN AND IT HAS BEGAN TO VIOLENTLY SHAKE AND SHUDDER MORE FREQUENTLY. I NEED TO KNOW WHY THIS IS HAPPENING. I OWN A CHEVROLET EXPRESS 2500 (2003). *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THERE WAS A FUEL LEAK COMING FROM THE VEHICLE. THE CONTACT INDICATED THAT AFTER REFUELING, FUEL PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE FILLER NECK NEEDED TO BE REPLACED AND THE METAL FUEL FILLER PIPE WAS CORRODED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V388000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,500.

DRIVING ON INTERSTATE AT 65 MPH, THE ABS WARNING LIGHT CAME ON, AND THE SPEEDOMETER STARTED JUMPING ERRATICALLY FROM ACTUAL SPEED TO LOWER SPEEDS 45, 25 + OTHERS AS LOW AS 8 (EIGHT) MPH. THIS CAUSED THE TRANSMISSION TO DOWNSHIFT UNPREDICTABLY, OVER-REVVING THE ENGINE SPEED. IT HAPPENED REPEATEDLY SO I DOCUMENTED THE ODOMETER ERRATIC MOVEMENT ON MY CELL PHONE AS A VIDEO, SHOWING ROAD MOVEMENT + ALL GAUGES + AUDIO EVENTS LIKE ENGINE OVER-REVVING AT SAME TIME. THE VIDEO IS OF HIGH QUALITY AND THE EVENTS TAKING PLACE ARE DOCUMENTED WITH THE VIDEO. RURAL AREA WITH FEW CARS ON ROAD AT THE TIME. IF IT TOOK PLACE IN A CITY INTERSTATE ENVIRONMENT (ESPECIALLY IN THE WINTER MONTHS) IT MIGHT HAVE CAUSED A MULTIPLE CAR COLLISION WITH SUDDEN UNEXPECTED DOWNSHIFTING THAT WAS OUT OF MY CONTROL. ENGINE RPM ALSO HUNTS ERRATICALLY AND OUT OF MY CONTROL. PREDICTABLE IN WHAT IT DOES, IT BEGINS APPROXIMATELY WITHIN A RANGE OF 4-8 MILES AFTER LEAVING HOME DAILY. WHEN ENGINE TURNED OFF AND PARKED AT A LOCAL STORE AS AN EXAMPLE, IT WILL CLEAR IT'S PROBLEM AS IF A CPU IS "RE-BOOTED", AND REPEAT THE CYCLE OF ERRATIC BEHAVIOR FROM THAT NEW STARTING POINT. WHEN I BOUGHT + INSTALLED ACTRON BRAND OBD-II CODE READER WHICH FEATURES ABILITY TO REVEAL ABS BRAKE CODES, IT NEVER SHOWS ANY OTHER STORED CODES EXCEPT A SINGLE PO446 WHICH IS AN EMISSIONS RELATED CODE. THIS VAN WAS ORIGINALLY SENT NEW BY THE SELLING NH CHEVROLET DEALER TO THE PENNSYLVANIA BASED QUIGLEY CONVERSION FACILITY, SO IN FEBRUARY 2004 WAS MODIFIED FROM RWD TO A 4WD BY EXCHANGING STOCK MODEL 2500 FRONT END FOR A 4 WD PICKUP TRUCK NEW FACTORY FRONT END WITH 4WDL, NEUTRAL, 2WDH 4WDH FLOOR CONTROL LEVER. THE DRIVER'S DOOR JAM HAS AN 8600 LB GVW CERTIFICATION WHICH IS APPROPRIATELY QUIGLEY'S. MY VERY LOW ODOMETER AT 16,614 MILES IS ACCURATE, AS I ALSO HAVE OTHER VEHICLES TO USE, AND WORK AT HOME. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 1500 VAN. THE CONTACT STATED THAT WHEN FUELING THE VEHICLE, FUEL SPRAYED FROM THE FILLER NECK. THE DEALER DIAGNOSED THAT FUEL FILLER PIPE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

WHILE DRIVING VEHICLE, ALL ELECTRICAL STOPPED, DISCOVERED THAT THE IGNITION HAD TURNED OFF BY ITSELF AND CAUSED A LOSS OF ALL POWER CREATING DANGEROUS STEERING AND STOPPING SITUATION.. I WAS ABLE TO PULL TO THE SIDE OF ROAD AND STOPPED VEHICLE. TOOK THE TRUCK TO CHEVROLET DEALER IN SARASOTA RT. 41 AND BEE RIDGE AND WAS TOLD IT WAS NOT PART OF RECALL. THIS DOES NOT MAKE SENSE, IT HAS THE SAME SYMPTOMS AS THE OTHER DEFECTIVE VEHICLES MAYBE THEY DON'T WANT TO INCREASED THEIR PROBLEMS WITH ANOTHER YEAR AND MODEL. PLEASE HELP, I AM UNABLE TO DRIVE MY TRUCK FOR WORK AND AM LOSING MONEY AND CUSTOMERS, AS I AM A GENERAL ONE MAN CONTRACTOR. PLEASE ADVISE. *TR

THIS VEHICLE WAS BOUGHT BRAND NEW BUT UNBEKNOWNST TO ME WAS MADE IN CANADA (SOMETHING WHICH WOULD NOT HAVE BEEN ACCEPTABLE TO ME HAD I BEEN TOLD). UPON POSSESSION THE WINDSHIELD MOLDING CAME OFF ON THE RIDE HOME. THE DRIVER SIDE TIEROD END WENT AT 12,000 MILES AND AGAIN AT 24,000 MILES BECAUSE UPON INSPECTION THE BALL JOINTS WERE NEVER PROPERLY TIGHTENED. THE BOLTS ON THE TRANSMISSION WERE FOUND BY THE DEALER TO HAVE BEEN NEVER PROPERLY TIGHTENED. THE SIDEDOOR HINGE HAD TO BE REPLACED AT A COST OF $600 BECAUSE IT FROZE UP AND COULD NOT BE OPENED. THE POWER STEERING UNIT RUSTED OUT AT 12,000 MILES AND STARTED LEAKING FLUID AND, WHAT I FIND MOST IMPORTANT, I AM NOT SURE IF I HAVE AIRBAGS BECAUSE THE AIRBAG LIGHT STAYS ON BUT IS NOTED TO GO OFF WHEN THE KEY IS PARTIALLY TURNED HOWEVER THE KEY CANNOT STAY IN THIS POSITION AND MUST BE TURNED TO START THE VEHICLE. FUEL EXPECTATION WAS NEVER NEAR WHAT I WAS TOLD IT WOULD BE AND TAILPIPE CONSISTENTLY SHOWED EVIDENCE OF BEING BLACKENED DUE TO INSUFFICIENT FUEL BURNING. THE POOR BACKDOOR DESIGN MAKES IT DIFFICULT TO SEE OUT THE BACK WINDOW AND IT IS CLEARLY EVIDENT BY ALMOST EVERY VAN OF THIS TYPE HAVING A DENTED BUMPER DUE TO THIS BLINDSPOT IN DESIGN. I HAVE NOT BEGUN TO LIST ALL THE THINGS NOT RIGHT WITH THIS VEHICLE BUT I WILL CHALK THEM UP TO DOWNRIGHT LYING AND JUST INFERIOR PARTS AND CRAFTSMENSHIP. THIS VEHICLE HAS BEEN A NIGHTMARE. *TR

FOR THE SECOND TIME IN ONE WEEK THE ENGINE RACED TO MAX RPM WITHOUT A THROTTLE INPUT. HAD TO PUT IT IN NEUTRAL TO SLOW DOWN WITH THE BRAKES. THE FIRST TIME (35MPH SLOWING DOWN FOR A RED LIGHT) WENT TO NEUTRAL, FOOT ON BRAKE AND BACK TO DRIVE, THE ENGINE RESPONDED NORMALLY. LAST NIGHT THE ENGINE RACED TO MAX RPM AGAIN 100 FEET FROM MY PARKING SPOT GOING LESS THAN 5MPH WENT TO NEUTRAL BACK TO DRIVE NO CHANGE IN ENGINE SPEED BACK TO NEUTRAL GLIDE TO PARKING SPOT TURNED ENGINE OFF. NO WARNING WHEN THE MAX ENGINE REV WOULD BEGIN, ONE WAS SLOW SPEED THE OTHER MODERATE SPEED, TEMP 75 ONE DAY, TEMP 45 YESTERDAY. WORKED FINE TODAY. WORRIED THE PROBLEM IS NOT REPEATABLE OR CAN BE FOUND USING A CODE READER. WORRIED THAT THE ONLY WAY NOW TO STOP MAX ENGINE RPM IS BY TURNING ENGINE OFF, NOT SAFE WHILE DRIVING ON THE INTERSTATE. *TT

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS CONVERSION VAN. THE CONTACTED STATED THAT WHILE DRIVING 45 MPH, ALL OF THE GAUGES AND ELECTRICAL FEATURES FAILED HOWEVER, THE LIGHT FUNCTIONS REMAINED OPERABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. NO REPAIRS WERE PERFORMED TO THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 84,000. UPDATED 5/22/14*CN

DRIVER A NOTICED LACK OF PRESSURE IN BRAKE PEDAL. THE BRAKE PEDAL WENT FULLY TO THE FLOOR AND RESULTED IN LESS BRAKING THAN EXPECTED. DRIVER REDUCED SPEED BY DOWNSHIFTING TO LOWER GEARS (AUTOMATIC TRANSMISSION) AND PULLED INTO FIRST AVAILABLE PARKING AREA. BY PUMPING THE BRAKES AND PULLING INTO AN UPHILL PARKING SPOT, DRIVER ACHIEVED ENOUGH BRAKING TO COME TO A FULL STOP WITHOUT USING THE EMERGENCY BRAKE. INSPECTION SHOWED A NEARLY FULL BRAKE RESERVOIR AND NO LEAKAGE FROM WHEEL CYLINDERS. FURTHER INSPECTION SHOWED LEAKING FLUID FROM BRAKE LINE ON LEFT SIDE UNDER THE DRIVERS SEAT AND ABOVE THE VEHICLE FRAME. IT SQUIRTED OUT FROM A CRACK IN A BRAKE LINE WHEN BRAKE PEDAL WAS PUMPED. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS TOWED FOR REPAIR. *TR

MY 2003 CHEVY EXPRESS 2500 CARGO VAN WAS IN EVENING RUSH HOUR STOP AND GO TRAFFIC. AFTER REDUCING MY SPEED TO 10 MPH THEN ATTEMPTING TO ACCELERATE. THE VEHICLE STALLED AND BEGAN TO IDLE ROUGH AND SHUT-OFF. I HAD TO PUT THE VEHICLE IN NEUTRAL AND RESTART IN THE MIDDLE OF THE INTERSTATE. I HAD TO CONTINUE TO SHIFT INTO NEUTRAL AND PRESS THE GAS TO PREVENT THE VEHICLE FROM SHUTTING OFF IN THE MIDDLE OF TRAFFIC. I HAD THE PLUGS AND WIRES CHANGE THE VERY NEXT DAY AND THE PROBLEM CONTINUED. THIS COULD HAVE TURNED INTO A MAJOR ACCIDENT WITH THE VEHICLE SHUTTING OFF IN THE MIDDLE OF TRAFFIC. THIS ISSUE SHOULD BE ADDRESSED AND AN IMMEDIATE RECALL NOTICE SHOULD BE PUT INTO EFFECT TO PREVENT A MAJOR ACCIDENT WHICH COULD LEAD TO A POSSIBLE FATALITY. THIS IS DANGEROUS! I'VE RESEARCHED THIS ISSUE AND HAVE FOUND MULTIPLE CHEVY EXPRESS OWNER'S WITH THE SAME CONCERN. GM SHOULD DO THE RIGHT THING FOR THE CUSTOMERS WHO SUPPORT THEIR BRAND AND PRODUCT. *TR