2003 CHEVROLET EXPRESS Complaints

Odometer Fraud. The contact purchased a 2003 Chevrolet Express. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was approximately 156,000. It was later discovered that the mileage on July 2, 2024, was 258,051.

THE FRAME AND ITS CROSSMEMBERS ARE RUSTED (ROTTED) THRU ABOVE THE GAS TANK MAKING THE VAN USELESS. THE GAS TANK IS EVEN ATTACHED AT THOSE AREAS MAKING IT A TICKING TIME BOMB. THIS IS A KNOW GM FRAME PROBLEM FOR MANY YEARS ON MANY TRUCK BODIES.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE SEAT BELT BUCKLES PREMATURELY DETERIORATED TO THE POINT THAT THE BUCKLES FAILED TO LOCK THE SEAT BELTS TO SECURE A PASSENGER. THE MANUFACTURER INDICATED THAT A SEAT BELT RECALL REPAIR WAS PERFORMED IN 2016, BUT THE CONTACT EXPLAINED THAT THE REMEDY MAY NOT HAVE PROVIDED A SOLUTION. THE DEALER (MARSHFIELD CHEVROLET, 14963 MO-38, MARSHFIELD, MO 65706, (866) 218-7896) WAS CONTACTED. THE CONTACT WAS UNCERTAIN AS TO WHEN THE VEHICLE WOULD BE REPAIRED DUE TO THE MANUFACTURER STATING THAT THE RECALL HAD ALREADY BEEN PROVIDED. THE MANUFACTURER ISSUED FOUR TSBS AND THREE RECALLS FOR THE SEAT BELTS. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. *TT *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE CABLE THAT HELD THE SEAT BELTS TOGETHER, LOCATED IN THE REAR MIDDLE ROW, SNAPPED WITHOUT WARNING. AS A RESULT, THE CONTACT WAS CONCERNED THAT, IN THE EVENT OF A CRASH, THE SEAT BELTS WOULD NOT SECURE PROPERLY AND CAUSE AN INJURY. THE CONTACT ALSO STATED THAT THE REAR DRIVER AND PASSENGER SIDE DOOR HINGES FRACTURED. THE CONTACT STATED THAT THE DOORS WERE GLUED SHUT. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 228,000. UPDATED 10/17*LJ UPDATED 10/4/18*JB

SEVERAL OF THE EXHAUST HEADER BOLTS ARE BROKEN ON BOTH SIDES OF MY 5.3 LITTER ENGINE. I DID SOME INTERNET SEARCHING AND FOUND A LOT OF PEOPLE WITH 5.3 LITTER ENGINES HAVING THE SAME ISSUE.

CORRODED AND LEAKING FUEL FILLER NECK. FOOLISH DESIGN INVOLVING DISSIMILAR METALS HELD IN CONTACT AND SURROUNDED WITH A CONDUIT WHICH HOLDS WATER AND ROAD SALT. DESIGN IS DESTINED FOR FAILURE. GM HAS A PARTIAL RECALL FOR THE SNOW BELT. SUCH A FOOLISH DESIGN SHOULD BE FIXED EVERYWHERE AS IT IS JUST A MATTER OF TIME UNTIL FAILURE.

THE PASSENGER SIDE SWING DOORS ARE VERY HARD TO OPEN AND SHUT AND THE DRIVERS SIDE SWING DOORS ARE IN THE INITIAL STAGE OF THIS. THE PASSENGER SWING DOOR THAT IS FIRST TO OPEN (RIGHT) DOES NOT WANT TO OPEN AND DOESN'T WANT TO SHUT. I HAVE TO FORCE IT. THE SECOND DOOR (LEFT) IS GETTING WORSE AS WELL. THIS IS CAUSING THE INTERIOR LIGHT PIN IN THE DOOR JAM TO NOT PUSH IN ALL THE WAY, THEREFORE; THE LIGHTS WILL NOT SHUT OFF.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE FRONT OF THE VEHICLE VIBRATED WHENEVER THE VEHICLE WAS BEING DRIVEN OVER 30 MPH OVER A BUMP. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTROL ARMS, THE PITMAN ARM, THE TIRES AND THE HUBS WERE REPLACED, BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE. ....UPDATED 07/22/15 *BF UPDATED 10/4/2017*CN

I RECEIVED A NOTICE FROM GM ( DOC ID #32202443, #12167 FUEL FILLER PIPE CORROSION) STATING THAT THERE WAS A RECALL ON MY VEHICLE FOR LEAKING GASOLINE. I BROUGHT IT TO SIGHN CHEVROLET IN RIVERSIDE CA AND THE SERVICE MANAGER TOLD ME THAT CA VEHICLES DO NOT QUALIFY. I CONTACTED CUSTOMER COMPLAINTS CASE # [XXX] AND ALL THEY DID WAS CALL THE SAME SERVICE MANAGER AND GOT BACK TO ME SAYING THEY WON'T FIX IT. I BELIEVE I AM DRIVING AROUND WITH A VEHICLE LEAKING GAS ON THE ROAD CREATING AN EXTREMELY DANGEROUS SITUATION FOR MY FAMILY WITH A DIRE FIRE HAZARD. MY CONTENTION IS, WHY WOULD THEY SEND ME A RECALL NOTICE AND THEN TELL ME I DON'T QUALIFY? I DID RECEIVE THE NOTICE AND IT SAID IT HAD TO BE ACTED ON BEFORE 12/31/12 BUT IT WAS NOT LEAKING THEN. I DON'T CARE WHEN IT EXPIRES. IT IS A ADMITTED DEFECT AND GM SHOULD STAND BEHIND THEIR DANGEROUS ERRORS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TR

MY SPEEDOMETER QUICKLY JUMPS FROM ONE INDICATED SPEED TO ANOTHER SPEED THAT IS CLEARLY INACCURATE, DOWN AS LOW AS -0- WHILE DRIVING, ACCOMPANIED BY THE TRANSMISSION ATTEMPTING TO DOWNSHIFT ON IT'S OWN, WHICH CAUSES A SEVERE ENGINE OVER-REV CONDITION OR GOING INTO A NEUTRAL MOMENTARILY WITH NO INPUT FROM ME AS THE DRIVER. THERE ARE NO SPECIFIC ACTIONS I CAN TAKE TO TRIGGER THE ERRATIC SYMPTOM, NOR ANY SPECIFIC ACTION I CAN TAKE TO CAUSE NORMAL OPERATION. WITH SNOW AND ICE ON THE ROADS AT THIS TIME OF THE YEAR THIS IS EXTREMELY DANGEROUS AS IT COULD CAUSE THE VAN TO LOCK UP THE REAR WHEELS ON SLIPPERY PAVEMENT CAUSING LACK OF CONTROL. THIS CONDITION CAN OCCUR REGARDLESS OF WHETHER OR NOT CRUISE CONTROL IS SELECTED, REGARDLESS OF THE GEAR I MANUALLY SELECT, AND REGARDLESS OF THE TRAILER MODE BEING SELECTED OR NOT. SIMULTANEOUSLY THE "CHECK ENGINE" LIGHT GOES ON, THE "ABS LIGHT" AND "BRAKES" LIGHTS ARE LIT ON THE DASHBOARD ALTHOUGH NO BRAKING ABNORMALITIES ARE NOTED. I REPORTED A LESS SEVERE CASE OF THIS SEVERAL MONTHS AGO, BUT RECEIVED NO REPLY FROM THE NHTSA. DOING INTERNET RESEARCH I FIND THAT IT MAY BE A DEFECTIVE SPEEDOMETER DASHBOARD ASSEMBLY THAT WOULD NEED TO BE SENT AWAY FOR REPAIR/EXCHANGE. THEY REQUIRE A LARGE DEPOSIT IN ORDER TO GO THRU THE VERIFICATION PROCESS THAT THE ODOMETER READING I REPORT IS THE SAME AS THE UNIT I SEND IN. PART COST WITH DEPOSIT IS CLOSE TO $600, AND THEY SHOW AN ONLINE INTERNET VIDEO OF HOW TO REMOVE THE DASHBOARD UNIT WHICH TAKES LESS THAN 3 MINUTES. I'VE READ THIS IS A COMMON PROBLEM WITH THIS VEHICLE MAKE, MODEL AND YEAR. I AM THE ORIGINAL OWNER SINCE NEW, AND IT HAS LESS THAN 17,000 ACTUAL MILES ON IT. *TR