2003 CHEVROLET EXPRESS Complaints

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 1500. THE CONTACT STATED THAT FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN AND THE MECHANIC ADVISED THAT THE RETURN AND DELIVERY FUEL LINES WOULD HAVE TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT SHE NOTICED A LEAK UNDER THE VEHICLE WHEN SHE WOULD PUT REFUEL. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE FUEL FILLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD PAY A PORTION OF THE REPAIR COSTS. THE FAILURE MILEAGE WAS 126,600.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE THE TRANSMISSION FAILED TO SHIFT INTO GEAR. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE CAUSE OF FAILURE WAS UNKNOWN. HOWEVER, THE TECHNICIAN STATED THAT THE MAF CENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO STATED THAT THE VEHICLE NEEDED THE CATALYTIC CONVERTERS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 58,500.

WHEN THE VEHICLE FUEL TANK IS FILLED, GAS FUMES ARE DETECTED AND SOME FUEL CAN BE SEEN ON THE BOTTOM OF THE TANK (A FEW DROPS OF FUEL). AS THE TANK CONTENTS LOWER THE SMELL AND LEAK GOES AWAY. AN ACCESS HOLE ON THE SIDE OF THE VAN REVEALS THAT THE TANK HAS A SMALL LEAK WHERE THE PLASTIC FILL NECK WAS BONDED TO THE TANK. THE STEEL FILL NECK AND RUBBER CONNECTION LOOK FINE. THIS IS A CONVERSION VAN W/O A LEFT HAND DOOR. THIS VEHICLE WAS BOUGHT FROM A SOUTHERN CLIMATE AREA AND IS ONLY RECENTLY BEEN BROUGHT TO A NORTHERN CLIMATE SO CORROSION IS NOT SUSPECTED. SINCE I SEE NO RECALL OR MANY COMPLAINTS, I AM LOOKING TO REPAIR OR REPLACE THE TANK. CURRENTLY LOOKING FOR A SEAL MATERIAL THAT COULD BE APPLIED TO THE LEAK AND THAT WORKS ON POLYURETHANE AND RESISTS FUEL. HAVE NOT FOUND ONE. THE VEHICLE IS WELL OUT OF WARRANTY BUT THIS DOES SEEM TO PRESENT A SAFETY ISSUE. SHORT TERM SOLUTION IS TO NOT FILL THE TANK. *TR

DURING A FAMILY OUTING WE WERE UNABLE TO CLOSE THE RIGHT REAR PASSENGER DOOR. EXPERIENCED DIFFICULTY CLOSING DOOR. AFTER SEVERAL ATTEMPTS, I NOTICED THE DOOR WAS NOT ALIGNED WITH THE BODY OF THE CAR WHICH PROHIBITED THE DOOR LATCH TO CONNECT AND CLOSE. THE DOOR WOULD NOT CLOSE SHUT COMPLETELY AND HAS SINCE KNOCKED WHILE DRIVING AND ALSO CREATES A SAFETY HAZARD FOR CHILDREN & ADULTS BECAUSE IT IS PRIMARY EXIT FOR THE REAR EXIT TO THE SIDEWALK FORCING PASSENGERS TO EXIT FROM THE REAR LEFT DOOR PASSENGER DOOR ONTO THE STREET TO ONCOMING TRAFFIC THAT CAN LEAD TO ACCIDENT, BODILY INJURY OR FATALITY. NO PRIOR MAINTENANCE INSTRUCTIONS OR SUGGESTED UPKEEP WAS DOCUMENTED IN THE BUYERS MANUAL WHICH CAME WITH THE VEHICLE THAT WOULD INDICATE POSSIBLE HINGE CORROSION OR RUSTING. POSSIBLE PIN DEFECT DETECTED BY CERTIFIED DEALER ON 10/7/2012, WHEN TAKEN IN FOR SAFETY RECALL ON FUEL FILLER PIPE RECALL 12166 CAMPAIGN ID#12V388. MULTIPLE COMPLAINT FOR HINGE/PINS HAVE BEEN DOCUMENTED IN COMPLAINTS ON SAFERCAR.ORG WEBSITE FOR 2003 CHEVY EXPRESS VAN. I BELIEVE THIS ISSUE SHOULD BE INVESTIGATED TO AVOID ACCIDENTAL DEATHS DUE TO INOPERABLE ACCESS TO SIDEWALK FROM THE LEFT REAR PASSENGER DOOR. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT THE SEAT BELT BUCKLE ASSEMBLY BROKE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE SEAT BELT WAS WORKING UP TO SPECIFICATIONS. THE DEALER STATED THAT THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 03V050000 COMPONENT: SEAT BELTS:FRONT:BUCKLE ASSEMBLY. BUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS 65,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. THE CONTACT STATED THAT A SMALL AMOUNT OF FUEL CONTINUOUSLY LEAKED OUT OF THE FUEL TANK FILLER NECK IMMEDIATELY AFTER REFUELING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL FILLER NECK TUBE EXHIBITED RUST CORROSION. THE PART WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 12V388000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY: FILLER PIPE AND CAP) HOWEVER THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS CONVERSION VAN. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, HE NOTICED A HOLE IN THE FUEL FILLER NECK. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 127,000.

ON A FEW OCCASIONS PRIOR TO LOCATING A LEAK, I NOTICED A GASOLINE SMELL. FINALLY WHEN FILLING EARLIER THIS MONTH, I SAW A LOT OF LEAKING COMING OUT OF THE FUEL FILLER TUBE, BETWEEN THE METAL TUBE AND THE PLASTIC COVER SURROUNDING THE TUBE. WHEN I GOT HOME, I CUT OFF THE PLASTIC TUBE ABOUT HALFWAY AND FOUND A STATIC WIRE RUNNING THE LENGTH OF THE TUBE. EVERYWHERE, WHERE THIS WIRE TOUCHED TO METAL PIPE, IT WAS CORRODED COMPLETELY THROUGH. THE STATIC WIRE IS OF A DIFFERENT MATERIAL AND WAS NOT CORRODED. PRESENTLY I HAVE WRAPPED THE TUBE WITH A GASOLINE RESISTANT TAPE. BUT, I WILL HAVE TO REPLACE THE TUBE SOON. THE LOCAL DEALERSHIP HAS QUOTED APPROX. $241.00 WITHOUT INSTALLATION. ARE THERE OTHER INSTANCES LIKE THIS AND IS THERE A RECALL I'M NOT AWARE OF. THANK YOU FOR YOUR TIME. *TR

FOR SOMETIME, THERE WAS A SMELL OF GASOLINE WHEN FILLING THIS VAN, WHICH I JUST ATTRIBUTED TO A VAPOR RELEASE WHEN THE TANK WAS FULL. RECENTLY, I NOTICE GAS LEAKING UNDER THE VAN WHEN FILLING AT THE GAS STATION. THE GAS LEAKS IN AND AROUND THE BRAKE LINES. THIS VAN IS A 2003 CHEVROLET EXPRESS 1500 WITH LEFT HAND DOOR OPTION. THIS IS MY FAMILY VEHICLE AND IN RESEARCHING THIS PROBLEM FURTHER, I UNDERSTAND IT TO BE A KNOWN PROBLEM AND A DESIGN FLAW, WHERE THE FUEL FILL HOSE RUSTS. THIS NEEDS A RECALL WITH IMMEDIATE ATTENTION. *TR