2003 CHEVROLET EXPRESS Complaints

SEAT BACK OF DRIVERS SEAT FAILED AND NOW SEAT WILL NOT STAY IN THE UPRIGHT POSITION. THE VEHICLE WAS NOT INVOLVED IN A COLLISION AND THIS OCCURED WHILE DRIVING. *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE VEHICLE MADE A GRINDING NOISE. HE INSPECTED THE VEHICLE AND DISCOVERED THAT THE FRONT AND REAR BRAKE PADS AND ROTORS WERE CORRODED. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THEY COULD COVER 50% OF THE REPAIR COST FOR THE ROTORS; HOWEVER, THE CONTACT WOULD BE RESPONSIBLE FOR THE BRAKE PADS AND ANY ADDITIONAL COSTS. THE VEHICLE IS OUT OF WARRANTY. THE MANUFACTURER ALSO STATED THAT IF THE VEHICLE IS NOT DRIVEN REGULARLY, THE COMPONENTS COULD CORRODE. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 38,000.

TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 1500. ON SEPTEMBER 7, 2008, THE CONTACT STARTED THE VEHICLE AND HEARD A KNOCKING SOUND. THE SOUND ORIGINATED FROM THE ENGINE AND PERSISTED THROUGHOUT THE DAY. HE CHECKED THE OIL AND NOTICED THAT THERE WAS ONLY ONE QUART. HE PLACED MORE OIL IN THE VEHICLE. THE FAILURE DID NOT PREVENT HIM FROM ACCELERATING. THE CONTACT TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND WAS INFORMED THAT THE LIFTERS AND PUSH RODS WERE DEFECTIVE, WHICH CAUSED THE ENGINE TO FAIL. THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 138,000.

(1)SEAT BELT WILL NOT LATCH. SEATBELT LATCH OPENS WITHOUT WARNING. (2)THE SIDE CARGO DOOR HINGES ARE FAULTY AND HARD TO OPEN. OPENS WITHOUT WARNING. *TR

I PURCHASED MY 2003 CHEVY EXPRESS 3500 IN 2003. ON THE PASSENGER SIDE OF THE VAN THERE IS A FRONT PASSENGER DOOR AND ARE TWO PASSENGER DOORS ON THE SIDE OF THE VAN. IN FIVE YEARS TIME I HAVE HAD TROUBLE WITH THE SIDE PASSENGER DOOR HINGE SEIZING UP AND NOW I CAN'T OPEN THE LEFT SIDE DOOR AND IT IS IMPROPERLY SEATED IN THE DOOR OPENING, I NOW DO NOT HAVE A TIGHT SEAL AND THE RIGHT SIDE DOOR CANNOT CLOSE PROPERLY. THIS POSES A SAFETY HAZARD BECAUSE IN AN EMERGENCY THE LEFT SIDE DOOR CANNOT BE OPENED. *TR

AT 4:30 A.M. ON THE MORNING OF FEB 13 2008 WAS AWOKE TO FLAMES FLICKERING ON BEDROOM WALL IT WAS MY 2003 REGENCY CONVERSION VAN GOING UP IN SMOKE NO APPARENT REASON BUT IT DID START IN THE FUSE BOX AREA MAYBE THE SAME ISSUE AS THE HORN PROBLEM THE WEEK BEFORE HAD THE SAME PROBLEM OF HORN GOING OFF IN THE MIDDLE OF THE NIGHT BUT THERE WAS NO FIRE AT THAT TIME. *TR

2003 CHEVY EXPRESS. TURNED ON THE REAR DEFROSTER. THE REAR PASSENGER SIDE WINDOW CAUGHT FIRE AND BEGAN BURNING. PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND ANOTHER CAR PULLED OVER WITH ME. THE WINDOW CONTINUED TO BURN, AND THEN EXPLODED IN MY FACE. THE FIRE WENT OUT AND THE WINDOW HAD SHATTERED INTO FRAGMENTS. *TR

DURING ROUTINE MAINTENANCE OF MY 2003 CHEVY EXPRESS VAN, I NOTICED THAT BOTH INNER TIE RODS HAVE EXCESSIVE END PLAY IN THEM, LEFT INNER AND RIGHT INNER. I DO NOT BELIEVE THIS IS A NORMAL WEAR PROBLEM AND IS A VERY DANGEROUS CONCERN. *TR

TL*THE CONTACT CALLED REGARDING A 2003 CHEVROLET EXPRESS 1500. THE CONTACT IS THE PHYSICAL DAMAGE INSPECTOR FOR AN INSURANCE COMPANY. HE STATED THAT THE VEHICLE WAS PARKED WHEN THE HORN BEGAN TO SOUND. HE STATED THAT THE HORN IS ALSO USED AS AN INTRUDER ALARM. SHORTLY AFTER, FLAMES BEGAN TO RISE FROM THE HOOD. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT IT WAS NOT A WARRANTY RELATED FAILURE. THE DEALER ALSO STATED THAT THE WIRE THAT RUNS FROM THE HORN RELAY TO THE ACTUAL HORN IN THE STEERING WHEEL COLUMN SUPER HEATED, WHICH CAUSED THE FIRE. A POLICE REPORT WAS FILED. THE PURCHASE DATE AND MILEAGES WERE UNKNOWN. RETURN USPS, MADE 2ND ATTEMPT 08/04/07 FAILED. *BF

TL*THE CONTACT OWNS A 2003 CHEVROLET EXPRESS. WHILE PREPARING TO STOP FROM 20 MPH, THE VEHICLE FEELS AS IF IT IS GOING TO STOP, BUT SUDDENLY LUNGES FORWARD. AFTERWARDS, THE VEHICLE WILL STOP. THE DEALER STATED THAT HIS VEHICLE IS NOT INCLUDED IN THE RECALL FOR THIS FAILURE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 42,000.