2006 CHEVROLET EXPRESS 3500 Complaints

DRIVERS SEAT WAS LOOSE AND ON INSPECTION DEALER FOUND THAT THE RAIL WAS BROKEN, THE VAN ONLY HAS 72785 MILES. IF THE SEAT HAD COME LOSE WHILE VAN WAS IN MOTION, IT WOULD HAVE CAUSED AND ACCIDENT. I NOTICED IT WHEN I TOOK THE VAN FOR INSPECTION.

TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE VALVE STEMS WERE DEFECTIVE. THE VEHICLE WAS TAKEN TO A TIRE SHOP WHERE IT WAS DIAGNOSED THAT THE VALVE STEMS WERE ROTTED. THE VALVE STEMS WERE REPLACED. THE FAILURE MILEAGE WAS 30,000. THE VIN WAS UNAVAILABLE.

WE PURCHASED AN EXPRESS VAN IN THE SPRING OF 2006. TRUCK ENGINE BLEW UP AT 6000 WHILE DRIVING ON THE FREEWAY. IN JANUARY 2014, WE TOOK THE CAR INTO A DEALERSHIP BECAUSE IT STALLED 3 TIMES. THE DEALERSHIP PUT IT ON THE COMPUTER DIAGNOSTIC DEVICE AND COULD NOT FIND ANYTHING WRONG WITH THE VAN. APPROXIMATELY 3 WEEKS LATER, ON FRIDAY THE 24TH THE CHECK ENGINE LIGHT CAME ON, WE THEN TOOK IT BACK TO THE DEALERSHIP AND AT THIS POINT THEY TOLD US THAT THE TRANSMISSION WAS THE PROBLEM. THE CAR HAD JUST OVER 32,000 MILES WHEN TRANSMISSION BLEW UP IN JANUARY OF 2014. AFTER THE TRANSMISSION WAS REPLACED THE CAR CONTINUED TO STALL AND WAS TAKEN BACK INTO THE DEALERSHIP AND IT HAD A BUSHING BROKEN IN THE FRONT SUSPENSION. THIS VAN CONTINUES TO STALL AND AT TIMES FAILS TO START. WE ARE CONFIDENT THAT THE STALLING PROBLEM THAT WE ARE EXPERIENCING IS THE SAME AS THE CARS THAT ARE PART OF THE RECALL AND EXPRESS VANS SHOULD BE ADDED TO THE LIST OF RECALLED VEHICLES. THIS VEHICLE ONLY HAS 33,000 MILES ON IT AS OF MARCH 2014. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE BEGAN SHAKING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THERE WAS PREMATURE WEAR OF THE STEERING DUE TO THE PITMAN ARM ROLLING AGAINST THE OUTER AND INNER TIE ROD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,000. *TR

PAINT (WHITE) IS FALLING OFF VAN AT HOOD, SIDES AND MOSTLY ON AREAS WHERE THESES WELDED AREAS...DEALER SAID THEY NEVER SEEN THIS ISSUE?? I HAVE SEEN HUNDREDS OF THE SAME ISSUE ON OTHER VANS. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET EXPRESS CUTAWAY G3500. WHILE DRIVING APPROXIMATELY 6 MPH, THE CONTACT APPLIED PRESSURE TO THE BRAKES WHEN HE NOTICED THAT THE BRAKES WENT TO THE FLOORBOARD ABNORMALLY. HE QUICKLY APPLIED THE EMERGENCY BRAKE, WHICH WAS ABLE TO IDLE THE VEHICLE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THERE WAS A BRAKE FLUID LEAK. THE DEALER ADVISED THE CONTACT TO CALL THE WARRANTY COMPANY. THE WARRANTY COMPANY ADVISED THE CONTACT THAT THIS ISSUE WAS NOT COVERED UNDER WARRANTY AND THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE BRAKE LINES WERE REPLACED. THE MANUFACTURER WAS NO LONGER IN BUSINESS. THE APPROXIMATE FAILURE MILEAGE WAS 12,000.

PERSON WAS IN AN ACCIDENT WHEN THE 2006 GM CHEVROLET TRUCK EXPRESS SUDDENLY ACCELERATED AND HIT A TREE. THE CAR HAD BEEN BROUGHT IN FOR THE SAME PROBLEM AND NOTHING WAS DONE AT THE DEALER. *TR

TL*THE CONTACT OWNS A 2006 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE STEERING CENTER LINK UNDERNEATH THE FRONT END OF THE VEHICLE, WHICH CONNECTS THE TIE RODS TO THE WHEEL, MOVES ABNORMALLY. THE FAILURE CAUSES THE TIRE TREAD TO WEAR EXCESSIVELY. ON ONE OCCASION, WHILE DRIVING AT AN UNKNOWN SPEED IN SLIPPERY WEATHER CONDITIONS, THE VEHICLE ROLLED OVER. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE CURRENT MILEAGE WAS 56,000 AND THE FAILURE MILEAGE WAS UNKNOWN.

2006 CHEVY EXPRESS 3500 CARGO VAN WITH DURAMAX ENGINE AND 4L80 TRANSMISSION MADE A 'WHINING' NOISE AT SLOW SPEEDS SINCE IT WAS BRAND NEW. AT ABOUT 31,000 MILES I FINALLY CONVINCED THE DEALERSHIP SOMETHING WAS WRONG WITH IT. IT HAD SOME KIND OF BAD BEARING AT THE REAR OF TRANSMISSION. THEY REPLACED THE ENTIRE TRANSMISSION WITH A BRAND NEW TRANSMISSION. 7,000 MILES LATER THE VAN SUDDENLY LOST REVERSE GEAR AND I HAD TO GET IT PUSHED IN ORDER TO BACK UP. GM IS REPLACING SOME PARTS, BUT NOT THE WHOLE TRANSMISSION. FROM OTHER POSTS ON YOUR WEBSITE THIS TRANSMISSION IS GOING TO CONTINUE TO BE AN UNSAFE PROBLEM. *TR

TL*THE CONTACT OWNS A 2006 CHEVROLET EXPRESS 3500. AFTER THE VEHICLE HAD BEEN PARKED FOR 45-60 MINUTES, IT WAS FOUND SMOKING AND ON FIRE. THE VEHICLE WAS DESTROYED AND A FIRE REPORT WAS FILED. THE CONTACT HAS PICTURES. THERE IS CURRENTLY AN OPEN INVESTIGATION (NUMBER PE08010) FOR THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 10,000. UPDATED 3/19/08 *CN THE CONSUMER STATED INSURANCE ADJUSTER EXAMINED THE VEHICLE DETERMINED THAT IT WAS EXTENSIVE ENOUGH DAMAGE TO BE DEEMED AS TOTALED. UPDATED 03/19/08 *TR