2016 CHEVROLET SILVERADO 1500 Complaints

On road trip from mi to ny. No lights or warnings but transmission failed.we were able to get safely off highway into parking lot.Tried to have towed to chevy dealer but could not look at for days. Able to take to aamco & need to install new transmission in ohio!

I am reporting a manufacturing defect involving General Motors’ Active Fuel Management (AFM) system. In October 2024, my 2016 Chevrolet Silverado 1500 LT, at 96,000 miles, experienced a lifter collapse which caused sufficient wear to the camshaft that the engine needed to be replaced, which was performed. The malfunction indicator lamp turned on and the truck was driven an additional 2 miles to a safe location and subsequently towed to the repair shop. Before then, there had been no indication that a lifter had collapsed or that there was damage to the engine sufficient to warrant a replacement. In November 2025, I experienced another lifter collapse (on the replaced engine). While the mechanic recommended an engine replacement, the warranty company only authorized a replacement of the affected side cylinder head and lifter, which was performed. In February 2026, I experienced another lifter collapse, and the truck is currently being evaluated by a repair shop. These failures have occurred without warning and aligns with thousands of consumer complaints regarding AFM-related oil consumption, lifter collapse, and engine damage in GM vehicles. This is a known design defect that GM has tried to address through Technical Service Bulletins and engine redesigns, yet many consumers continue to experience premature failures at low mileage. This defect presents a safety and reliability concern, including loss of power while driving and significant financial burden to vehicle owners. I respectfully request that NHTSA investigate this ongoing defect.

The contact owns a 2016 Chevrolet Silverado1500. The contact stated that while driving at 48 MPH and driving uphill, the transmission downshifted and started sputtering. The contact pulled into a parking lot and attempted to troubleshoot the failure, but the failure persisted. The vehicle was driven to an independent mechanic, where it was diagnosed with a torque converter failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 103,000.

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that the transmission valve body had failed and needed to be replaced; however, the part was on backorder. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,000.

I am reporting a manufacturing defect involving General Motors’ Active Fuel Management (AFM) system that caused catastrophic engine failure in my 2016 Chevrolet Silverado (VIN: [XXX] ). At approximately 78,000 miles, my vehicle experienced piston and lifter failure requiring full engine replacement. This failure occurred without warning and aligns with thousands of consumer complaints regarding AFM-related oil consumption, lifter collapse, and engine damage in GM vehicles. This is a known design defect that GM has addressed through Technical Service Bulletins and engine redesigns, yet many consumers continue to experience premature failures at low mileage. This defect presents a safety and reliability concern, including loss of power while driving and significant financial burden to vehicle owners. I respectfully request that NHTSA investigate this ongoing defect. Sincerely, [XXX] [XXX] [XXX] [XXX] VIN: [XXX] 2016 Chevrolet Silverado INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2016 Chevrolet Silverado 1500. While driving at an undisclosed speed, the steering wheel became stiff and then loosened. The steering started turning independently and was uncontrollable. The vehicle was pulled over to the side of the road. The power steering warning light and several other unknown warning lights were illuminated. The vehicle was taken to a private mechanic, who declined to repair it due to the vehicle having an active recall. The vehicle was then taken to a dealer who also declined to perform the recall repair because the vehicle had a salvage title. The manufacturer was notified of the failure. The failure mileage was approximately 87,000.

2016 Silverado z71 with 6L80 transmission started slipping gears and shudders when accelerating. Vehicle was looked at by a mechanic who drove it and confirmed that the transmission is the issue and said a rebuild is needed.

The rear 3rd brake light above the back glass started leaking because the seal/gasket went bad. Water leaked into the cab and now the headliner has to be replace as well as that seal. I works for a glass company and this is a known problem for this year. There should be a recall or service campaign put out for this. I'm not the only one with this issue.

I am writing about my recent engine failure on my 2016 Chevy Silverado High Country. This is a 4x4 with the 6.2L motor. My engine has failed at only 66,790 miles due to the lifter issue that seems to be common with these motors. I noticed a loud ticking from my motor that was getting worse. I took it into A1 Automotive Georgetown, TX. They advised me to contact a dealership for Warranty repair or replacement as they noted it was coming from the valves. I contacted Don Hewlett Chevrolet; they advised me due to the date of the truck being made in 2016 it is no longer covered in warranty and the advisor said they do not see engines with lifter issues. I did standard service with an oil and transmission change using the recommended 0W-20W oil. The next day the ticking was very bad and turned into what I would describe as ‘jack hammer’ noises. Then I lost power while driving and the dashboard lights came on. I got towed back to A1 Auto; they drained the oil and noticed a lot of metal fragments and advised me that theck engine will need to be replaced. The engine was removed and we found the pushrod on the passenger side was sticking out to the side of the rocker arm presumably due to a lifter issue. I now have a new engine with the ‘delete kit’ to remove the 4-cylinder shutoff that has been linked to lifter failures. This has been a very unnecessary expense for something that shouldn’t happen. The motor only having 66,790 miles and I am the only owner, I have always taken very good care of it, and even use only premium gas. I have gotten all the oil changes on time and most of them have been done by the dealership at Don Hewlett. Date of ticking inspection and oil change, A1 Auto – 12/16/2025 miles 66,766 Date of failure 12/17/2025 miles 66,790 Charges: •Towing $235 •Engine replacement $14,064.90 oEngine $8,375 oLabor $3,750 oInjectors $1042 oOil, Tax, misc. $897

The contact owns a 2016 Chevrolet Silverado 1500. The contact stated that when the vehicle was started, the rear sliding glass defroster element overheated. The contact was unsure but thought that the defroster had activated independently. The contact stated that the heating element had caught fire, burned a hole through the weather stripping, and shattered the rear sliding glass. The contact extinguished the fire with a can of soda. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not yet diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 106,000.