2023 CHEVROLET SILVERADO 1500 Complaints

Battery keeps going dead 4 batteries in 4 months think it is caused by power tailgate release

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle made an abnormal sound and failed to respond as intended. The vehicle was taken to the dealer. The dealer contacted the manufacturer and was helped in diagnosing the vehicle. The dealer replaced the front brakes on several occasions and replaced the rear brakes once. The contact stated that the 360-degree camera had become inoperable. The vehicle was taken to the dealer, where it was repaired. Additionally, the contact stated that while the dealer was completing a transmission recall repair, the dealer informed the contact that there was an engine oil leak between the engine and the transmission. The contact stated that while driving at various speeds, the engine overheated. The message "Reduce Acceleration - Drive with Caution" was displayed. The vehicle was taken to the dealer, where it was diagnosed with cooling system failure. The vehicle was repaired; however, the failure recurred. Additionally, the instrument panel was intermittently blank. The vehicle was taken back to the dealer. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,000.

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that the engine failed after the vehicle was repaired under NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The contact stated that while driving 70 MPH, the vehicle lost motive power. The message "Hot Oil Shutting Down" was displayed. The contact coasted to the side of the road, and the vehicle was towed to the dealer. The dealer determined that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 36,500.

My engine completely died, and a complete loss of propulsion happened. My safety was put at risk due to no power while on busy highway. This problem with L87 engines (6.2) has been reported extensively. The vehicle was inspected for GM Program # N252494000, NHTSA 25V74 for above issues and was inspected on 2025-08-28. Inspection passed, but the failure ultimatel happened on 2025-02-25. Dealer indicated engine was covered under original powertrain warranty and GM would send a remanufactured engine. Dealer has still not received the engine as of Monday (2/23), which is almost a month later. While driving on a US highway in a rural area, my engine suddenly died while driving approximately 60mph. The restart engine light came on, and I quickly was unsure what was happening as I felt myself slowing down slightly after realizing I had no power and the engine would not restart. I believe it went to neutral automatically. I was in the inside lane, and it was incredibly dangerous due to traffic around me. I could not easily exit to side of road due to the traffic, but luckily a gap formed, and I was able to abruptly get off the road. I have kids in the car daily, and this would have been life threatening had it happen in any other scenario, or especially in a larger city or busier highway. I am confident this is related to GM's issues with the 6.2 liter engines. I have a 2023 Silverado 1500 ZR2 that this happened to. The loss of propulsion is clearly due to the defect in these engines.

The contact owns a 2023 Chevrolet Silverado 1500. The contact stated that on two separate occasions while hauling the camper, the "High Diesel Exhaust Fluid", Exhaust Fluid Range", and "Fill DEF (Diesel Exhaust Fluid) Now" warning messages were displayed on the instrument panel. The messages indicated that the Diesel Exhaust Fluid was low and needed to be replenished. The contact stated that the failure caused the instrument panel to freeze and not operate as needed. Upon attempting to refuel the vehicle, fuel failed to enter the fuel tank since the diesel tank was full. The vehicle was taken to a dealer, where the contact was informed that the failure was an electrical glitch and that there were no issues with the Diesel Exhaust Fluid system. The contact was also informed by the dealer of Technical Service Bulletin: 22-NA-150, which the contact related to the failure. The dealer reset the vehicle, which caused the instrument panel to return to normal operation. The manufacturer was then notified of the failure, and the contact was informed that vehicle was not included in the TSB. The contact was given a case number and was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 55,000.

The vehicle lost power and went into limp mode on 3/3. I had it transported to a dealership and they said there was metal containments in the motor. I got it back on 3/17 and they said all was well but it never drove right. It broke down again on 3/20 and the said the throttle body was out. Why had they not found this issue before? This seems to be a recurring issue with this model truck.

Valve body in the transmission failed while driving on the freeway, all of a sudden it was like the car was in neutral and the RPM's went to redline. Dealer is telling me it is a known issue and has no idea on when they will be able to get parts because they have been on backorder forever. Says that they also have to replaced the Transmission Control Module (TCM). same thing no eta on parts. If this is a known issue why have they not recalled them. Fom what I see on line this failure is happening a lot to people, hence the unavailability of replacements parts.

The Def guage does not work properly. After topping off with DEF the guage would not register being full. Also the guage would read over half full and within minutes I would receive a notification that the truck was going into limp mode due to be out of DEF. Happened several time while on a trip. Also truck went into limp mode while DEF was full.

Engine failed, started making noise and was shutting off, engine was locking up.

Driving at highway speeds the message center prompted us to restart the truck and put itself into neutral. Upon attempting to do so, the message center read conditions not correct to shift. We were traveling in a single lane highway thankfully on a decent where we coasted into a parking lot. The truck list all power steering and brakes. We turned the truck off and attempted to restart. Lights were randomly flickering on and off, but the starter couldn’t turn the engine over. After 3 hours of waiting on Chevrolet roadside assistance we obtained our own tow service. The truck tires had seized up causing the driver to drag the truck into the flatbed. The emergency brake kept resetting itself. The following day 7/13 Chevrolet had the truck towed to the dealership. On Monday 7/16 we were informed the engine had catastrophic failure with less than 24k miles. This is the second major engine breakdown as the first was at 5k miles where one side of the engine had collapsed lifters. Engines are on back order but in reviewing other experiences the replacements experience the same issues. The truck is not a safe vehicle to drive.