2015 CHEVROLET SILVERADO 3500 Complaints

I own a 2015 Chevrolet Silverado 3500HD Duramax diesel. At approximately 130,000 miles, the high-pressure CP4 fuel pump failed internally, sending metal shavings throughout the fuel system and contaminating major components. The truck suddenly lost power on the freeway and became inoperable without warning. I was barely able to get out of traffic before it had to be towed to a Chevrolet dealership. This created a serious safety hazard, especially considering the risk if it had happened while towing my fifth wheel with my family. A failure like this should not happen at this mileage on a heavy-duty diesel truck. I also cannot afford the extremely high cost of repairing the entire fuel system. From my research, many other owners have experienced the same CP4 fuel pump failure, which often destroys the entire fuel system and leads to very expensive repairs. I believe this is a widespread defect, not normal wear and tear. I ask NHTSA to review these failures and take action to protect vehicle owners from similar dangerous and costly failures. This truck currently sits at the dealership as I cannot afford the repairs and GM will not fix what they know is faulty parts.

Truck was operating on the highway at highway speed. Suddenly the truck went into a drastic engine power reduction mode and severe automatic downshifting occurred; the truck came to a complete stop on the highway. Diagnostics proved to be a CP4 injector pump failure sending metal into the fuel system, needing a complete contamination kit and new CP3 pump conversion. This apparently is a known defect in GM vehicles and should have been recalled.

The 2nd stage of this truck was not completed and the title was done in fraud in 2015 by Jon Hall Chevy in Daytona. I need this inspected as it shouldn't be on the road. Only 1 MCO without water Marks on it. this is a 2 stage truck should have 2. but nope only one we are getting the run around.

Exhaust filter plugged due to turbo not working properly. Been at dealership going on 7 weeks This is the 3rd new vehicle we have had this has happened to.

The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while driving 65 MPH, the message "Fuel Filter Needed to be Replaced" followed by the "Engine Power Reduced" were displayed on the instrument panel. The contact then stated that fuel started leaking from the vehicle and the vehicle stalled. The contact was left stranded in the middle of the road; a tow truck was called, and the vehicle was towed to an independent diesel mechanic. The mechanic performed a diagnostic test, and the contact was informed that the fuel pump had disintegrated which caused debris from the fuel pump to leak into the fuel system. The contact was provided an estimate to replace the fuel pump, fuel pump filter, fuel pump housing, and the fuel injectors. The manufacturer was notified of the failure and referred the contact to the NTHSA Hotline to file a complaint. The vehicle had yet to be repaired. The failure mileage was approximately 270,000.

A rear defrost system malfunctioned and was smoking in the interior of the vehicle followed by the rear glass shattering. The electrical malfunction could have easily started a fire and glass flying around the cab a highway speeds could definitely be hazard. I called the dealership and they were unconcerned and gave me a quote to replace it. the dealer or the aftermarket glass replacement company have not heard of it happening. I did find a recall in Canada. Strangely enough mine was done in Canada and it happened again.

The contact owns a 2015 Chevrolet Silverado 3500. The contact stated that while the vehicle was parked, the contact noticed that the instrument panel was inoperable. The contact stated that the instrument panel failed to function properly while attempting to activate the windshield wiper. The vehicle was taken to the dealer, where it was diagnosed that the fuse block had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 5,100.

The brake pedal pivot bolt nut loosened itself and came off of the bolt, allowing the bolt to back out of the pedal mount and the brake pedal fell out of position and became lodged behind the accelerator pedal. Thankfully no accident occurred. After performing research with local dealer and independent repair shop it was found to be an obvious repeat failure of the General Motors safety recall #20760E already performed on the vehicle. I reached out to GM customer support who were rude and I received no help in the matter. Can provide more information upon request.

Cooper Discoverer STT Pro (LT295/55R20/10). Driving south bout on Meadowbrook State Parkway about 1/2 mile north of the Southern State Parkway in New York State (Long Island) when a catstrophic failure of the front right tire occurred without warning or provocation. Tires were about 18 months old and had about 25000 miles on them. All traffic was at extreme risk with the sudden blow out at highway speed. The tire failed in its entirety becoming completely separated! I struggled to maintain control of the vehicle while avoiding contact with other vehicles barely managing to get off the road. This tire was most likely defective and should not have failed. The vehicle was towed with the help of AAA to Mavis Discount tire who replaced the tires with a different brand.The seller and manufacturer customer service was god awful and didn't care. All four tires had to be replaced. NO warning indicators were present at any time. The cause of the catastrophic failure is unknown but like I said the tire appears to have been defective. There was no contact or damage prior to the failure. I have pictures of the failed tire.

Bosch CP4 fuel pump failed 400 miles from home leaving us stranded. We were towed in and spent thousands of dollars and 5 weeks to have the truck repaired. Only warning was that the truck was losing power and barely got off the road.