2001 CHEVROLET SUBURBAN Complaints

FIRST INCIDENT: VEH. WOULD CRANK BUT NOT START. TURNED OUT TO BE FUEL DELIVERY FUSE. REPLACED, AND RAN FINE FOR SEVERAL WEEKS. SECOND INCIDENT: DRIVING AT APPROX. 55 MPH, VEHICLE LOST POWER, STARTED SPUTTERING AS IF OUT OF GAS ALTHOUGH IT WAS 1/4 FULL. UNABLE TO EXCEED 25 MPH DUE TO LITTLE/NO POWER. WAS TOWED TO AUTOPARTS STORE, CLEARED CODES, VEH RAN FINE FOR ABOUT 2 DAYS, THEN LOST POWER. TOWED HOME. LOOKED UP INFO ON INTERNET, FOUND RECALLS FOR FUEL PUMP. CALLED LOCAL CHEVY DEALERSHIP, INQUIRED ABOUT RECALL, WAS TOLD THAT RECALL WAS ONLY ON HALF-TON SUBURBANS AND SINCE MINE IS 3/4 TON, IT WAS NOT COVERED BY RECALL. I REPLACED FUEL MODULE MYSELF AND DISCOVERED THE COVERING OF THE WIRES INSIDE THE FUEL MODULE ASSEMBLY HAD MELTED, ALLOWING THE BARE WIRES TO RUB AGAINST EACH OTHER, SHORTING OUT THE FUEL DELIVERY SYSTEM (WHICH LIKELY CAUSED THE BLOWN FUSE TO BEGIN WITH). I AM VERY UPSET THAT MY SUBURBAN IS NOT COVERED BY THE RECALL, EVEN THOUGH IT IS VIRTUALLY THE SAME SYSTEM AS WHAT IS IN THE THE 1/2 TON SUBURBANS, AND THE SAME PROBLEM EXISTS (AS EVIDENCED BY NOT ONLY MY OWN EXPERIENCE, BUT MANY OTHERS' EXPERIENCES AS WELL). I AM EXTREMELY DISTURBED THAT UNDER THE RIGHT CIRCUMSTANCES, FUEL VAPORS, PLUS SPARK OF BARE WIRES TOUCHING, COULD IGNITE, CAUSING FIRE AND/OR EXPLOSION. POSSIBLY WITH MY FAMILY OF SIX IN THE VEHICLE.

WIPER MOTOR FAIL. 2001 SUBURBAN 6.0L V8. WIPER MOTOR FAIL. THE WIPER MOTOR IN MY TRUCK ALWAYS FAILS. THE LAST TIME IT FAILED WAS SEPTEMBER 27TH 2010 DURING A HEAVY RAIN STORM. TO MAKE A LONG STORY SHORT I ALMOST RAN OVER A PEDESTRIAN, AND ENDED UP ON THE SIDEWALK. (TECHNICALLY THAT IS A CRASH) THE WIPER MOTOR JUST STOPPED WHILE IT WAS RAINING. LAST YEAR DURING HEAVY SNOW THE MOTOR FAILED AGAIN. I HAD TO PULL OVER FOR AN HOUR UNTIL THE STORM WAS OVER. NOT TO MENTION NUMEROUS OTHER TIMES AS WELL. THIS MOTOR FAILS A LOT I LOST COUNT. THE EVENTS THAT LEAD UP TO THE FAILED WIPER MOTOR ARE RAIN , SNOW, SLEET, SOMETIME THE MOTOR FAILS DURING A SUNNY DAY AND NO MOISTURE IN THE AIR OR FAILED JUST TO CLEAN YOUR WINDOW. NOTHING HAS BEEN DONE TO CORRECT THE WIPER MOTOR FAILURE BECAUSE IT'S TOO EXPENSIVE FOR ME; GENERAL MOTORS SHOULD FIX THIS SERIOUS PROBLEM BEFORE SOMEONE GET KILLED. *TR

I HAVE SUBURBAN 2001, THE REAR WINDOW (TAILGATE WINDOW) GLASS SEPARATED FROM THE HINGES SUDDENLY. THIS IS COMMON PROBLEM IN GM SUBURBANS AND I AM AFRAID THIS MAY RESULT IN A SERIOUS ACCIDENT AS THE TAILGATE WINDOW MAY SEPARATE, FLY OFF AND HIT SOMETHING. I AM NOT SURE IF THE WINDOW WILL FLY OFF, MINE WAS HANGING FROM ONE HINGE UNTIL I CORRECTED IT. *TR

PER NHTSA CAMPAIGN ID#07V521000, THE 2001 CHEVROLET SUBURBAN 2500 IS SUBJECT TO THIS RECALL BY GM. I HAVE EXPERIENCED THE SAME DESCRIBED PROBLEM OF VEHICLE ENGINE STALLING AND NOT OPERATIVE WHILE TRAVELING ON THE ROAD. I HAVE CONTACTED BOTH GM AND GM'S LOCAL AUTHORIZED DEALERSHIP IN CONCORD, CALIFORNIA. BOTH REFUSED TO HONOR THIS RECALL. PLEASE HELP BEFORE AN ACCIDENT OCCURRED. THANK YOU. *TR

I HAVING A PROBLEM WITH MY 2001 CHEVY SUBURBAN 1500 REGARDING THE ABS BRAKE MODULE CONTROL THAT FAILED, AFTER RESOURCE ITS LOOKS LIKE MANY THOUSAND OF 2000-2002 HAVE THE SAME PROBLEM , I CALL GM AND THEY SAYING THEIR IS NO RECALL. IF YOU CHECK THAT ISSUE WOULD YOU THINK IT SHOULD BE A RECALL ? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ANTI-LOCK BRAKES ENGAGE AT LOW SPEEDS OVER 50% OF THE TIME. STARTED IN EARLY DECEMBER. WE HAD EARLY SEASON SNOWS LAST YEAR. PASSED INSPECTION LATER THAT MONTH. HAD IT IN FOR SERVICE AT LOCAL AUTO SERVICE BUSINESS & NO OBVIOUS ISSUES. TALKED TO CHEVY DEALER AND THEY SAID THEY'D HAVE TO INVESTIGATE. RECENTLY FOUND GM RECALL NO. 05068, BUT CHEVY SAYS I DON'T HAVE IT. I'VE RUN OVER CURBS AND BEEN CLOSE TO HITTING PARKED CARS & WALLS. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE ANTI-LOCK BRAKE SENSOR WOULD INDEPENDENTLY ENGAGE WHEN DRIVING AT SPEEDS OF AT LEAST 10 MPH. WHEN THE ABS WOULD ACTIVATE IT WOULD CAUSE AN UNUSUAL INCREASE IN STOPPING DISTANCE. THE CONTACT PREVIOUSLY RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC: ANTI-LOCK) BUT WAS ADVISED BY THE DEALER THAT BECAUSE THE VEHICLE WAS OVER 100,000 MILES, THEY WOULD NOT MAKE REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 113,000.

HUGE SAFETY ISSUE !!!!!! 1. VEHICLE MAINE STATE INSPECTION 2. TWO REAR AND SIDE BRAKE LINES ARE SEVERELY RUSTED AND WILL NOT PASS STATE INSPECTION 3. MUST REPLACE BRAKE LINES; SIDE LINE REPLACEMENT REQUIRES REMOVAL OF 30 GALLON GAS TANK! HAVE NOT YET REPAIRED. *TR

2001 SUBURBAN K2500 COMPLETE LOSS OF BRAKING DUE TO CORROSION AND RUPTURE OF BRAKE LINES FROM MASTER CYLINDER TO ABS UNIT AND FROM ABS UNIT TO RIGHT FRONT WHEEL. THIS IS THE SAME PROBLEM AS CURRENT INVESTIGATION PE10010. *TR

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN HE NOTICED THAT THE FUEL GAUGE DISPLAYED EMPTY WHICH WAS INACCURATE; HOWEVER, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO HIS RESIDENCE. THE CONTACT REPAIRED THE VEHICLE BY REPLACING THE FUEL PUMP MODULE. THE FAILURE MILEAGE WAS APPROXIMATELY 69,000. UPDATED 08/24/10 *LJ THE CONSUMER STATED THE ELECTRICAL WRING IN THE FUEL PUMP MODULE HAD MELTED THE INSULATION AND WAS CAUSING A SHORT IN SEVERAL PLACED. UPDATED 08/24/10