CHEVROLET Complaints

The brake booster vacuum pump went out in my car it broke which caused hard breaking while driving vehicle. When the brake booster vacuum pump broke a piece of it damage my camshaft as well as my timing chain in my motor.

Description: On June 23, 2025, I was involved in a traffic collision in Las Vegas, Nevada. According to the police report, another driver failed to yield while exiting a private driveway and struck the front of my vehicle while I was stopped in the center turn lane preparing to turn left. As the vehicle entered my lane, I pressed the horn continuously in an attempt to alert the driver. My right hand was positioned on the horn pad in the center of the steering wheel. At the moment of impact, the driver airbag deployed while my hand remained on the horn pad. I immediately experienced severe pain in my right wrist. Medical evaluation confirmed fractures of the distal radius and ulna requiring surgical fixation with plates and screws. My purpose in submitting this report is to document a potential safety concern involving the interaction between horn activation and airbag deployment. Activating the horn during an imminent collision may be a foreseeable defensive maneuver, which could place the driver’s hand directly over the airbag module at the moment of deployment. I respectfully submit this information for safety review in case similar incidents have been reported.

Power Steering and stabilitrack keeps popping off on my dashboard. Took it to service at Chevy dealer but they couldn’t seems to find any problem even when they see the issue.

Suddenly lost all power steering, then warning power steering attention, no control for steering, very dangerous, couldn't drive vehicle. Took independent car repair to fix. $5k repair to fix problem. Should not happen to vehicle.

the car has a grinding that i am not sure where it is coming from, it maybe coming from the wheel and it also has a battery problem

The contact owns a 2024 Chevrolet Silverado 6500. The contact stated that a month after the vehicle was repaired under NHTSA Campaign Number: 25V390000 (Service Brakes, Hydraulic); the contact became aware that the brake motor was constantly engaged. The contact stated that upon disconnecting the brake pressure switch, it was discovered that the brake switch connector was covered with brake fluid. The dealer was notified of the failure and informed the contact the recall remedy only involved the replacement of the brake pressure switch wiring harness, and the brake switch replacement was not covered. The contact was referred to the manufacturer for assistance. The manufacturer was notified of the failure, and a case was filed. The contact was referred to the dealer for additional assistance. The vehicle was taken to the dealer, where it was confirmed that the brake switch replacement was not covered by the recall. The vehicle was not repaired. The manufacturer was called back and referred the contact to the NHTSA Hotline to report the failure. The contact stated that the recall remedy had fail to correct the failure. The failure mileage was approximately 46,000.

The truck engine light came on and was not able to be driven very far without stalling. Took it for repair and 2 valve lifters were bad. We had to pay for replacement ourselves. This happened at 41,786 miles. This happened again at 46,000 miles because of faulty GM parts and they needed to be replaced again. The parts were under warranty so there was no charge. This happened again at 59,000 miles and now both side lifters are bad and mechanic suggested engine replacement since he is sure this will happen again. Now it’s costing us 15,300 to repair it and GM/Chevrolet is not helping or do they care! First incident was in April 2023, second in November 2023 and now in December 2025.

While driving 65mph, the vehicle’s engine shut off, a ‘Reduced Acceleration Drive with Care’ message showed up and I had to coast to the side of the freeway. Engine would not restart and dealer confirmed a piston contacted a valve and a new engine is needed.

Car uses excessive amount of oil! We have had the timing replaced and now it’s stating the P0420 catalyst system efficiency below threshold bank 1.

The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 5k miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 10-14 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.