CHEVROLET Complaints

Engine failed on interstate while pulling my RV. Almost had a bad wreck due to this happening. This is the known 6.2L engine failure issues. Had to have motor replaced by Chevrolet and had to pay out of my own pocket.

Vehicle was making a very loud humming noise at 73 mph. After returning to the dealership they found that the bearings in the rear end house had destroyed themselves causing internal damage to the housing and the entire rear end now needs to be replaced.

Vehicle taken into dealership for maintenance, after car received cars system software malfunctioned. Display screen went black and states "return to dealer. failed update" due to this issue I don't have access to car settings with most features are unavailable. All warning chimes such as turn signals, park sensor warnings, lane departure warning are inoperable. Had drove miles with turn signal on causing traffic disruption on neighboring lanes.

The Turbo Charger failed suddenly without a prior display of a warning light and was replaced by an independent service center in June 2025. I received a letter from GM in November 2025 stating there was a known "condition" that may cause the Turbo Charger to need replacing but a recall was not issued. On 1/22/26 the vehicle suddenly went into "Limp Mode" while driving. The Throttle Body Injection Unit, Engine Coolant Water Outlet, and Coolant were replaced. The coolant had been topped off on 1/20/26. On 1/27/26 the vehicle began shuddering and lost power while I was driving on the highway. As I attempted to get to a gas station off of the next exit, it intermittently lost power and began smoking under the hood. It seemed to be overheating but there is no temperature gauge on the display. I had it towed to my service center again. At that time, four spark plugs and an ignition coil were replaced. After these repairs, I have continued to have significant power issues, the engine warning light has come back on, and the "Service Brake Assist" warning light has come on. Additionally, the instrument panel frequently goes blank or displays what can best be described as "static" and the A/C and heat do not work, making it difficult to defrost and defog the windshield. The wiper fluid will not come out even though the reservoir is full. Due to prohibitive diagnostic fees at the dealership, which I was told would not be waived or reimbursed, I have continued to utilize my independent service center to maintain basic drivability. My service center has advised me that the engine may fail completely within a short time frame. I have reported these issues to the manufacturer and have been assigned a case number. I'm concerned that this may indicate a potential safety defect and/or premature engine failure affecting my vehicle and others of the same model. I'm submitting this complaint for documentation and safety tacking.

as i was driving down the highway the engine warning light came on and engine quit running immediately so i began to pull off of the road but couldn't get all the way off so it was sticking out on the highway i did put in park and checked oil level which was good, so i was going to try to push vehicle off the road more because there was semi-trucks and other vehicles going by at a high rate of speed but the shifter would not shift unless vehicle was running. so for the safety of my wife and myself we had to stand off into the ditch for about an hour waiting for help hoping no one slammed into our vehicle and there was some close calls. after getting the truck back to my home i then trailered it to a repair shop called Eagle Chevrolet in Chadron Nebraska where i was told the bearing in the engine had spun and it is very common on the engine in my truck which is an 6.2 L87 ENGINE and there is recalls on the same engine but only for the year 2022 and up and mine is a 2019 and was given a quote for Repair which is over $10,000.00

The contact owns a 2012 Chevrolet Impala. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. The contact stated that the steering wheel seized and became difficult to turn. There was no warning light illuminated. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 201,000.

The contact owns a 2021 Chevrolet Silverado 1500. While driving approximately 30 MPH, the contact heard an object being dragged underneath the vehicle. There were no warning lights illuminated. The contact pulled over and heard an abnormal clicking sound coming from the vehicle before the vehicle stalled. The contact was unable to restart the vehicle, and the vehicle was towed to an independent mechanic. The mechanic diagnosed the vehicle and determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.

In Michigan- stopped for lunch - used remote start as always when it’s cold. Came out and got back on the road and about ten minutes later a loud bang and the back window shattered. A quick google said it’s a known problem on this model with the power sliding window due to the rear defrost and there’s a recall for Canada and 10 us states but Illinois isn’t covered. Hard to understand when it’s the same part number. GM customer service rep also stated they won’t cover it when we called the corporate office. If we’d been alerted we would’ve disabled the rear defrost long ago. Frightening to know it’s a fire hazard and what if we’d had children in the back.

There is a recall number 09184C that only pertains to certain states but I live in a wet state also not listed and the carpet under my seat held moisture and now my airbag control module totally disintegrated from being in moisture for so long, they won't accept my truck in for inspection or repair

I have a 2019 Chevrolet Silverado LT 1500 with only 19K Miles. When I brought this vehicle I was having problems with hearing a loud clunking noise coming from the rear of the Vehicle. Every Time I Stop at a red light, stop at a stop sign, yield at a yield sign, and slow down to turn in my driveway I can hear this clunking noise coming from the rear of the vehicle. If someone is riding in the backseat of the vehicle, they can feel the clunking noise every time I hit the brakes or slow down. After doing some research I honestly believe it’s the drive shaft that is on my vehicle that is causing this issue. Also, my vehicle does a hesitation when trying to accelerate on the gas pedal, which the drive shaft can cause this issue as well. There is a recall against this issue (Drive Shaft) but my Vin Number doesn’t call for a recall, I believe my vin number was missed in this recall. This is very dangerous because my Drive Shaft can drop beneath my vehicle while driving on the roads or highways and can cause my Truck to loose control and get into a serious accident or fatal accident. All I want is to have the Chevrolet Dealership to repair my Drive Shaft for free, because Chevrolet states that they will fixed all the drive shaft that is on recall on there time and the customer doesn’t have to pay anything. Please follow up on this serious matter. I don’t feel safe driving my truck anymore, so I keep it parked in my garage. PS : I took my truck in several times to three Chevrolet Dealership when I had full warranty’s and each Dealership told me that my truck is fine, I just have to drive it because it’s still new and this is not a problem at all.