1992 DODGE GRAND CARAVAN Complaints

ABS BRAKE ACTUATOR MOTOR FAILURE. FOR THE THIRD TIME THE ABS MOTOR HAS FAILED. CHRYSLER CLAIMS THE PART IS NO LONGER SERVICED AND WILL NOT HONOR THE LIFETIME WARRANTEE 96V099000. THE PART IS AVAILABLE IN THE AFTERMARKET FOR ABOUT $350.00 AFTER A NUMBER OF CALLS TO FIAT CHRYSLER THEY WOULD ONLY OFFER TO BUY THE VEHICLE FROM ME FOR $300.00 WHICH IS THE LOWEST VALUE TO BE HAD BY KBB.

TL*THE CONTACT OWNS A 1992 DODGE GRAND CHEROKEE. THE DEALER STATED THAT THEY HAVE BEEN MAKING THE REPAIRS PER RECALL 96V099000 SERVICE BRAKES, HYDRAULIC: ANTILOCK SINCE SEPTEMBER 25, 2009. SHE WILL CONTACT THE MANUFACTURER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 172,104.

I HAVE A 1992 DODGE GRAND CARAVAN MINI VAN. FRONT WHEEL DRIVE WITH A 3.3 ENGINE. EVERY TIME THE SERPENTINE BELT GETS THE SLIGHTEST AMOUNT OF MOISTURE ON IT...IT COMES OFF! AT LEAST ONCE A MONTH WHICH REQUIRES PAYING A PRO TO REINSTALL IT. THE BIGGEST PROBLEM IS THAT ONE LOSES ALL POWER STEERING NOT MENTION ALL FUNCTIONS CONTROLLED BY THE BELT! THE LAST TIME THIS HAPPENED TO ME WAS IN RAIN ON A BUSY TWO LANE HIGHWAY AND I ALMOST FLIPPED THE VAN! IT HAPPENS WITHOUT WARNING AND WITH IMMEDIATE LOSS OF POWER STEERING. I HAVE RELOCATED THE TENSIONER AND PULLEY ASSEMBLY WITH NO SATISFACTION. THE PROBLEM IS THAT CHRYSLER DESIGNED THESE MINI VANS WITH NO SHIELDS INSTALLED TO TURN MOISTURE FROM THE ENTIRE PULLEY SYSTEM (TOP OR BOTTOM) AND THE PULLEYS HAVE NO 'LIP' TO HOLD THE BELT IN PLACE ALLOWING IT TO SLIDE OFF WHEN WET! IS THERE NO WAY CHRYSLER CAN BE FORCED TO INSTALL AN OEM PRODUCT OR SHIELD TO PREVENT THIS AND SAVE LIVES? THIS IS A VERY COMMON PROBLEM IN ALL CHRYSLER MINI VANS FROM APPRX. 1992-2007. *TR

TL*THE CONTACT OWNS A 1992 DODGE GRAND CARAVAN. WHILE DRIVING 30 MPH, THE CONTACT STATED THAT THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE BRAKE PEDAL WAS DIFFICULT TO DEPRESS. A MECHANIC STATED THAT THE ABS NEEDED TO BE REPLACED. THE DEALER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 96V099000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK). THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 152,513.

TL*THE CONTACT OWNS A 1992 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE DRIVER'S SEAT BELT BUCKLE DISLODGED WHICH CAUSED THE RELEASE BUTTON TO STICK INSIDE THE COVER. THERE IS A SAFETY RECALL FOR THE SEAT BELTS: FRONT: BUCKLE ASSEMBLY (NHTSA CAMPAIGN ID # 97V148000) HOWEVER, THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED. THE CURRENT MILEAGE WAS 223,087 AND THE FAILURE MILEAGE WAS UNAVAILABLE. THE PURCHASE DATE WAS UNAVAILABLE.

DT*: THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, EXTREME PRESSURE ON THE BRAKE PEDAL WAS NEEDED TO STOP THE VEHICLE. THERE WAS NO WARNING PRIOR TO THE INCIDENT THAT THE BRAKES WERE FAULTY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER DETERMINED THAT THE HYDRAULIC CONTROL UNIT FAILED. THE VEHICLE WAS NOT REPAIRED DUE TO THE UNAVAILABILITY OF PARTS. THERE IS A NHTSA RECALL # 96V099000 WHICH PERTAINS TO THE ANTILOCK BRAKES. THE VEHICLE WAS REPAIRED BY THE PREVIOUS OWNER BASED ON THE RECALL, BUT THE PROBLEM RE-OCCURRED.*AK

DT: THE CONTACT RECEIVED NHTSA RECALL CAMPAIGN 96V099000 CONCERNING ANTI LOCK BRAKES. THE RECALL ONLY OFFERED A PARTIAL REMEDY. IN ORDER TO COMPLETELY REPAIR THE PROBLEM ADDITIONAL PARTS HAD TO BE REPLACED AT THE CONTACT'S EXPENSE. ACCORDING TO THE RECALL, AN EXTENDED OR LIFETIME WARRANTY WOULD BE OFFERED ON OTHER ANTI-LOCK COMPONENTS. THE DEALER AND MANUFACTURER STATED THE RECALL WAS COMPLETED CORRECTLY, AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REMAINING EXPENSE. *AK

DT: THE CONTACT STATED RECALL 96V099000 REPAIRS WAS DONE ON THE ABS BRAKES IN 2004. HOWEVER, HE WA SHAVING A FAILURE. THE ABS LIGHT ILLUMINATED ON THE DASHBOARD. UPON INSPECTION BY THE SERVICE DEALERSHIP THE ABS CONTROLLER FAILED. HE HAS BEEN IN CONTACT WITH THE MANUFACTURER. THEY CLAIMED THE PART IN QUESTION WAS NOT COVERED BY THE RECALL. NO REPAIRS HAVE BEEN MADE.*AK

DT: 1992, DODGE, GRAND CARAVAN, INTERMITTENT BRAKE FAILURE, NO POWER ASSIST, THE BRAKES WILL NOT STOP VEHICLE QUICKLY ENOUGH. ALSO, RIGHT FRONT BRAKE CALIPERS FAILED AFTER GOING ABOUT 20 MILES IN STOP AND GO TRAFFIC. CONSUMER ALREADY REPLACED THE HYDRAULIC BRAKE LINE AND THE CALIPERS. BUT IT DID NOT SOLVE THE PROBLEM, WHICH ONLY LEFT THE BRAKE ACTUATOR PISTON ASSEMBLY AND PUMP MOTOR ASSEMBLY. CONSUMER TOOK VEHICLE TO THE DEALER, AND DEALER COULD NOT SEE THE PROBLEM, DEALER SAID THAT IF THEY COULD DUPLICATE THE PROBLEM THEY WOULD FIX IT BECAUSE THE ACTUATOR PUMP AND ASSEMBLY MOTOR WERE STILL UNDER WARRANTY. THE INTERMITTENT BRAKE FAILURE WAS INCLUDED IN A RECALL 96V099000 CONCERNING ABS MODULE CONTROL FAILURE. THE PROBLEM WAS FIXED THEN. CONSUMER STATED THAT THE PROBLEM WAS INTERMITTENT SO THE DEALER WILL NOT FIX BECAUSE THEY COULD NOT DUPLICATE THE PROBLEM. *AK

THE CONSUMER WAS INVOLVED IN PAST RECALL 730 BY DODGE THAT WAS POORLY HANDLED. THE REAR HATCH ATTACHMENT BOLT WAS THE ITEM ON RECALL. THE CONSUMER HAD TAKEN THE VEHICLE IN FOR REPAIR IN JULY OF 1997 BECAUSE THE BOLTS HAD BROKEN, AND HAD THEM REPLACED. THEN THEY BROKE AGAIN IN AUGUST OF 1999. ON MAY 1, 2005 ONE OF THEM BROKE AGAIN, AND ALMOST BROKE HIS WIFE'S ARM. ON 5-3-2005, AND THE DEALER SAID THAT THE CAR WAS TOO OLD. THEY WOULDN'T FIX IT UNLESS THE CONSUMER PAID. THE DEALERS RESPONSE WAS INAPPROPRIATE. THE DEALER CHECKED WITH THE DISTRICTS OFFICE AND VALIDATED THAT IT WOULDN'T DO IT. ALSO, THE CONSUMER WAS INAPPROPRIATE. THE THIRD ISSUE WAS THE ADEQUACY OF THE RECALL ITSELF. THE FOURTH ISSUE WAS THAT THE DEALER JUST TOLD HIM THAT HE WOULDN'T FIX BOTH SIDES. *AK THE OIL PAN LEAKED AND THE SERPITINE BELT. RECALL CAMPAIGN#97V079000. *SC