2012 DODGE RAM 3500 Complaints

Driving my 2012 dodge ram 3500, just as I was crossing one of the busiest intersections in my town my truck lost all power and dropped from 35mph to 5 mph. Barley made it acrossed and pulled over. As soon as I pulled over the engine light comes on, checked code, and U010C lost coms with turbo actuator comes up. Turned truck off and rest code and everything back to normal. About a week later it happened again, luckily not as busy of a spot. Called dealer and soonest appointment was in April. Meanwhile I look up code and see hundreds of post for same issue, bad actuator replace. 28 years as a diesel mechanic for the military, so I found the part online and ordered. Replaced the actuator, drove about 50 miles, light comes back on. Finally get my appointment with dealer and they say my turbo is bad, they want $8k to fix. I ordered the turbo and replaced it myself along with another actuator, test drove. Light still comes on but have not lost power yet?? Dealer is not helping. This is a major issue that is all over the internet! The truck just goes to limp and your in the middle of traffic. If this has not caused an accident it’s only a matter of time before it does. The dealer ship just wants to replace big parts for lots of money. I’m already $2500 into this and still having an issue

The contact owns a 2012 Dodge Ram 3500. The contact stated that while driving 70 MPH, the steering wheel was loose. The contact pulled over and discovered that the steering shaft had detached. The vehicle was towed to an independent mechanic, who repaired the steering shaft. The manufacturer was not made aware of the failure. The failure mileage was approximately 151,000.

This truck has had to have several high temp burnoffs because of failures in the EGR and Carbon build up. The recent recall for Rams does not cover the 2012, and began at 2013, however, we are experiencing the same exact issues with the same type of system. In addition, we have had repeated airbag issues due to the positioning of the cockspring and wiring getting choked out.

Drivers side rear wheel broke loose from hub and bounced into the opposing lane of traffic.

The contact owns a 2012 Ram 3500. The contact stated that while that while the vehicle was in for service, the independent mechanic discovered fuel leaking from the fuel filter heater assembly. The contact was advised that the fuel filter heater assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 202,000.

The wireless ignition module loses connection internally and the truck will lose power while driving. It usually happens when hitting a small bump and the key in the ignition moves. Truck loses electrical power which shuts the engine off which means loss of power steering and brakes.

The contact owns a 2012 Ram 3500. The contact stated that while driving uphill at 55 MPH, the contact became aware that the vehicle was not exceeding 55 MPH. The contact stated that the check engine warning light was illuminated. The contact continued driving to the destination. The vehicle was parked; however, upon inspection, the contact became aware that there were damages on top of the front driver’s side ball joint, the rear driver’s side axle leaf spring shackle, and the driver’s side overload spring. Additionally, there were metal fragments found in the engine oil, and a diagnostic scan retrieved DTC: P0087, P0471, U029D. The vehicle was taken to a local dealer where it was inspected; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 215,000.

Driving vehicle and lost the ability to steer. The inner drag link tie rod broke at pitman arm.

The key loses contact and vehicle shuts off at random times. The vehicle is not able to be steered when shut off happens. Could very easily cause an accident. It has happened driving on the highway at highway speeds and also on county roads driving slower. There are no warning messages. I have inspected it myself and believe the ignition box needs replaced

The contact owns a 2012 Ram 3500. The contact stated that while reversing at approximately 1 MPH, the front driver’s tie rod fractured and put a whole in the aluminum wheel. The contact who works as an independent mechanic completed the repair. The contact stated that a recall repair for the driver’s side outer tie rod had been completed in July 2019. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.