1997 FORD E-150 Complaints

I TOOK MY 1997 FORD E150 CONVERSION VAN IN FOR SERVICE, WITH THE COMPLAINT OF THE STRONG SMELL OF GASOLINE, WHICH SEEMS TO BE WORSE AFTER I FILL IT UP. THE TECHNICIAN STATED IN HIS REPORT THAT THE TOP OF THE TANK WAS WET WITH GASOLINE AND HE SUSPECTS THAT IT IS CRACKED. HE ALSO TOLD ME A SEARCH CAME UP WITH A FORD RECALL FOR 1997 E150 VANS WITH THIS ISSUE. I CONTACTED MY FORD DEALER AND WAS TOLD THERE IS NO SUCH RECALL FOR MY VAN. I LOOKED ON YOUR WEB SITE AND FOUND RECALL #01V114000, WHICH SEEMS TO PERTAIN TO MY VAN. I AM AFRAID TO DRIVE THE VAN, WITH GAS LEAKING AND THE DEALER TOLD ME THE TANK WOULD BE $400 + LABOR TO REPAIR. *JB WHAT NOW? THANK YOU FOR YOUR HELP SINCERELY, BRIAN HOLGATE. *JB

THE PARKING CABLE WAS DESIGNED TOO SHORT, AND WAS INSTALLED INCORRECTLY. *JB

AFTER CONSUMER FILLED THE VEHICLE FUEL TANK WITH GAS THEY SMELT GAS FUMES. CONSUMER TOOK VEHICLE TO DEALERSHIP FOR SERVICE. DEALERSHIP INDICATED THAT THE FUEL TANK HAD A LEAK. PLEASE PROVIDE MORE DETAILS. TS

WHILE REFUELING VEHICLE CONSUMER NOTICED FUEL LEAKING FROM UNDERNEATH VEHICLE. UPON CLOSER INSPECTION CONSUMER SAW FUEL TANK WAS CRACKED. THERE IS RECALL O1V014000, BUT THIS VEHICLE IS NOT AFFECTED DUE TO VIN. *AK

WHILE DRIVING VEHICLE WOULD NOT GAIN SPEED, DEALER DETERMINED THAT CATALYTIC CONVERTER HAD MELTED ON ONE SIDE, AND MASS AIRFLOW SENSOR WAS REPLACED.*AK

GAS TANK IS LEAKING FLUID AND COULD CAUSE A FIRE. CAUSE UNKNOWN. DEALER NOTIFIED.*AK

EXHAUST IS SMOKING BAD, SERVICE ENGINE SOON LIGHT HAS ILLUMINATED, DEALER STATES ENGINE NEEDS REPLACED, CONSUMER STATES THERE IS A TSB REGARDING THIS, TSB 99-20-7. *SLC

VEHICLE IS STALLING WHEN BACKING UP AND COMING TO A STOP. THIS BECAME PROGRESSIVLY WORSE. DEALER CANNOT REMEDY PROBLEM. *AK CONSUMER ALSO STATED THAT THE VEHICLE STALLED WHILLE PULLING OUT INTO THE INCOMING TRAFFIC. VEHICLE WAS HOOKED UP TO A MONITORING DEVICE WHICH HAD DETECTED A FAULTY E DPFE SENSOR (PROBLEM STILL OCCURS, EVEN THREE WEEKS LATER). CONSUMER WAS INSTRUCTED TO TAKE VEHICLE BACK THE FOLLOWING WEEK (AUG 19TH). *SCC

WHILE HAVING TIRES REPLACED MECHANIC NOTICED THAT UPPER AND LOWER BALL JOINTS WERE DEFECTIVE, CAUSING PREMATURE TIRE WEAR. *AK *JG

CABLE WHICH HOLDS THE SPARE TIRE FELL TO THE GROUND. *AK CONSUMER STATES THAT THE CABLE BROKE AT THE WELD JOINT. *SLC