1997 FORD E-150 Complaints

The contact owns a 1997 Ford E-150. The contact stated that after parking the vehicle in a parking lot, the contact leaned over to the passenger’s side to pick up the cell phone. The contact stated that after sitting back straight in the seat, the air bag deployed unintendedly and without impact. No warning lights were illuminated. The contact’s eyes and jaw were injured and required medical attention. The contact’s vision became blurry but has since started to improve. The vehicle was not taken to a local dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The contact owns a 1997 Ford E-150 equipped with Milestar Tires, Tire Line: Grantland, Tire Size: 235/75/R15, DOT number: TB20R028. The contact stated while driving approximately 45-50 mph, the tires were bouncing. The contact stated upon checking the tires, his son noticed that the tires were cracked and had holes. The vehicle was taken to an independent mechanic who informed the contact that the tires were defective. The tires were not replaced. The manufacturer was not made aware of the failure. The approximate vehicle mileage was 150,258. The approximate tire failure mileage was 800.

MY HUSBAND HAD JUST STARTED UP HIS E150 ECONOLINE VAN PULLING OUT OF THE DRIVEWAY AND THE AIRBAG JUST DEPLOYED. THERE WAS NO REASON HE WAS NOT IN ANY ACCIDENT HE DID NOT RUN OVER ANYTHING HE DIDN'T HIT ANYTHING. AND NO ONE CAN TELL ME WHY THIS HAPPENED. IF HE HAD BEEN ON THE INTERSTATE THAT HE DRIVES EVERY DAY HE COULD HAVE DIED OR KILLED SOMEONE.

WHILE BACKING OUT OF TIGHT PARKING SPOT 9/1/17, WITH MULTIPLE TURNS OF THE WHEEL, TURNED WHEEL ONE LAST TIME TO PULL FORWARD INTO PARKING SPOT DRIVE AREA BUT AT THAT POINT, HEARD A CLUNK AND ALL STEERING CONTROL WAS GONE. CALLED FOR A TOW. TOW TRUCK DRIVE ASSISTED IN THE DIAGNOSIS NOTING THAT THE STEERING BOX HAD DISCONNECTED FROM VAN FRAME RENDERING STEERING WHEEL CONNECTION LINES USELESS. HAD VAN TOWED HOME. AFTER ONLINE READ, LOOKED AT FRAME THROUGH LEFT FRONT TIRE ACCESS AND SAW THE 3 BOLTS WE READ ABOUT. GRABBED THE TOP BOLT AND IT CAME RIGHT OUT. SAME WITH SECOND BOLT. LAST (THIRD) BOLT WAS A BIT JAMMED DUE TO THE STEERING BOX DROP, BUT ALL 3 BOLTS HAD SHEARED AND ALL STEERING WAS LOST. HAD WE NOT STOPPED AT A STORE FOR LABOR DAY HOLIDAY SUPPLIES ON OUR WAY TO CAMPSITE, WOULD HAVE LOST STEERING SOMEWHERE ELSE, LIKE ON THE FREEWAY, POSSIBLY DURING A SIMILAR TURN SITUATION. WE COULD HAVE KILLED OTHERS OR OURSELVES. FOUND THAT THIS FORD E150 STEERING BOLT ISSUE HAS ALREADY BEEN DOCUMENTED. WHY WHEN WE HAD THE VAN SERVICED AND SAID THE STEERING HAD FELT "LOOSE", WHY DIDN'T ANY MECHANIC FIND THIS POTENTIAL?? UN-EXCUSABLE SITUATION. OUR PARENTS, CHILDREN AND GRANDCHILDREN ARE CURRENTLY DEPENDENT ON US. HAD WE DIED DUE TO LOSS OF STEERING, WHAT A NIGHTMARE THAT WOULD HAVE BEEN. GRANTED, THE 20-YR-OLD VAN IS RUSTY, BUT WE DIDN'T KNOW TO LOOK UNDER THE LEFT FRONT TIRE AREA AND APPARENTLY, MULTIPLE (NON-FORD DEALERSHIPS) MECHANICS DIDN'T EITHER !!

DRIVING ON BESTBUY PARKING LOT, WENT OVER A SPEED BUMPER HEARD A LOUD CLUNK COMING FROM DRIVER SIDE FRONT TIRE. DROVE HOME, STOPPED VAN, GOT HELP, WHILE TURNING THE STEERING TO LEFT, LOUD METAL CLUNK FROM THAT DRIVER SIDE, HELPER ON FLOOR NOTICED THAT BOTTOM BOLT HOLDING POWER STEERING BOX IS GOING IN AND OUT, RUSTED ON FRONT AND BACK OF FRAME, THIS BOX SHOULD BE MOUNTED ON REINFORCED BRACKETS FRONT AND BACK OF FRAME THEN WELDED TO FRAME TO PROTECT OCCUPANTS FROM POSSIBLE SEPARATION OF BOX AND FRAME WITH CONSEQUENT LOSS OF CONTROL AND POSSIBLE ACCIDENT (COULD BE FATAL WHEN DRIVING THE VEHICLE). SO, WITH THE ENGINE ON, IN PARK, IF THE STEERING IS TURN TO THE LEFT, DRIVER WILL FEEL AND HEAR THE CLUNK. *TR

I HAVE JUST RECENTLY LOST THE REAR SHOCK MOUNT DUE TO TOO EXTREME RUST OF THE FRAME, FORD DOES NOT MAKE A REPLACEMENT PART FOR THIS. AND THE FRAME IS NOW CRACKING IN TWO. CONTACTED THE DEALER AND WAS TOLD TO BUY A NEW FRAME REALLY. WELL IT WILL NOT BE LONG TILL THE OTHER SIDE GOES. OR MY FRAME BREAKS IN TWO AND CAUSES SERIOUS INJURY TO ME OR OTHERS. THIS IS A COMMON PROBLEM WITH THIS YEAR TRUCK AND FORD DON'T SEEM TO CARE. IF THE FRAME NEEDS REPLACED IT SHOULD BE AT THEIR EXPENSE NOT MINE RECALL TIME. THEIR ARE HUNDREDS OF THOUSANDS STILL ON THE ROAD I AM NOT THE ONLY ONE. *TR

TL* THE CONTACT OWNS A 1997 FORD E150 VAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE SPARK PLUG BECAME DISENGAGED FROM THE ENGINE. THE VEHICLE STARTED MAKING A LOUD NOISE WITHOUT WARNING. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE HEAD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 280,000.

THE VEHICLE HAD BEEN PARKED FOR ABOUT 1 HOUR WHEN AN EXPLOSION INCURRED WHICH RESULTED IN THE TRUCK BURNING UP. THE MOTOR AREA, FRONT WHEELS AND COMPLETED CAB WERE DESTROYED. GAS TANK DID NOT BLOW UP. *TR

THIS IS THE EXACT SAME SITUATION OTHERS HAVE EXPERIENCED ON NHTSA RECALL CAMPAIGN NUMBER 01V114000 RELATING TO CRACKS/LEAKS TO THE 'MID SHIP' STYLE FUEL TANK. MY VAN IS A 1997 E-150 CONVERSION VAN. UNFORTUNATELY, I AM IN THE SAME SITUATION AS MANY OTHERS IN THE FACT THAT FORD MOTOR COMPANY DOES NOT ACKNOWLEDGE MY PARTICULAR VIN NUMBER IS AFFECTED IN THIS RECALL. THERE HAVE BEEN A NUMBER OF OTHER INCIDENTS REPORTED WITH VEHICLES MYSTERIOUSLY CATCHING ON FIRE FOR UNKNOWN REASONS. VERY DISTURBING THAT A MANUFACTURER WOULD NOT AGREE TO REPLACE A LEAKING/DAMAGED FUEL TANK. *TR

WHILE TRAVELING ON VACATION 600 MILES FROM HOME I EXPERIENCED A WELL KNOWN FAILURE TO FORD TRITON ENGINE OWNERS KNOWN AS A SPARK PLUG EJECTION FAILURE. I WAS TRAVELING @ 65 MPH AND UP TO THE FAILURE THE ENGINE WAS RUNNING NORMAL THERE WERE NO ABNORMAL SOUNDS. AT THE TIME OF THE FAILURE IT SOUNDED AS IF THE EXHAUST OR THE INTAKE WAS COMING APART. I PULLED OVER ON THE SIDE OF THE HIGHWAY AND REMOVED THE DOGHOUSE AT THE REAR OF THE ENGINE TO DISCOVER THE RIGHT BANK AND 2ND CYLINDER FROM THE REAR HAD EJECTED THE SPARK PLUG AND DESTROYED THE IGNITION COIL. I UNPLUGGED THE IGNITION COIL AND THE POWER CABLE FROM THE FUEL INJECTOR FROM THAT CYLINDER AND NURSED THE VAN TO A FRIENDS HOUSE 40 MILES AWAY WHICH TOOK OVER 3 HOURS. I CALLED SEVERAL FORD DEALERS TO EXPLAIN WHAT HAPPENED AND THEY FINISHED THE STORY FOR ME, THEY SAID THEY HAVE SEEN THIS PROBLEM SEVERAL HUNDRED TIMES AND THE FIX WOULD COST $1000.00 PER CYLINDER NEEDING REPAIRED. THIS IS A KNOWN FORD TRITON FLAW AND SHOULD BE ADDRESSED BY FORD WITH A RECALL. THIS COULD BE A SAFETY ISSUE BECAUSE WHEN THE SPARK PLUG LET GO THERE WAS A EXTREME LOSS OF POWER IF IN HEAVY TRAFFIC THIS COULD CAUSE A ACCIDENT, AND THE RAW FUEL COMING FROM THE CYLINDER ALONG WITH SPARK FROM A LIVE IGNITION COIL IS A FIRE HAZARD. *TR