2003 FORD E-250 Complaints

TIRE BRAND AND SIZE: PATHFINDER SPORT S A/T 245/75-16 PUT ON REAR OF 2003 FORD E250 EXTENDED LENGTH WORK VAN. BOUGHT NEW FROM DISCOUNT TIRE. AS SOON AS I GOT ON THE INTERSTATE I NOTICED THE VEHICLE FELT UNSTABLE. WAS WANDERING IN REAR. WHEN MAKING A LANE CHANGE IS WAS REALLY BAD AND FELT UNSAFE AS THE REAR SWAYED FROM SIDE TO SIDE. HAD THEM TAKE THESE TIRES OFF AND REPLACE WITH A MAJOR BRAND AND THIS PROBLEM WENT AWAY. I HIGHLY RECOMMEND SOME ONE LOOKS INTO THESE TIRES AS I THINK THE POTENTIAL IS THERE FOR CAUSING A SPIN OUT OR ROLL OVER.

TL* THE CONTACT OWNS A 2003 FORD E-250. THE CONTACT STATED THAT THE ENGINE TEMPERATURE GAUGE FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE INSTRUMENT PANEL WOULD NEED TO BE REPLACED. THE FAILURE PREVENTED THE CONTACT FROM KNOWING IF THE VEHICLE WAS OVERHEATING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000. *TR

TL* THE CONTACT OWNED A 2003 FORD E-250. THE CONTACT STATED THAT UPON STARTING, THE VEHICLE SURGED IN REVERSE AND CRASHED INTO A BUILDING. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT REPAIR SHOP. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS 2003 FORD E-250. THE CONTACT STATED WHILE DRIVING 2 MPH, PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND IT DEPRESSED TO THE FLOOR. THE CONTACT ENGAGED THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND STATED THAT THERE WAS A SMALL PINHOLE IN THE BRAKE LINES THAT DEVELOPED DUE TO CORROSION. AS A RESULT, BRAKE FLUID WAS LEAKING FROM THE BRAKE LINES. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WAS 93,636.

LOSS OF INSTRUMENTS IN 2003 F250 DIESEL WITH 50,153 MILES. FUSE REPLACED BY SERVICE CENTER AND INSTRUMENTS CAME ON. 3 DAYS LATER THEY WENT OFF WHILE IN 4 WHEEL LOW AND THE THE ENGINE STOPPED (BATTERY'S DEAD). I HAD NO CONTROL OVER STEERING AND WENT OFF THE ROAD. REPAIR OF DAMAGED WIRING IN STEERING COLUMN FIXED PROBLEM. THIS IS A WELL DOCUMENTED PROBLEM ON THE WEB AND KNOWN TO THE SERVICE CENTERS I HAVE CONTACTED. IF WIRING IS WORN IN A 50,000 MILE TRUCK I WOULD THINK IT PROBABLY WILL OCCUR IN SIMILAR MODELS. THE TRUCK COULD HAVE SUSTAINED SEVERE DAMAGE AND POSSIBLY RESULTED IN INJURY. WHY NO RECALL OR AT LEAST NOTIFICATION OF OWNERS. *KB

TL*THE CONTACT OWNS A 2003 FORD E-250. THE CONTACT NOTICED THE ABS WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL AND THE GEARS WOULD NOT ENGAGE. THE CONTACT RESTARTED THE VEHICLE AND IT BEGAN TO FUNCTION NORMALLY; HOWEVER, THE ABS LIGHT CONTINUED TO ILLUMINATE. THE DEALER WAS CONTACTED AND STATED THERE WAS A FEE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V444000 (ELECTRICAL SYSTEM:WIRING) THAT MAY BE RELATED TO THE FAILURE BUT THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.

TL*THE CONTACT OWNS A 2003 FORD E-250. THE VEHICLE HAS TRAIL KING A/S MUD N SNOW LOAD RANGE E TIRES, SIZE LT235 85 R1. THE CONTACT NOTICED PULSATION AND VIBRATION IN THE FRONT END OF HIS VEHICLE WHILE DRIVING 75 MPH. A WEEK LATER, WHILE DRIVING APPROXIMATELY 75 MPH AGAIN, THE VIBRATION WORSENED. ALMOST IMMEDIATELY, THE TREAD SEPARATED AND THE FRONT PASSENGER SIDE TIRE EXPLODED, WHICH RESULTED IN $1,900 WORTH OF DAMAGE TO THE VEHICLE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 115,000 AND FAILURE MILEAGE WAS APPROXIMATELY 114,800.

TL*THE CONTACT OWNS A 2003 FORD E250. WHILE DRIVING 35 MPH IN INCLEMENT WEATHER CONDITIONS, THE CONTACT CRASHED INTO A LIGHTPOLE AND SEVERAL TREES. THE VEHICLE WAS COMPLETELY DESTROYED AND NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER AND DEALER HAVE NOT BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 27,000. UPDATED 03/04/09. *LJ UPDATED 03/04/09. *JB

I RECEIVED A RECALL NOTICE (#05S28) FROM FORD CONCERNING A DEFECTIVE SPEED CONTROL DEACTIVATION SWITCH (CREATING A FIRE HAZARD) ON A VEHICLE I OWN. WHEN I CONTACTED DEALERSHIP SERVICE DEPARTMENTS AS INSTRUCTED (TWO DIFFERENT DEALERSHIPS) I WAS TOLD THE NECESSARY PARTS WILL NOT BE AVAILABLE UNTIL AT LEAST DECEMBER 07 BUT THAT I COULD HAVE THE SPEED CONTROL DISCONNECTED UNTIL PARTS WERE AVAILABLE (MEANING TWO TRIPS TO THE DEALERSHIP - TWO DAYS WITHOUT USE OF A COMPANY VEHICLE). I HAVE CONTACTED FORD DIRECTLY AND WAS TOLD THE SAME. HOW CAN IT POSSIBLY TAKE LONGER TO OBTAIN REPLACEMENTS FOR HAZARDOUS DEFECTIVE PARTS THAN IT TAKES TO ORDER A CUSTOM VEHICLE FROM THE FACTORY? DOES YOUR ORGANIZATION HAVE ANY AUTHORITY TO FORCE A MANUFACTURER TO EXPEDITE SUCH MATTERS? *TR

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH AROUND A CURVE AN ACCIDENT OCCURRED TRYING TO AVOID AN ON-COMING VEHICLE. THE CONSUMER HIT A RAILROAD POST. THIS LAUNCHED THE VEHICLE INTO A CREEK. THE AIR BAGS DID NOT DEPLOY, HOWEVER THE SEAT BELTS DID RESTRAIN THE CONTACT. DUE TO THE AIR BAG'S FAILURE TO DEPLOY, THE CONTACT WAS SERIOUSLY INJURED. THE FIRE DEPARTMENT RESCUED THE CONTACT AND A POLICE REPORT WAS PROCESSED AT THE SCENE OF THE ACCIDENT.*AK UPDATED 08/08/06. *JB