1994 FORD E-350 Complaints

EXHAUST MANIFOLD FAILED DUE TO EXCESSIVE HEAT AND THE TYPE OF MATERIAL USED, THE CONSUMER IS REQUESTING THAT THE MANUFACTURER PAY FOR AT LEAST HALF THE BILL FOR THE FAILED COMPONENT. NLM

FUEL PRESSURE REGULATOR IS NOT WORKING PROPERLY. REGULATOR WAS SUPPOSED TO READ AT A VERY LOW NUMBER, BUT WHEN VEHICLE STOPPED WORKING, IT WAS READING AT 90 LBS. CONTACTED DEALER. *AK CONSUMER STATES THE REGULATOR IS SUPPOSED TO REGULATE PRESSURE TO 35 PSI. VEHICLE WAS STILL DRIVE ABLE, BUT WAS RUNNING VERY RICH DUE TO REGULATOR MALFUNCTION. *YH

WHILE ADJUSTING TILT MECHANISM FOR STEERING COLUMN WIRING HARNESS SEPARATED, RESULTING IN A LOSS OF BRAKE LIGHTS/ TURN SIGNALS, AND THE HAZARD LIGHTS. DEALERSHIP HAS NOT EXAMINED VEHICLE FOR THIS PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION. *AK

IN THE LAST 2,000 MILES, I HAVE HAD 3 TIRES SEPARATE AND BLOW OUT. *AK (TIRESIZE: LT225/75R1)

CONSUMER STATES WHEN HE RETURNED TO VEHICLE, HE NOTICED THAT HEADLIGHTS WERE ON, WHEN HE OPENED THE DOOR THE LIGHT SWITCH WAS ON IS OFF POSITION, AND AT THAT TIME, THAT IS WHEN HE NOTICED SMOKE COMING FROM THE STEERING COLUMN, CONSUMER DISCONNECTED THE BATTERY WHICH STOPPED THE SMOKE, CONSUMER REMOVED THE MALFUNCTIONED SWITCH THAT SHORTED OUT, AND HAS SINCE REPLACED THE SWITCH.*JB

DURING A TRIP IN AUGUST OF 2000 I HAD THE RIGHT REAR TIRE TREAD SEPARATED IN DOING SO IT TOOK OUT THE FLOOR/CABINET/WIRING/ EXHAUST/ FENDER, AND FLARES, ETC.THEN AGAIN ON 6/08/01 WITHIN 150 MILES, I LOST 3 MORE TIRES DUE TO TREAD SEPARATION. THIS TIME IT COULD HAVE BEEN SERIOUS,WHEN TREAD SEPARATED IT TOOK OUT THE HOLDING TANK ALONG WITH THE FUEL TANK FILL TUBE AND VENT TUBE. IF ANYTHING IT WOULD HAVE SPARKED THE WHOLE THING COULD HAVE GONE UP IN FLAMES.THESE WERE AT SPEEDS OF 65MPH AND UNDER AND ON SOME VERY HOT DAYS.ALL TIRES HAD AROUND 11/32 OF TREAD LEFT ON THEM.I'AM VERY CONCERNED THAT THIS COULD HAPPEN TO SOMEONE ELSE AND CAUSE SOME INJURY OR DEATH. *AK (TIRESIZE: 225/75R16)

OWNER HAS A FLEET OF 22 1994-1995 VEHICLES THAT ARE STARTING TO SHOW A HIGH RATE OF FAILURES OF THE UPPER BRAKE SHOE ANCHOR IS BREAKING OUT OF THE BACKING PLATE, THIS CAUSES THE BRAKE SHOES TO CONTACT THE OUTBOARD FACE OF THE BRAKE DRUM, WHICH CAN ALSO CAUSE DAMAGE TO THE WHEEL CYLINDER AND CAUSE BRAKE FAILURE. *SLC

TREAD SEPERATION AT HIGH SPEED CAUSING CONSIDERABLE DAMAGE TO WHEEL WELL AND FENDER (DOT NUMBER: MD11AMHV 4 TIRESIZE: LT245/7R16)

THE TIRE STARTED TREAD DELAMINATION. AN 8 INCH STRIP PEELED AWAY FROM THE TIRE. I STOPPED, CHANGED TO THE SPARE, AND THE NEXT DAY REPLACED ALL THE RUNNING TIRES WITH MICHELIN TIRES. THE SPARE IS STILL FROM THE ORIGINAL SET OF FIRESTONE. (DOT NUMBER: VNII8IA TIRESIZE: LT245/75R1)

3 TRANSMISSION FAILURES, TECHNICAL SERVICE BULLETIN #95-11-11 SHOWS FAILURE OF TRANSMISSION DUE TO DEFECTIVE DRIVESHAFT. DRIVESHAFT MUST BE REPLACED WITH A SPECIAL REDESIGNED DRIVESHAFT ONLY AVAILABLE FROM FORD. THIS NEW DRIVESHAFT HAS BEEN REPLACED AND IT SEEMS TO HAVE FIXED THE PROBLEM. IMPROPER AND FAULTY DESIGN FROM THE BEGINNING ACCORDING TO TECHNICAL SERVICE BULLETIN.