2002 FORD E-350 Complaints

HEAD ON VEHICLE STRIPPED BECAUSE OF THE WAY IT IS MADE. THERE WAS A RECALL ON REGULAR E350 BUT MINE IS AN RV. IT WAS IN MOTION WHEN THE SPARK PLUG POPPED OUT WHILE DRIVING DOWN THE HIGHWAY ON I-65 IN BIRMINGHAM ALABAMA.

THIS 350 ECONOLINE, 8CYL., EXTENDED BODY VAN WAS PURCHASED NEW, AND I AM THE ORIGINAL OWNER. THE VEHICLE HAS ONLY 120K MILES ON IT SINCE 2002. BEGINNING SEVERAL YEARS AGO, MY MECHANIC COMPLAINED OF SEVERE FRAME EROSION, HAVING HAD TO REINFORCE AND RE-WELD SEVERAL PARTS BACK ONTO THE FRAME, INCLUDING BUT NOT LIMITED TO THE BRACKETS WHICH SUPPORT THE REAR LEAF SPRINGS. (TWO OCURRANCES-- LEFT AND RIGHT SIDES). LAST WEEK, MY EMPLOYEE COMPLAINED OF SOME REAR END SWAYING AT MODERATE SPEED CORNERING. WE DISCOVERED A CROSS-TIE CONNECTION BETWEEN THE SIDE RAILS AT THE REAR OF THE VEHICLE'S FRAME HAD ROTTED AWAY, THUS CAUSING SOME UNWANTED FRAME MOVEMENT. IF IT WEREN'T FOR A HEAVY-DUTY TOWING PACKAGE I HAD PURCHASED WITH THE VEHICLE IN 2002, I BELIEVE THE LEFT AND RIGHT SIDES OF THE VEHICLE'S UNDER-FRAMING WOULD HAVE TWISTED AND SEPARATED FROM THE BODY YEARS AGO ! ALSO BEGINNING A FEW YEARS AGO, WAS THE DECAY OF THE VEHICLE'S ENGINE BLOCK, AS THREE SEPARATELY TIMED SPARK PLUGS HAD LITERATELY 'BLOWN' OUT OF THE THREADED WELLS OF THE ENGINE BLOCK. MY MECHANIC HAD TO ADAPT HELI-COIL KITS INTO RE-BORED HOLES IN THE VEHICLE'S SPARK PLUG WELLS. IT'S ONLY A MATTER OF TIME BEFORE THESE KITS COME LOOSE, AND BLOW -OUT AGAIN. I'M ALREADY EXPERIENCING A PAINFULLY OMINOUS COMPRESSION LOSS IN ONE (OR MORE) OF THE CYLINDERS. COULD FORD HAVE PURCHASED SOME INFERIOR METALS, THUS PRODUCING A LINE OF JUNK VEHICLES?

WHILE TRAVELING ON AN INTERSTATE HIGHWAY, THE VAN STARTED SHOWING SYMPTOMS OF FUEL STARVATION AND WITH THE FAMILY AND A SEMI ON MY BUMPER THINGS GOT QUITE HAIRY AND STARTED AND ARGUMENT WITH MY WIFE! I EXITED THE HIGHWAY AND PUT CLEAN DIESEL FUEL AND FUEL ADDITIVE TO GET ME BACK HOME; THIS DID NOT WORK AS THE VAN ACTED UP AGAIN SEVERAL MILES DOWN THE ROAD. AFTER STOPPING AND STARTING NUMEROUS TIMES ON A SIDE STREET, I GOT TO A PLACE WHERE I COULD CHANGE THE FUEL FILTER; I NOTICED THAT IT WAS FULL OF RUST AND ALUMINUM FLAKES. THE VAN WOULD NOT MOVE ANY FURTHER, I HAD TO TRAILER IT HOME, THE NEXT DAY. UPON FURTHER INVESTIGATION, I DISCOVERED THAT THE ALUMINUM COATING THE FUEL TAKE HAD COME OFF AND WAS PLUGGING UP THE FUEL PICKUP, EMERGENCY VALVE AND THE FILTER. YOU CAN DO AN INTERNET SEARCH AND FIND WERE THIS IS A COMMON PROBLEM WITH FORDS. IF I WOULD HAVE KNOWN ABOUT IT I WOULD HAVE PERFORMED PREVENTIVE MAINTENANCE ON THE FUEL TANK AND FILTERS. VERY DANGEROUS AND EXPENSIVE TO REPAIR WHEN IT IS TO LATE.....

TL* THE CONTACT OWNS A 2002 FORD E-350 EQUIPPED WITH MICHELIN LT24575R16 TIRES, SIZE: 245/756/16 (NA). WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT FELT VIBRATIONS FROM THE FRONT TIRES. THE CONTACT NOTICED THAT THE TREAD FROM THE FRONT PASSENGER SIDE TIRE WAS SEPARATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE TIRE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13T012000 (TIRES). THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 108,362 AND THE APPROXIMATE TIRE FAILURE MILEAGE WAS 20,000.

TL*THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO RESTART. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED THREE TIMES OVER A PERIOD OF FOUR YEARS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSIS OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2002 FORD E-350. THE CONTACT STATED THAT THE TURN SIGNALS AND HAZARD LIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE TURN SIGNAL SWITCH WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

TRUCK WOBBLING TO THE POINT OF ALMOST WRECKING...WAS TOLD IT WAS WHEELBEARING,ROTORS,TIEROD ECT. I NOW REALIZE FORD HAS A PROBLEM WITH THE TRUCKS REGARDING UNCONTROLLABLE SHAKING , IT IS VERY SCARY WHEN THIS HAPPENS. I ALSO OWNED A 2003 AND 2004 HAD TO SELL THEM BECAUSE THE TURBO KEPT BLOWING OFF AND FUEL INJECTORS WERE CLOGGED. I AM SO DISAPPOINTED. I HOPE IF THERE IS A PROBLEM YOU WILL DO SOMETHING ABOUT IT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 FORD E350 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE FRONT END OF THE FRAME FRACTURED INTO TWO PIECES, CAUSING THE CONTACT TO CRASH INTO A BARRIER ON THE INTERSTATE. THE VEHICLE WAS DESTROYED AND TOWED TO A PRIVATE MECHANIC WHO CONFIRMED THAT THE A FRAME WAS FRACTURED AND CAUSED THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

2002 FORD E-350. S10 DIRECT REPLY-REQUEST FINANCIAL ASSISTANCE RELATED TO THE REPAIRS OF HIS TRUCK DUE TO THE FEDERAL GRANT MANDATED CHEMICAL ADDITIVES TO DIESEL FUEL, CHEMICAL ADDITIVES HAVE CAUSED THE DE-LAMINATION OF THE FUEL TANK *TGW THE CONSUMER STATED THE LOOSE LAMINATE MATERIAL DAMAGED THE FUEL PUMP, FUEL FILTER AND FUEL LINES AND PREVENTED THE OPERATION OF THE VEHICLE. THE CONSUMER STATED THE REPLACEMENT OF HIS FUEL TANK, PUMP, FILTER AND LINES WOULD COST $4,000.00 . THE CONSUMER IS SEEKING FINANCIAL ASSISTANCE BECAUSE THE ROOT CAUSE OF THE SITUATION STEMMED FROM A GOVERNMENT MANDATE. *JB UPDATED 10/18/11. *JB THE CONSUMER STATED THE ENGINE STOPPED, WITH NO WARNING, ON A BUSY HIGHWAY. UPDATED 11/10/11. *JB