2017 FORD F-250 SD Complaints

While driving on a very busy interstate at highway speeds, I went over cracks/bumps in the road. Immediately the front end started to violently shake to the point I thought I could lose control at any moment. The only corrective action was to slow down to around 40 MPH on the highway. Other drivers around me must have seen I was having trouble and got out of my way. This has happened to me numerous times with this truck and acting in the same manner. I have been lucky it did not happen in a curve or bad weather. I have contacted my local Ford Dealer for an appointment, evaluation and assistance. This incident could have ended badly by slowing down on the busy highway and everyone around me driving 70+ MPH. I wonder if any of the other F250 owners with this problem has undergone this shaking in inclement weather.

The contact owns a 2017 Ford F-250. The contact stated while driving approximately 60-65 MPH, the steering wheel and vehicle were shaking uncontrollably. The contact lost control of the vehicle and drove over the jersey wall. The check engine warning light was illuminated. There were no reported injuries. The vehicle was towed to a collision repair facility. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.

On Tues Nov 16, 2021 evening we discovered our Ford f-250 super duty diesel 6.7L on fire. Fire department was dispatched. They extinguished the fire and they determined that it was most likely the engine block heater (It was plugged in because of 0 degree temps that evening). The GFCI breaker was tripped. Upon later research, I found the NHTSA safety recall report 18v-894 dated Dec 18, 2018 found that the vehicle's engine block heater cable is susceptible to moisture accumulation and subsequent fire because of these factors: a female connector angled upwards at 45 degree or greater angle, a low mounting position in the vehicle, and an unshielded or exposed mounting location. On 5/30/2019 we took the vehicle into our local Ford service dealer because of recall #18s45 and they disabled the block heater. On Oct 28, 2019 we responded to recall 19g01and took the vehicle again into the dealer because they reported they had the fix. At that time they replaced the cord on the existing block heater. Consequently, 2 years later, our vehicle succumbed to a catastrophic total loss fire because Ford's recall solution was to simply replace the cord, not to actually address the root cause of the problem, which was the low mounting location and susceptibility to corrosion of the terminals in cold climates. Ford is not cooperating with our requests for them to help us. They advised us that they will no longer be addressing this matter, that they are not going to get involved in helping with our immediate needs (our most immediate need being transportation to and from work), and there is no need to contact them again and they will not be contacting us. Their legal department advised us to consult our insurance company for compensation. By the way, on Aug 17, 2021 we took the vehicle in for its 30,000 mile service, which included full inspection.

If I hit a bump or grooved part of the road the front of the truck starts shaking violently. I have to slow way down or come to a near complete stop. This has terrifying while on the interstate towing my 5th wheel or 24 foot enclosed car trailer. I have taken it to the dealer for a "recall repair" the only thing the dealership did was replace the steering damper. This is a mask for a severe issue! As soon as I left the dealership the problem reared its ugly head again. I called them immediately and scheduled to take it back in on 12 Nov 21. During the conversation with the service department the employee told me they would replace the steering damper again. I am waiting till the appointment to see. This had been an ongoing issue since I purchased the vehicle used in Feb or Mar of 2020.

11/6/21 driving 65 mph on interstate. After hitting a bump in the road the truck experienced a severe shaking in the steering to the point that the truck wasn't maneuverable. I had to slow down to 45 mph for it to go away. It happened again about 20 minutes later and I had to go off the interstate to drop the speed below 55 mph. Supposedly this is a known problem but has never been recalled.

The death wobble is back. The Ford dealership where I purchased it conducted an inspection 11/1/21. They identified front-end issues not covered under the previous death wobble fix. I’ve owned three previous trucks with no violent shaking issues while driving. This should be fix by Ford!

I have experienced the "Death Wobble" experienced by many during my internet research into the violent shaking and oscillation of the front wheels at speeds in excess of 50 MPH. The condition occurs routinely on approach and departure from bridges where the concrete slabs have subsided causing a "pothole" effect, on pavement patches, and potholes. The violent oscillation and shaking can cause temporary loss of control. I had to slow down to a dangerously low speed in congested interstate traffic for the conditon to subside.

My Ford has experienced Terrible steering wheel and front end shaking when traveling at speeds of over 55 mphs. I turned it into kinsel Ford at Beaumont tx for repairs on sept 20 and the shaking was fixed but has returned even more violently. Also known commonly only as the “death wobble “ affecting Ford f250’s

When driving down the interstate the truck started shaking vigorously where we had to pull over 6 times to get the truck to stop shaking. It looked like the tires were bouncing of the road. Very scary.

This is in regards to the Ford "death wobble" that occurs at under normal driving conditions where the vehicle rattles to violently it is not able to be controlled or operated safely. This has happened numerous times and with greater frequency. Ford will only replace the steering dampener, which they have, and it did not fix the problem. If anything it made it worse. Ford also does not consider this a warranty issue, and will not even address it as compensated work. This is likely because Ford knows that this is a major design flaw and it is cheaper to stiff customers than pay to make it right.