2017 FORD F-350 SD Complaints

On Aug 25, 2021, my son took the truck to Crestview Ford in Crestview, FL with 32k miles on it. The Fuel filter on the engine was spraying diesel from a crack in the housing - Have a video and service records available for review. Crestview Ford replaced the fuel filter housing. On Oct 22, 2021, He was traveling to the Stark Fl area with a 4-wheeler in the back of the truck. He started smelling diesel really bad and pulled over and when he stepped out the steps were covered in diesel. When he pulled the hood release the engine compartment flamed up and filled the cab with smoke. He stepped away and called 911. The truck burned to the ground. I have pictures and fire department report available for review (see attached file). The truck had approximately 44k miles. My research has shown that this is a common problem in 2017 + super duty Ford diesel trucks.

Truck has was is called a DEATH WOBBLE. At highway speeds the steering will vibrate violently after crossing an expansion joint or bump in the road. Braking or rapid slow down will resolve the shaking. The issue seems to be getting worse. The truck was taken to the dealership for repair. The repair will cost several hundred dollars and not covered by the warranty. the mileage of the truck is 80,112 and is 90% highway miles.

Ford claims fuel was contaminated and redid whole fuel system when in fact I have read and was told by my mechanic that the lining in the fuel tank was flaking off due to new diesel Ford was aware of this problem and is making lots of money replacing the whole fuel system did not cover under warranty

Traveling down the road at or around 62 -65 mph and you hit a bump truck goes into a violent shake that can only be stopped by slowing down below 40 mph. You have to immediately start slowing down, and it there is someone following that isn’t paying attention it going to get us rear ended on the highway. The truck has 54,000 miles on it. Ford should own the problem.

Death Wobble started to occur around August 2021. No prior incidents. After the first time it would continue to happen anytime driving between 45-60 MPH and hitting a bump in the road. Once you found a bump that would trigger the death wobble, you could EASILY recreate the problem. Once the death wobble starts you have to slow down to 5-10 MPH before it’ll quit. During the wobble it is IMPOSSIBLE to control the vehicle as the steering wheel shakes violently and it feels like all wheels are bouncing opposite of one another creating a very scary and violent situation. I had a repair shop go in and replace anything that could be related and had 2 different alignment shops look into the problem. Ultimately nothing solves the issue.

The contact owns a 2017 Ford F-350. The contact stated that while driving at highway speeds, the vehicle experienced a death wobble. The contact took the vehicle to the dealer for wheel balancing and alignment; however, the failure persisted. The contact returned the vehicle to the dealer who diagnosed that the front stabilizer and the drag links needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 36,000.

There was a recall, NHTSA Recall 19V864, for an "unintended tailgate opening" when the electrical parts became wet. I had the recall performed, but the tailgate continues to fall when water gets in the tailgate. Ford needs to readdress this issue to replace the tailgate from an electrically operated to a manual tailgate. I had to start securing the tailgate with a device to keep it from falling down, especially when towing my RV. I am afraid it would have fallen down damaging it just like it did when I was towing my Son's RV causing over $600 damage to the RV cargo doors and damaging the Truck's tailgate. The tailgate has fallen down at least five (5) times since the recall repair. Last one was today during a thunderstorm. The truck was sitting still, other times driving down the road.

Back-UP and 360 degree cameras have failed and are malfunctioning. They have been replaced twice and safety issue still exists. The cameras are foggy and especially at night and are not very clear. Safety hazard has occurred on several occasions where a child, person or object behind the vehicle are not clearly seen. There is a safety recall for 2019 super duty trucks but not for the 2017 models. This safety issue is very common according to internet searches and several vehicles all have the same issues and concerns. God forbid that a child or person is hurt because of the low visibility of these cameras. It is not only the back-up rearview camera but all of the cameras that are part of the 360 degree view of visibility. The side cameras as well as the forward facing camera all have the same issue. Ford should recall and remedy this issue before anyone gets hurt or killed if it hasn't already happened because of this issue.

Ford trucks have a known issue of cameras fogging up with condensation. Becomes very difficult to see where you’re backing into. The condensation gets so bad you can’t see at all sometimes. These trucks are big and need the cameras to assist in and out of tight spaces or keep you from rolling over something without knowing it.

The contact owns a 2017 Ford F-350. The contact stated while driving approximately 15 MPH, the tailgate fell. The contact indicated there was no warning prior to the tailgate falling on several occasions. The contact also stated the four rear outer aluminum rims were constantly allowing the tires to lose air pressure. There were no warning lights illuminated. The vehicle was taken to the local dealer and diagnosed tailgate failure was confirmed. The dealer repaired the tailgate; however, the failure recurred. The manufacturer was notified of the failure. The approximate failure mileage was 10,000.