KEYSTONE Complaints

WHILE OUTSIDE OF SALT LAKE CITY UTAH ON INTERSTATE 15 WE EXPERIENCED A TREAD SEPARATION ON OUR 2012 KEYSTONE MONTANA 3100RL. THE LEFT REAR TIRE CAME APART. THE TIRE WAS A GOODYEAR MARATHON STS235R 16. THE TIRES WERE MANUFACTURED IN THE 49TH WEEK OF 2011 AND CAME EQUIPPED WITH THE TRAILER WHEN WE BOUGHT IT NEW IN FEBRUARY OF 2012. I FILED A COMPLAINT WITH GOODYEAR (COMPLAINT #[XXX]) IN WHICH THEY SAID THEY DETERMINED IT WAS NOT THE RESULT OF A DEFECT WITH THEIR TIRE BUT A RESULT OF A LOSS OF AIR PRESSURE. I HAVE MAINTAINED THE PRESSURE IN MY TIRES AND BELIEVE THEY ARE WRONG. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2012 KEYSTONE COUGAR FIFTH WHEEL. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE FRONT DRIVER'S SIDE LEAF SPRING FRACTURED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE ONE LEAF SPRING OUT THE FOUR WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300. UPDATED 7/31/13 *CN THE CONSUMER STATED WHILE TOWING THE RV AT HIGHWAY SPEED, THE LEFT FRONT LEAF SPRING BROKE AND CAUSED THE AXLE TO BREAK AS WELL. UPDATED 08/06/13

TL* THE CONTACT OWNS A 2002 KEYSTONE MONTANA MOUNTAINEER TRAILER. THE CONTACT STATED THAT THE CAMPER HAD A SMELL OF AMMONIA COMING FROM THE REFRIGERATOR. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 07V134000 (EQUIPMENT) AND WAS TOLD BY THE MANUFACTURER THAT THE REPAIR WAS NOT FOR THE TYPE OF FAILURE THAT THE CONTACT HAD EXPERIENCED. THE VEHICLE WAS NOT REPAIRED. THE MILEAGE WAS UNKNOWN. *TR

LAST OCTOBER WE TOOK A TRIP FROM DAYTON, OH TO ORLANDO ? DISNEY WITH OUR 2010 KEYSTONE MONTANA. ON THE RETURN TRIP FRIDAY OCT 5TH, JUST NORTH OF ATLANTA WE HAD A BLOWOUT ON ONE OF THE OEM GOODYEAR MARATHON TIRES, DRIVER SIDE REAR. *TR THERE WAS LIGHT TRAFFIC ON NEWLY BLACKTOPPED ROAD WITH CRUISE CONTROL. BOOM! TIRE AND DEBRIS WENT EVERYWHERE. THE TIRE WAS SHREDDED AND WE HAD AAA/RV COME OUT AND PUT ON THE SPARE. I IMMEDIATELY CHECKED ALL OF THE TIRE PRESSURES (81-82LBS) SO THEY WERE ALL WITHIN SPEC. I CHECKED THEM BEFORE WE LEFT CALHOUN THE NEXT MORNING MAKING SURE THEY WERE ALL 80LBS. WE LIMPED HOME ON SATURDAY. THE TIRE WAS A GOODYEAR 235/80R16, MFG CODE: OH UN 1LHR 3608. THE TIRE WAS RETURNED TO GOODYEAR PER THEIR INSTRUCTIONS. BOTH OF THE PLASTIC FENDERS, THE SKIRT UNDER THE WATER HEATER, REAR SKIRT WERE DAMAGED AND THE BOTTOM OF THE TRAILER. I HAVE REPLACED ALL OF THE TIRES WITH ANOTHER MAKE INCLUDING THE SPARE. *TR

TL* THE CONTACT OWNS A 2010 KEYSTONE MONTANA 3750FL EQUIPPED WITH A NORCOLD REFRIGERATOR, SERIAL NUMBER 12711643. THE CONTACT MENTIONED THAT THE REFRIGERATOR MALFUNCTIONED AND IT FAILED TO COOL ITS CONTENTS. THE CONTACT ALSO STATED THAT THE REFRIGERATOR HAS BEEN REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 10E049000 ( EQUIPMENT) ON THREE DIFFERENT OCCASIONS BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE EQUIPMENT WAS NOT REPAIRED. *TR

POWER KING TOWMAX STR BLEW OUT AFTER ONLY 150 (ONE HUNDRED FIFTY) MILES OF SERVICE. TIRE WAS SPARE FOR 3+ YEARS BEFORE BEING ROTATED INTO SERVICE. AS SPARE, TIRE WAS PROTECTED FROM SUN, BUT MAY HAVE EXPERIENCED UV DAMAGE DUE TO COVER NOT COMPLETELY COVERING BACK. PRESSURE OF 65PSI CONFIRMED 48 HRS PRIOR TO FAILURE. ST225/75R15, DOT 83B4 GPB 0110 DY. TIRE WAS MOUNTED IN DRIVER REAR POSITION OF FIFTH WHEEL RV TRAILER, A 2010 COUGAR 244RLS. ESTIMATED LOAD ON TIRE WAS 1800LB. TIRE WAS RATED FOR 2540LB AT 65PSI. VEHICLE WAS DRIVEN AT 65MPH IN 90+ DEGREE AMBIENT TEMPERATURE FOR TWO HOURS PRIOR TO FAILURE. NO TPMS, BUT DRIVER WITNESSED (IN REAR MIRROR) PIECES OF TREAD SEPARATING AND PULLED OVER BEFORE TRAILER WAS DAMAGED. TIRE MAY HAVE BEEN DRIVEN FOR SEVERAL MILES, AS TIRE'S LOCATION (DRIVER SIDE REAR) MADE IT NOT VISIBLE. *TR

TL* THE CONTACT OWNS A 2013 KEYSTONE COUGAR. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR BUMPER BEGAN TO SEPARATE FROM THE VEHICLE OVER THE COURSE OF A TWO HOUR DRIVE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE BUMPER WOULD HAVE TO BE RE-ATTACHED. THE VEHICLE WAS REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 120. UPDATED 06/10/13 *BF UPDATED 06/14/2013*JS

TL* THE CONTACT OWNS A 2012 KEYSTONE COUGAR HIGH COUNTRY FIFTH WHEEL TRAILER. THE CONTACT STATED THAT THE REAR BUMPER WAS NOT SUFFICIENTLY ATTACHED TO THE VEHICLE TO CARRY THE WEIGHT OF A BIKE RACK AND ANY OTHER EQUIPMENT HOWEVER, THE BUMPER DID FRACTURE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO ADDED SUPPORT GUSSETS TO REINFORCE THE BUMPER. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 1500. UPDATED 03/26/2013*LJ THE CONSUMER STATED THE BUMPER DID NOT FALL COMPLETELY OFF.

TOOK DELIVERY OF A NEW 2007 KEYSTONE MONTANA 3400RL (JANUARY 11, 2007) THAT IS STAMPED WITH A GAWR OF 7,000 LBS AND GVWR 15,500 LBS. THE FACTORY TREDIT T6 WHEELS HAVE A CASTING STAMP OF 3,042, BUT A STICKER ON THE RIM INDICATING 3,750 LBS @ 110 PSI. (AT LEAST 3,500 LBS WOULD BE REQUIRED TO MEET THE GAWR AND GVWR). WHEN WE REPLACED TIRES IN 2008, THE TIRE DEALER SAID THE STICKER LOOKED SUSPICIOUS AND REQUESTED THE RATING FOR THE T6 WHEEL TO BE IN WRITING FROM TREDIT. WE OBTAINED THAT VERIFICATION IN THE FORM OF AN EMAIL FROM TREDIT IN 2008, WHICH WE HAVE. WE AGAIN NEED TO REPLACE THE TIRES AND WE REQUESTED VERIFICATION IN WRITING FROM TREDIT, HOWEVER THIS TIME WE LEARN VIA EMAIL FROM TREDIT THAT THE RATING ON THE STICKER HAS BEEN RESCINDED AS THAT WHEEL NEVER ACTUALLY PASSED THE LOAD TEST. WITHOUT THE STICKER RATING, OUR STAMPED 3,042 WHEELS ARE 500LBS UNDER-RATED FOR THE LOAD, OR 2,000 LBS OVERLOADED FOR THE GVWR AS DELIVERED FROM THE FACTORY, NOT TO MENTION THAT THE FACTORY TIRES EXCEEDED THE LOAD CAPACITY ON THE WHEELS AS WELL. THERE WERE NO NOTIFICATIONS OR RECALLS RECEIVED ABOUT CHANGES IN THE WHEEL RATING, AND WE ARE ORIGINAL OWNERS. THERE IS NO MENTION OF THE DISCREPANCY ON THE KEYSTONE WEBSITE UNDER NOTIFICATIONS AND RECALLS, EVEN THOUGH THIS ISSUE EXTENDED THROUGH AT LEAST ONE MODEL YEAR, POSSIBLY TWO. THERE IS SOMETHING VERY SUSPICIOUS ABOUT THE WAY THE STICKER WAS HANDLED. OUR MODEL MONTANA WAS BUILT WITHIN THE FIRST MONTH THAT KEYSTONE/MONTANA SWITCHED TO 7,000 LB CAPACITY AXLES, YET THE WHEELS WERE THE SAME TREDIT T6 USED SINCE 2005 ON THE 6,000 LB CAPACITY AXLES. I BELIEVE THERE COULD HAVE BEEN FRAUDULENT ACTIVITIES LEADING TO THE STICKERS TO ALLOW THE WHEELS TO MEET THE ADDITIONAL CAPACITY OF THE NEW AXLES. *TR

WE BOUGHT OUR 2010 KEYSTONE FUZION RV AROUND JUNE/JULY 2010. THE DEALER (CAMPING WORLD, S.C.) TOLD US THAT THE RV WAS A BRING-BACK, NEVER EVEN USED (WHICH, LOOKING BACK ON IT, MAKES ME WONDER IF THERE WERE PROBLEMS WITH THE UNIT FROM THE START). IN AUGUST 2010, WE TOOK IT ON A TRIP TO VIRGINIA. WE PLUGGED IN THE 50 AMP SERVICE AND ABOUT AN HOUR AFTER, THE UNIT CAUGHT FIRE IN THE STORAGE COMPARTMENT. THANKFULLY, MY HUSBAND WAS THERE WHEN IT HAPPENED AND WAS ABLE TO CONTAIN THE DAMAGE. WE IMMEDIATELY CONTACTED KEYSTONE RV, WHO HAD NO INTEREST WHATSOEVER IN WHAT HAPPENED. IT TOOK MONTHS BEFORE A DEALERSHIP IN PA FINALLY MADE THE REPAIRS,' REPLACING A BAD TRANSFER SWITCH. THIS PAST SUMMER (JUNE 2012) WE AGAIN TOOK THE UNIT TO S.C. FOR VACATION. WE SMELLED ELECTRICAL FIRE IN THE UNIT AND AGAIN, THANKFULLY, MY HUSBAND FOUND THE FIRE BEFORE ANY DAMAGE OCCURRED. WE AGAIN CALLED KEYSTONE RV, WHO DRUG THEIR FEET IN OFFERING ANY TYPE OF ASSISTANCE. THIS TIME, WE WERE ONLY A MILE OR SO FROM WHERE WE ORIGINALLY PURCHASED THE UNIT (CAMPING WORLD). AFTER MULTIPLE PHONE CALLS AND ARGUMENTS WITH KEYSTONE AND CAMPING WORLD, A TECH CAME TO OUR CAMPSITE AND FOUND THAT KEYSTONE RV HAD REPLACED THE ORIGINAL FAULTY TRANSFER SWITCH WITH THE SAME FAULTY TRANSFER SWITCH. THIS WAS TWICE THAT OUR FAMILY COULD HAVE SUFFERED INJURY OR DEATH AS A RESULT OF THEIR MISTAKE. WE HAVE NOT USED THE UNIT SINCE AND I AM HONESTLY SCARED TO USE IT. *TR