KIA Complaints

The contact owns a 2026 Kia Seltos. While driving across an intersection, another vehicle ran a stop sign and collided with the contact's vehicle. The impact occurred on the driver-side door, causing extensive damage to the vehicle. No property damage reported. The vehicle came to a complete stop after being struck. The contact stated no air bags were deployed. The vehicle was towed to a tow yard but was than brought to the residence. No warning lights were illuminated before the crash. A police report was filed. The vehicle will be fixed. The contact stated she was the driver and had a passenger (son) in the front. The contact sustained a severe head impact and was knocked unconscious. The head trauma caused total numbness across the right side of her face and directly impaired her peripheral vision. Additionally, the contact sustained deep contusions to her neck and severe structural disc damage to her lower back. The contact's son, who was also an occupant in the vehicle, experienced acute head pain following the crash. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unavailable.

The contact owns a 2019 Kia Sorento. The contact stated while driving at an undisclosed speed, the low oil and the check engine warning lights were illuminated. The contact stated that a few days later, the contact noticed white smoke coming from the exhaust. The check engine warning light illuminated intermittently. The vehicle was taken to an independent mechanic where it was diagnosed with detached cylinder head bolts and a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 186,016.

2021 Kia Soul | VIN: [XXX] | Recall SC336 (NHTSA 25V099) | Kia America Case No. XXX DEALER: Team Kia of El Cajon, 541 N. Johnson Ave, El Cajon, CA 92020 SYMPTOMS: Rapid oil consumption, abnormal engine noise, overheating, vehicle stalling at complete stops, difficulty restarting. All symptoms are explicitly documented in SC336 TSB (Rev 6, 10/21/2025) as consequences of defective piston oil rings. DEALER CONDUCT ISSUES: 1. CHARGED $280 DIAGNOSTIC FEE TO PERFORM A RECALL. Owner confirmed open recall on VIN before arrival. Dealer required $280 diagnostic payment as condition of recall service, in violation of 49 U.S.C. 30120. 2. 24-HOUR TSB PROTOCOL VIOLATION. SC336 TSB requires engine vibration inspection no sooner than 24 hours after R/O open date. R/O opened May 16 at 7:38 AM. Inspection report also dated May 16 with no timestamp. If test ran same day, PASS result is invalid under Kia's own guidelines. 3. FAILED TO OPEN REQUIRED TECHLINE CASE. SC336 TSB Page 2 states: if engine noise is present and inspection results in PASS, dealer must open a Techline case. Owner continues to experience engine noise. Dealer has not provided a Techline case number despite two written requests. 4. DEMANDING $2,500 FOR RECALL-RELATED SYMPTOMS. Dealer is attributing stalling and oil consumption to a separate camshaft issue and demanding $2,500 more. SC336 TSB documents that piston ring damage causes cascading engine damage including timing components. 5. OWNER IS [XXX] , drives for Uber. Vehicle out of service 12+ days. Lost income and rental costs incurred. Kia America corporate (Case XXX) has been copied on correspondence but has not responded. Requesting NHTSA review of this dealer's SC336 recall compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I always turn off the engine auto stop while driving and am sure this feature was turned off at the time of the incident. I was stopped at a drive thru idling in drive when my RPM sounded like it lowered and the the vehicle started shaking. Since it sounded like it was going to stall, I instinctively put the vehicle in park and that naturally bumped up the RPM avoiding a stall. I tried to replicate it and could not in the 15 minutes I sat in idle afterwards. I would like to note that we did the software emissions recall update at the dealership recently and ever since then the vehicle is consistently idling 100-200 RPM lower than it used to, usually around 500 RPM in drive and 700 RPM in park. I'm grateful this has only happened at a drive thru so far but I'm afraid to stall in traffic as we drive in busy and dangerous areas and it could be deadly to stall in traffic. Since so far I cannot get this to replicate we have not set an appointment at the dealership as all the other complaints on this matter show the dealership is unable to replicate the problem. Please require KIA to fix this as it is incredibly scary to fear stalling in dangerous location due to traffic speeds and/or getting stuck in a crime riddled area. Thank you for your help.

This vehicle is eligible for Theta II class action settlement, and I cannot seem to get the Kia dealerships, or the Kia Corporate to honor the engine failure issue that I was told by the AAA mechanic should have been replaced. I have also been told by others, including another mechanic at a nationally recognized mechanic that it needs to be taken care of, and that they had the same vehicle and had there's taken care of without any issues.

COMPONENT FAILURE: The engine, power train, and speed control systems failed due to the known Nu 2.0L GDI connecting rod bearing defect. SAFETY RISK: My [XXX] daughter was driving in heavy rush-hour traffic when the vehicle suddenly lost motive power and entered a 20 MPH "limp mode." This sudden deceleration created an immediate and severe risk of a rear-end collision, endangering my daughter and surrounding motorists. DEALER CONFIRMATION: The failure was officially confirmed by Flow Kia of Charlottesville (RO #XXX). On Dec 3, 2025, the dealer confirmed active DTC P1326 (KSDS) and documented failed cylinder compression (as low as 150 PSI; min spec is 178 PSI). The dealer issued a written diagnosis stating: "engine replacement is required." MANUFACTURER CONDUCT: Despite their own dealer's written diagnosis and the active P1326 safety code, Kia Corporate issued a bad-faith warranty denial. The dealer also unlawfully charged me $165 for the mandatory KSDS warranty diagnostics. SUMMARY: This is a textbook safety failure under NHTSA Investigation EA 21-003. Kia's refusal to replace the engine under the court-supervised Engine Litigation II settlement represents a systemic failure by the manufacturer to remedy a known safety hazard. 51-page evidence packet attached. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle exhibits repeated brake pulsation and vibration under normal braking conditions, affecting braking performance consistency. The issue began at approximately 10,000 miles and has progressively worsened. The vehicle currently has approximately 30,000 miles. The pulsation is felt through the steering wheel and brake pedal during moderate braking from highway speeds and occurs consistently across multiple driving conditions. The condition is significantly more pronounced when using the vehicle’s adaptive cruise control system. During normal operation, the adaptive cruise repeatedly applies the brakes automatically, and this consistently produces increased vibration and uneven braking response. This indicates the issue occurs during normal vehicle operation rather than abnormal use. The repeated pulsation creates inconsistent brake feel and may affect stopping performance, particularly during repeated or sustained braking events. This raises concern regarding braking reliability and stopping consistency, especially in traffic conditions where adaptive cruise control is actively managing following distance. The condition has steadily worsened over time and is present during routine driving. It is not limited to high-speed or heavy braking scenarios. A manufacturer Technical Service Bulletin (TSB CHA126V) exists for this vehicle model addressing front brake disc judder. The symptoms described in the bulletin match the condition experienced in this vehicle. Given the early onset, progressive nature of the issue, and the involvement of system-controlled braking (adaptive cruise), this condition appears to be related to component performance or design rather than normal wear. Kia response .. Dear [XXX] , Thank you for contacting Kia Customer Care. We do not see that bulletin related to this VIN, as such, any repairs recommended would be the responsibility of the vehicle’s owner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We have been having persistent safety issues with this vehicle. The issues have ranged from unsecured gas cap to loss of power. We’ve also had severe transmission issues where the car will not shift out of first gear. This happened on the Garden State Parkway and nearly caused an accident as the car wasn’t able to go above 27 mph safely.

VEHICLE: 2023 Kia Sorento, VIN [XXX] , currently 48,000 miles. Vehicle has never been in a collision. DEFECT: FUEL FILLER DOOR ACTUATOR WITH NO EMERGENCY RELEASE — STRANDING HAZARD The fuel filler door actuator fails to release on demand intermittently. When the actuator fails, the door must be pried open with tools or force, which is inconsistent and not always possible. The dealership service advisor has stated that this model is not equipped with any emergency release mechanism for the fuel filler door. With no emergency release, the actuator is the only mechanism by which the fuel door can be opened. SAFETY IMPLICATION: An intermittent actuator failure with no backup release mechanism creates a stranding hazard. If the actuator fails when the vehicle is low on fuel — particularly in remote areas, in cold weather, at night, or in emergency situations requiring refueling to reach safety or medical care — the vehicle cannot be refueled and becomes immobilized. This is a single-point-of-failure design on a system required for vehicle operation. The condition has been reported to the dealership and remains unresolved. The vehicle remains within the 5-year / 60,000-mile basic warranty period. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EHICLE: 2023 Kia Sorento, VIN [XXX] , currently 48,000 miles. Vehicle has never been in a collision. DEFECT: MASTER POWER WINDOW SWITCH / WIRING HARNESS — OCCUPANT EGRESS HAZARD The driver's master power window switch fails intermittently, causing simultaneous loss of all window operation and electric door lock function. When this occurs, occupants cannot operate any window or unlock any door electrically until the condition resets, typically by opening and closing the driver's door. The condition was first reported to Arapahoe Kia at 24,859 miles on 11/08/2024 (RO 208018) and again at 25,050 miles on 11/15/2024 (RO 208449). On the 11/15/2024 visit, the dealership confirmed the defect on customer-supplied video and performed a full diagnostic including pin tension testing on connector D01, power, ground, B-CAN continuity testing, and a wiggle test of the harness. The dealership's written conclusion on the repair order: "we've determined that the harness is probably not the issue and it will need a new master switch." The master switch was not ordered or installed, and the vehicle was returned with the defect unresolved. The condition continues to occur intermittently as of the current 48,000-mile reading. SAFETY IMPLICATION: This defect creates an occupant entrapment and egress hazard. In a fire, submersion, or crash event where the mechanical door release is inaccessible, inoperative, or where occupants are incapacitated, simultaneous loss of window operation and electric door lock function eliminates secondary egress options. The defect is intermittent and unpredictable. The vehicle remains within the 5-year / 60,000-mile basic warranty period. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)