KIA Complaints

I purchased this 2021 Kia Telluride new and have had it routinely serviced and maintained by authorized Kia dealerships. At approximately 60,000–80,000 miles, the engine began consuming excessive oil. I reported the condition to the Kia dealer at approximately 80,000 miles, while the vehicle was still within Kia's 10-year/100,000-mile powertrain warranty. The dealer initially recommended a tune-up, but the oil consumption continued. During a later visit, the dealer identified an issue involving the OEM oil-filter housing and replaced the affected component. Despite this repair and continued maintenance, oil consumption progressively worsened. The vehicle now has approximately 160,000 miles and requires approximately one pint of oil every 2–3 weeks. The current diagnosis indicates potential internal engine damage, including cylinder-wall scoring that may allow oil to bypass the piston rings and burn in the combustion chambers. I have been advised the engine may require replacement at an estimated cost of approximately $13,000. My primary concern is that this condition began and was reported to Kia while the vehicle was still under the powertrain warranty, but the repairs did not correct it. Continued excessive oil consumption and internal engine damage create a safety concern because they could result in low oil pressure, engine seizure, stalling, or sudden loss of propulsion while driving. The vehicle is available for inspection, and its maintenance history, prior complaints, dealer repairs, and current condition are documented through Kia dealership service records.

I was slowly driving in the parking lot of the Meadowmeer Golf course on [XXX] today, Monday XXX at about 11:30AM. As I began the turn to pull into a parking space, at about 5 miles an hour, the car rapidly and unexpectedly accelerated. I immediately slammed on the brakes, leaving skid marks on the payment. Before the car stopped it drove into a curb around a flower garden. The i-pedal was not engaged. Myself and the passengers were frightened but not injured. No one has inspected the car as yet. There were no messages. I am trying to reach the dealer Kia of Bremerton, WA but they have not yet been responsive. The car has been driven about 9500 miles in total. I bought it as a certified used car from Kia on XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a violation of the National Traffic and Motor Vehicle Safety Act by Ball Kia (National City, CA). The dealer tried to deny service for recall 25V794000 (SC356) for a melted, leaking fuel tank, fabricated a false diagnostic narrative of road impact to exploit me, and tried to charge $3,000 out-of-pocket for a federally mandated free repair.My vehicle has a severe fuel leak from a compromised fuel tank. Ball Kia service refused the recall, claiming "external aesthetic factors" or "road debris impact" caused it, and pressured me to tow it away.Using my military infantry experience in mechanical damage assessment, I inspected the vehicle in the service bay. I verified there is absolutely no puncture, tear, scrape, or kinetic impact on the fuel tank assembly. The dealer pointed to a split in the fuel tank protector panel, but a professional assessment shows this is false. The plastic protector panel failed due to extreme thermal exposure; the expanding tank pressed it against the hot exhaust, causing it to melt and tear under heat/pressure, not a kinetic strike.The tank itself is structurally melted and deformed with zero signs of road impact. This physical evidence matches the exact defect mechanism in the NHTSA recall: a deteriorated check valve allows intake pressure into the fuel tank, causing it to expand, hit hot exhaust components, melt, and leak.Only after I read the exact NHTSA safety risk and remedy text verbatim did the service manager back down and open a manufacturer Tech Line.Because I had to fight a fraudulent diagnosis to get this safety mandate acknowledged, I fear internal dealership retaliation, being blacklisted, or receiving a subpar, dangerous repair. Leaving a high-risk fire defect unaddressed is a public safety hazard. Please audit Ball Kia's handling of campaign 25V794000 to ensure they are not endangering or defrauding other affected Kia K5 owners.

The contact owns a 2021 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). The vehicle was taken to a dealer for the recall repair. The contact was struggling to receive updates on the status of the vehicle. The contact spoke with a service clerk and was informed that the repair was going well and that only one recall test remained. However, a supervisor later called and stated that the recall repair could not be completed. The vehicle could not be repaired. The vehicle was no longer functional due to a high risk of catching fire from fuel tank swelling caused by the recall defect. The contact stated that prior to the dealer visit, the vehicle had no issues but became inoperable. The vehicle was not repaired, and the dealer stated that the vehicle could not be repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 111,000.

The contact owns a 2021 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle failed to shift gear as intended, and the RPM was extremely elevated. The failure had occurred on several occasions. The contact pulled over, and the message "Possible Condition with the Transmission Control System Detected - Press SOS for Roadside Assistance" was displayed on the instrument panel. The vehicle was towed to a dealer where it was diagnosed and determined that the transmission needed to be replaced. The contact researched and was made aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 116,000.

The cluster screen on my 2024 Telluride is BLACK when I turned it on today. No issues prior and turning the car off and on does not help. I cannot see my fuel gauge, speed, winshield wiper speed, tire air levels, what gear I am in nothing. I contacted dealer and they have heard of no issues and cannot get me in for repairs until at least two weeks. I feel this is very unsafe since I am not sure of my speed or my fuel level! There was no warning whatsoever, just a black screen.

Uneven wear 8/16 ones at 7/16 and one is 6/16 and the other is at 5/16 and has been riding ruff since we purchased them.

On our 2024 KIA Carnival, which my wife is the primary driver, the blind spot warning on the passenger side does not work all the time. Driver side is 100% okay. She drives on I40 and hwy111 to and from work daily, and when passing on the left, she looks for the red triangle to let her know it is clear to get back in the right lane. It only works about 50% of the time and the dealership has worked on it three times unsuccessfully, so we put in a complaint to KIA corporate in June and they have been very unresponsive. We keep the vehicle clean, so it is not that. She just wants it to be reliable for safety reasons and it is not. It probably just takes a different set of engineering eyes to look at it but KIA seems like a dead end so far. Please help us. Thanks. BTW, the people at the dealership have been very good to us, we just believe engineers at a higher level need to solve this problem.

This report concerns a repeating loss of power in the 2025 Kia Sorrento-Hybrid that forces the engine into "limp-mode". This issue has occurred when traveling at speeds exceeding 55mph on highway as well as when accelerating to merge into traffic. The vehicle does not flash any warning lights on the dashboard and shuts down in the middle of traffic which presents a serious safety issue for oncoming traffic as the vehicle must coast to the side of the road. This has occurred multiple times and twice I have had the vehicle towed to the dealership. Initially a fuel pressure sensor was replaced and the second time the dealership indicated they could not find any relatable cause. Since that time there have been two additional occurances that I have had. I believe the issues are related to either a fuel pressure sensor or a sudden loss of power within the EV system that causes the vehicle to protect itself by enetering into the limp-mode. I have discovered a short term resolution is to disconnect the 12-V battery and let the car sit for 30 minutes to clear the system codes, but sitting on a busy roadway and the loss of power at speed is a serious safety issue. I have spoken to other owners who have experienced similar issues so this appears to be a wider spread issue.

Purchased my Kia on the XXX then on the XXX, My engine light came on and my car went into Safety Mode . I at once took it to Auto Zone and their test came back with P1326 Knock signal range / performance. I then looked it up and found that a recall was put out quite a while back called an [XXX] # took my car to Kia Dealership in [XXX]. They said I could bring it in that was on the XXX and if an appointment came open they would check but they did not have an opening til the 14th which was today and I was told it would be next week . Could someone please send me updated information concerning the 2018 Kia Sportage and the Knock Sensor [XXX] [XXX] [XXX] [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)