KIA Complaints

The contact owns a 2020 Kia Sportage. The contact stated that while driving at various speeds, the oil warning light flickered on the instrument panel. While the contact's son was driving the vehicle at highway speeds, the vehicle hesitated while depressing the accelerator pedal. The contact's son pulled off to the right shoulder of the highway, and the vehicle entered LIMP Mode. Despite the failure, the driver was able to drive the vehicle back to the residence. The contact called the dealer and made an appointment to have the vehicle serviced. While driving the vehicle to the dealer, the failure occurred again, and the vehicle failed to accelerate above 10 MPH. Due to the failure, the contact took the vehicle to a dealer, where the vehicle was diagnosed with engine failure. The following day, the contact called the dealer and was informed that the engine had not failed, and a knock sensor test was performed which restored the engine function. The contact then took the vehicle to an independent mechanic and was informed that the engine was consuming an excessive amount of engine oil. The vehicle was taken back to the original dealer, where an appointment had been scheduled. The dealer performed a series of oil consumption tests and monitored the oil consumption every 1,000 miles. After four consumption tests, the contact was informed that the engine was consuming an excessive amount of engine oil. The contact took the vehicle back to the independent mechanic and was informed that the oil consumption had worsened, and that the vehicle had consumed 4 quarts of oil in less than 5,000 miles. The manufacturer was not notified of the failure. The vehicle had not yet been repaired. The failure mileage was approximately 93,000.

I was driving on the highway when I heard a whistle. When I arrived at my destination, I was surprised to see that the front driver’s side windshield trim panel was missing and flew off when I was driving. Earlier, I had a similar issue with the front passenger side trim panel. I reported these safety concerns to Kia on 9/2. I received a standard form letter on 9/4 (copied below). I was surprised by Kia’s response because I think parts flying off during typical driving use is more than standard repair and is a safety concern for all of us who travel on our roads. I’m reporting to you because I care about safety as both a driver and a passenger. I attached the photos I took and sent to Kia. —- Thank you for contacting Kia Customer Care. We’re sorry to hear about the concern with your Kia. The standard Limited Basic Warranty for your vehicle has expired (5 years/60,000 miles whichever comes first.). As such, any repairs recommended outside of warranty coverage, or not included in an applicable campaign, would be the responsibility of the vehicle’s owner. If you have any additional questions or need further assistance, please don’t hesitate to call us at 800-333-4542 (option 2, then 5) and provide your case number. Sincerely, Kia America

Check engine light came on. 4 new engine coils and spark plugs. Carb cleaner in gas. Check engine light on again then while driving car jerked and check engine light blinking. Code 420 catalytic converter. This vehicle was under recall for same issue but was ok at time of recall. Was checked at Kia dealership u see recall time.

Just bought the car, was perfectly fine during the test drive, no lights on or engine codes present. On my way home check engine light came on showing code P0420 , catalyst system efficiency below threshold (bank 1), saying the catalytic converter needs to be replaced. Did some research and found there were certain 2016 Kia Sorentos recalled for this issue, but doesn’t show up on affected vehicles list when I look up my VIN # .

There was a fire under my minivan as my husband was driving it, creating smoke and flames. He lost power to the van and had to coast to the right side of the highway where he came to a stop with the flames occurring. This is the family vehicle and I have small children. We had no warning lights or any indication that there would be a fire in my vehicle as the van had been running smoothly, and I had kept up with all recommended maintenance (see Carfax report). On July 31st, I was told by Kia America that there was a fire in the engine compartment and that it was inconclusive and they could not determine what started the fire. On August 15th, my father and husband went to Castrucci Kia (where the car was) and were shown that there were holes in the engine block, and the service representative Brandon stated that the engine failure had probably thrown some of the rods causing the holes in the lower engine block sparking a fire when the leaking oil hit the catalytic converter. My insurance was involved, but I was not able to obtain a settlement from them, but I kept up on all maintenance and adherence to Kia guidelines and my engine unexpectedly failed and caught on fire. I was told I would need a new engine at an approximate cost ranging from 12,000 to 15,000 dollars. I believe that my 2018 Kia Sedona's 3.3 L gasoline direct injection engine was manufactured defectively resulting in catastrophic engine failure, APPARENTLY puncturing the engine block, causing engine oil to leak and ignite a fire. Our attempts to address this critical issue with Kia have been met with significant resistance and delays. It appears that Kia refuses to take responsibility. There has been an escalating number of safety complaints and instances directly linked to the 3.3 L Kia V6 Lambda II engine. I appreciate your assistance in resolving this issue with KIA AMERICA and the local KIA service center where my vehicle is located

Power completely dropped while driving in traffic. This occurred several times. I could have easily been rear ended. Also, I could have been stuck within an intersection, I could have been broadsided. I see researched this issue and found it was widely written about in KIA EV6 online forums. Kia should have checked for issues before I leased the 2025 EV and informed me before I made a decision to lease vehicle. This occured in first weeks I drove the new car.

For the past year to year ½ I have brought my car in for concerns with idle, hesitation when accelerating, stalling out, etc. This has put me in compromised situations when in traffic, at stop lights and when trying to accelerate to get on the highway. I was told it was fine, until it was not. Now my engine needs to be replaced. What I discovered in my car was their worksheet on issues that they never shared with me. Identified issues on this report: Fault Code 6, PO300400 - history, cylinder misfire, PO30500 - history, cylinder misfire PO34100 When going back for a 'simple' 1000 mile oil check, I was told there was not enough oil loss to identify concern. When I checked my own oil after another 1000 miles, KIA then pursued. In researching, there is a history of these engine problems and engines needing to be replaced with KIA. This is unacceptable and has compromised safety and any value I hoped to have with my car.

1. Failed Component/System: EV plastic charging door does not open using the electronic unlock mechanism on the key. Unable to charge EV vehicle due to this fundamental failure. IMPORTANT: There are no manual override mechanisms provided by the manufacturer - KIA to open this charging door. This makes the EV both unsafe and unusable since it cannot be charged. 2. Safety Risk: Unable to charge an EV vehicle is a fundamental EV electrical system component failure that can create an unsafe situation since it occurs without any warning and leave the car owner stranded. The Manufacturer - KIA has not provided any manual fail safe/override mechanism to open the charging door manually. This is also a fundamental safety issue since the failure occurred without any warning lamp/other indication to the owner. IMPORTANT: Other KIA NIRO EV owners have complained about the same issue in online forums. Refer attachment - [XXX] 3. Dealer Problem Reproduction: NO since dealer demands a $299.99 diagnostic fee. Multiple attempts to contact the dealer and manufacturer KIA to waive the diagnostic fee were unsuccessful. 4. Manufacturer/Police/Insurance Inspection: No. KIA refused to deal with this issue under the KIA 10-year/100,000-Electric vehicle (EV) system warranty even though the warranty description mentions all internal parts. Reference: KIA Case No. [XXX]. NOTE: KIA does not allow the case history to be retrieved from their manufacturer portal because they have closed the case. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure? NO 6. When did they first appear? [XXX] (approximately) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had just left my doctor after a protracted visit and was almost late for dinner guests. I noticed a thumping and thought it was the road, but it was a 3/8" bolt in my tire tread.I pulled up at Costco, hoping they could repair it quickly but was told I had to wait 2.5 hours when I had guests coming in an hour. I decided I would have to change the tire. When opening the trunk I found there is no spare, but saw a kit to fix the flat, which I vaguely remember reading about. I'm in a huge hurry to get home but I open the Owner's manual and there is: NADA about the flat repair. So I look at the components. There is a container of the repair solution and a pump with cartoons on it and a hose with a needle to insert into the puncture. After studying the cartoons for about 5 minutes (I am a highly technical, retired 82 year old ex IT professional), I figured out how to connect the can into the pump the hose to the pump and the power cord into the cigarette lighter (how many people still smoke and what would happen if the 12v socket disappears). I was then able to try to repair the puncture but it was for nought as the hole - duh - was too big. I also apparently ruined any chance the repair shop could repair the hole. The tire shop said my repair solution ruined the chance to repair the tire. Heaven help me if I get a flat in the rural boondocks!!!!! My complaint is: 1. What if this happened on a dark 2 lane country road 100 miles from nowhere and I were a single female or aged, frail couple? How would they manage to put together the repair flat kit with the hieroglyphic documentation on the repair kit pump? Could they be stranded for days without food, water, survival gear like coats or blankets? 2. Not supplying a spare doughnut tire could be imperiling vulnerable people. 3. The Owner's manual does not mention tire repair at all.

I went to use my vehicle horn when another driver pulled out in front of me and the sound was way off...it sounded like a clown horn. I subsequently took to the Kia dealer where they diagnosed that one of the horns failed and it was replaced under an extended warranty with a deductible payment. The failure of the horn compromised my safety and the other driver's as the other driver may not have heard my warning that my vehicle was where it was. There was no warning that the horn failed until I went to use it.