2017 LINCOLN MKZ Complaints

I purchased a 2017 Lincoln MKZ and began experiencing serious engine problems, including repeated overheating and an engine misfire. The vehicle developed a check-engine light and a P0301 misfire code. I was advised by a repair shop that the vehicle has a serious engine problem and that the engine needs to be replaced. I am concerned that the overheating and engine problems could cause the vehicle to suddenly lose power or suffer complete engine failure while I am driving. If the engine loses power unexpectedly while I am traveling in traffic, I could be unable to accelerate or safely move out of the way of other vehicles, creating a serious safety hazard for me, my passengers, and other motorists. I contacted Lincoln regarding these problems and asked the manufacturer for assistance, but Lincoln refused to provide assistance with the issue. I am now left responsible for addressing a potentially serious engine and safety problem. I am requesting that NHTSA document and investigate these engine, misfire, and overheating problems to determine whether they may be related to a safety defect affecting other 2017 Lincoln MKZ vehicles.

We are submitting this vehicle safety complaint regarding a dealer-confirmed coolant-intrusion failure in our 2017 Lincoln MKZ equipped with the 2.0L EcoBoost engine. The vehicle had approximately 60,063 miles when presented to Parks Lincoln of Longwood. The vehicle developed a check engine light, rough running, shaking, and recurring misfire symptoms. Two ignition coils had recently been replaced, but the symptoms returned. The vehicle also produced white exhaust smoke on startup after sitting for several days. Because the rough running was so severe, the vehicle was ultimately towed to the Lincoln dealership on a flatbed. Parks Lincoln's Repair Order 2684839/1 documents DTC P0301. The technician states that, pursuant to TSB 22-2229, a coolant pressure test and cylinder inspection were performed; coolant intrusion was found in cylinder 1; and a long-block engine is required to properly repair the concern. Lincoln TSB 22-2229, NHTSA Manufacturer Communication No. 10214126, describes coolant intrusion in certain 2.0L EcoBoost vehicles including 2017-2019 Lincoln MKZ models. The bulletin identifies white exhaust smoke, rough running, and misfire codes, including P0301, and directs replacement of the long-block engine assembly when the condition is confirmed. Our safety concern is that coolant intrusion can progress from rough running and misfire to loss of engine performance or engine failure while the vehicle is in operation. In our case, the symptoms became severe enough that we did not consider continued driving appropriate and had the vehicle transported to the dealer. We ask NHTSA to add this complaint to its defect database and evaluate it together with other reports involving 2.0L EcoBoost coolant intrusion, misfire, loss of power and engine failure. We can provide the complete dealer repair order, estimate and additional records upon request.

Engine has rough idle and can stall. Ford says engine has coolant intrusion and needs a new engine. The repair will cost between 8500 and 10000 dollars.

The contact owns a 2017 Lincoln MKZ. The contact stated that while operating the vehicle, there was an abnormal rattling sound coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the torque converter, flex plate, and transmission fluid pump were inoperable and needed to be replaced. The vehicle was not yet repaired. The contact was informed that the vehicle was not included in the extended warranty coverage for the repair. The failure mileage was 102,450.

I am reporting a catastrophic engine failure and engine-compartment fire involving my 2017 Lincoln MKZ Select, equipped with a 2.0L EcoBoost engine, VIN [XXX]. The vehicle had approximately 99,864 miles when the final failure occurred. Shortly after I purchased the vehicle, the original engine developed severe overheating, loss of cabin heat, white exhaust smoke, misfiring, and coolant intrusion. On December 16, 2024, at approximately 95,354 miles, the vehicle was taken to Murgado Ford Lincoln of Chicago. The dealership documented diagnostic codes P0303 and P0316 and determined that coolant was entering cylinder No. 3. Pursuant to Ford Technical Service Bulletin 22-2229, the dealership replaced the long-block engine and related one-time-use components. The replacement service-engine assembly was identified on the repair invoice as part No. J2GZ-6006-E. The vehicle was returned to me on approximately January 30, 2025. After the engine replacement, the vehicle continued to experience serious problems. Within days, it stalled in an intersection, produced white smoke, lost cabin heat, and had to be returned to the dealership. The vehicle later continued to exhibit hesitation, harsh shifting, loss of power, and other abnormal drivability symptoms. On September 4, 2025, while I was operating the vehicle under normal driving conditions in Chicago, I heard a sudden loud metallic grinding or mechanical noise coming from the engine area. Gray smoke then began coming from the vehicle and quickly progressed into heavy dark smoke. A fire developed in the engine compartment, forcing me to stop and exit the vehicle. The fire rapidly intensified and was followed by an explosion or explosive sound. There was no collision that initiated this incident. The vehicle sustained catastrophic fire damage and was rendered a total loss. The failure occurred only approximately seven months after the replacement long-block engine was installed and after I had repeatedly experien INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

I own a 2017 Lincoln MKZ equipped with the 2.0L EcoBoost engine. At approximately [MILEAGE] miles, the vehicle began experiencing loss of coolant, rough running/misfire, shaking/rough start, and reduced engine performance. The vehicle was diagnosed by a Ford/Lincoln dealership as having coolant intrusion into the engine/cylinders and/or engine block failure, requiring engine/long-block replacement. The estimated repair cost was approximately $8000. This creates a safety concern because coolant intrusion can cause misfires, overheating, engine damage, and possible loss of power while driving. Ford/Lincoln has issued Technical Service Bulletin 19-2346 and superseding bulletin 22-2229 for 2017–2019 Lincoln MKZ vehicles equipped with the 2.0L EcoBoost engine. These bulletins describe low coolant, white exhaust smoke, rough running, misfire codes, overheating codes, and coolant intrusion into the cylinder, with the prescribed repair being long-block engine replacement. Despite this known documented condition, Lincoln/Ford denied assistance because the vehicle is outside warranty. I am reporting this as a potential safety defect because the failure can occur without adequate warning and may cause engine overheating, misfire, or loss of power while the vehicle is being operated.

2017 Lincoln MKZ was taken to Community Ford Lincoln of Bloomington (Auto Vest II LLC), Bloomington, IN for service on 05/01/2026. No ABS, Traction Control, or AdvanceTrac warning lights were present at drop-off. After the vehicle was returned, all three warning lights were illuminated. The ABS/stability control system had been damaged during the service visit. Diagnostic codes C0031:07 and C0031:15 (left front wheel speed sensor circuit fault) were confirmed in writing by the dealership service manager on 06/09/2026. The dealership denied responsibility. An independent Ford/Lincoln dealer (Tom Roush Lincoln) estimated repair at $310. The servicing dealer offered only partial reimbursement of $169.45. The ABS and stability control systems are safety-critical. Their failure compromises emergency braking performance and vehicle stability, putting driver and other road users at risk. The vehicle has been unavailable for normal use since [XXX]. The problem was confirmed by an independent Lincoln dealership. The vehicle is available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Took car into Ford dealership service because the check engine light came on. The car was sounding a little rough also. When they called me, I was expecting a tune up or just a sensor issue, but I was told that I needed a new engine! The tech found dtc P0302 for misfire on cylinder number 2, found coolant on spark plug. Cylinder #2 was cracked and leaking coolant into it. Was told it would lead to catastrophic failure. Was told I needed a long block replacement at the tune of $9,000. The service tech called Ford to help with the costs, but since I didn't have an extended warranty, they wouldn't do anything. The car has been barely driven and taken well care of. I bought it in 2019 with 12k miles and now in 2026 it only has 69k miles. I have researched and found out that this is a systemic issue. Had I not replaced the engine it could of been catastrophic! I have been with Ford since I started driving in the early 80's. This is unacceptable. According to several reports, this has been reported many times (maybe thousands?). I wonder how many are NOT reported. Ford needs to reimburse for the defective engine.

2.0yt coolant intrusion. Needs long block replaced. So basically a motor. Ford knows about this.

The contact owns a 2017 Lincoln MKZ. The contact stated that while driving approximately 40 MPH the brake warning light had illuminated and the brake pedal extended to the floor and the vehicle did not immediately stop while pressing the brake pedal. The vehicle was slowly driven to a nearby garage who diagnosed that the rear brake hoses had failed causing brake fluid leak from the vehicle and the brake master cylinder had also failed. The mechanic informed that both rear brake lines were installed making contact with the transmission and eventually became damaged. The rear brake lines and master cylinder were replaced. The local dealer and manufacturer were not notified of the failure. The failure mileage was 153,000.