2019 LINCOLN NAVIGATOR Complaints

The contact owns a 2019 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 24V099000 (SEAT BELTS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that upon starting the vehicle and allowing the engine to warm up, the contact attempted to buckle the seat belt and heard a loud pop and the seat belt started to retract with the contacts left arm in the seat belt harness. The contact stated that the Air Bags/SRS warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the seat belt retractor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 110,000. Parts distribution disconnect.

My husband (age [XXX] ) and I (age [XXX] ) were traveling on, he was driving, [XXX] in Atoka, OK on the evening of [XXX], when all of a sudden we heard a loud pop. It sounded like a gun shot. The sound was followed by a smoke smell. He held his composure and was able to pull over, and we learned that it was the seatbelt that was affected, and he had cinch marks on his shirt left by the seatbelt. We then realized the driver’s side seatbelt was “floppy” and wouldn’t retract back. I then called our local Ford dealership in Durant, OK to get it in asap and was informed to bring it in Monday, June 23, 2025. We drove the car home to Durant, OK which is approximately 30 minutes away on a very dangerous stretch of highway after the call. On Monday, I carefully drove it to the dealership to be repaired. I was informed later that day that they were able to repair one recall, the back up camera, but the seatbelt couldn’t be repaired due to a back order on the part (told by Kyle the service tech). I emailed Red River Ford service manager immediately after that and was sent an email back that had his phone number. I then called him, Rick Riley, and he told me that he’s showing that the part is actually not even available to get and couldn’t give me an estimated time. I asked if it was possible to get a loaner, this is my personal car and the only car that can hold my family of 6. We were leaving for vacation June 25 and had no way to get to the airport. I called Lincoln concierge to see if they could do anything to get me a loaner, and the representative was no help. She told me she was going to contact Red River Ford but never did; I had sent a message asking Rick Riley if he had been contacted, and he said no. We ended up paying for a driver to safely get us to DFW airport which cost $360. I’ve called Lincoln 2 more times now and keep getting told the part is on back order but no advice on getting a loaner or them buying back the car. I don’t know what else to do. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Purchased a 2019 Lincoln navigator in 2024 used at a dealership in Orange Park Florida. The vehicle was taken to the same dealership for an oil change, which is a Volkswagen dealership. I started to hear a loud shaking noise after starting it up. I took it to O’Reilly‘s auto parts and had to put on a machine and I also took it to Paul, Clark Ford and Yulee Florida. I was told by both that it was the cam phaser. The vehicle was also leaking coolant, and now the engine has completely blown in the vehicle. It has been sitting at a Lincoln dealership for three weeks with a blown engine due to the cam phaser Echt that was never addressed or corrected by Ford. The vehicle is just sitting. It’s now a boat anchor.

Is all on google this particular vehicle Lincoln Navigator 2019 L have problems on the transmission gear malfunctioning…I barely purchase this exactly model a few days ago and I have this issues concern safety so dealer said is purchase with no warranty but this vehicle have 75000 miles only … we should have the attention on this matter because is safety and costly to repair

About 5 weeks ago, our Navigator's transmission had a mild slip, like it was accidentally put in neutral. Since there was no visible warning sign, check engine light, or clear indicator of transmission issues, we thought it may just be a fluke. Within weeks, the transmission slipping escalated from mild to extreme, causing major safety concerns. When in drive, it would struggle to accelerate, get stuck in the wrong gear, then overcompensate, violently jerking into the correct gear 20+ seconds after it should have. A few times, we narrowly avoided getting rear-ended or rear-ending others. Lincoln service confirmed the 10-speed automatic transmission in the 2019 Navigator is problematic and will likely need a full rebuild, yet there is no transmission recall. They also stated their service department was backed up 4-5 weeks due to transmission repairs. Over the last 2 weeks, we've had a full vehicle diagnostic and repair. The mechanic replaced both leaky transmission coolant lines and completely rebuilt the transmission. He confirmed the check engine light never activated and diagnostic trouble codes never generated. That is an extreme safety problem. According to Lincoln, with leaks and transmission slipping, DTCs should be generated, and check engine lights should come on, but it didn't happen in either case. Please investigate both the transmission failures and the trouble code generation!

Have had Navigator in shop (at dealership) six times for drive train/transmission/seat belt recall and it is not repaired. Last repair has not even been driven 200 miles after dealership having vehicle for 5 weeks.

No warning light on dash. Issues engaging in gears. SUV failed to shift in gear and engine rev up And takes 2 to 10 seconds to catch again before engine engages. No accidents yet. Additionally, during cold start my SUB is making a rattling and ticking sound and the SUV would shake. There were no engine failure or warning lights that came on and the engine doesn’t sound like it’s running correctly.

The contact owns a 2019 Lincoln Navigator. The contact stated that the front driver's side seat belt had locked and had failed to extend as needed. The contact stated that the seat belt was inoperable. The vehicle was taken to the dealer, where it was diagnosed and determined that the seat belt assembly needed to be replaced. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V099000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.

The contact owns a 2019 Lincoln Navigator. The contact stated that while starting the vehicle, the vehicle made an abnormal rattling sound. The vehicle was taken to the dealer, where it was diagnosed that the cam phasers had failed and needed to be replaced. The dealer informed the contact that the VIN was not included in Ford Campaign Number: 21N03. The manufacturer was notified of the failure and confirmed that the VIN was not included. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 83,000.

I had my windshield replaced with an OEM Lincoln glass at the dealership. Upon receiving the vehicle i noticed that when driving at night all lights are duplicated. The duplicated light eventutally merges with the actual light as you approach in distance. Multiple headlights on a highway are very disorienting and distracting making it hard to focus on driving. I have had the glass replaced a total of 4 times. All with the same problem. I was told there was defective glass that had been made however I have yet to get a piece of glass that is optically reasonable to drive at night. Wanted to report as I'm sure others have a similar problem.