LINCOLN Complaints

The contact owns a 2011 Lincoln MKZ. The contact's spouse stated that while the vehicle was parked, the contact's spouse started the vehicle and noticed flames coming from the interior seal of the driver's door, located by the rocker panel. The contact's spouse stated that the flames were not severe. The contact’s spouse was able to extinguish the fire. The contact stated that after inspecting the vehicle, the contact noticed moisture leaking into the rocker panel wiring. The vehicle was taken to an independent mechanic for brake and rotor repair. The contact and the mechanic noticed that the whole rear of the vehicle was severely corroded. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Engine light came on. Took it to mechanic. Was told there is a well documented mechanical issue affecting my 2017 , MKC. My vehicle is experiencing a misfire and cylinder three accompanied by signs of colon intrusion into the engine, as well as transmission slippage. I have heard these are known and widespread issues in 2015 to 2019 Lincoln MKC models equipped with the 2.0L Eco boost engine. I am aware of several technical service bulletins, including TSB 19-2346 and TBS 22-2229, that detail this defect. Numerous Lincon customers have reported identical issues at similar mileage, often requiring full engine or transmission replacement. My trusted mechanic has verified that my vehicle exhibit symptoms consistent with this engine defect.

The foot rails outside the vehicle either don't go up or don't go down. Also, there are several times that the foot rail goes down, and as I step on it, it closes with my foot still on it. Causing me to fall or get my foot stuck between the rail and the car. Fortunately, I didn't get hurt the 4 times that it happened. There is no consistency as to when it happens or any type of warning. The vehicle is scheduled to go in for additional service, but I wanted to file this complaint as it's an extremely dangerous hazard for occupants. Started around the end of June.

Coolant Intrusion into the cylinder causing overheating. New engine block required. Car has been regularly maintained. Failure occured with no warning.

I don't know the component or system that failed but sometimes when I am parked and put my car into reverse, the brakes lock up but my car will roll backwards. I have to either jam both feet on the brake pedal or quickly shift the car back into park and turn the car off and restart it. This usually will correct the problem. It feels like the brakes are locked and they are really hard to press. I drop kids off at school and this has happened in the parking lot several times with children walking behind me as I am getting ready to leave. I no longer am able to pull in forward to spots and have to back in to avoid reversing with people/cars behind me. I would rather hit a curb then potentially roll into a person or another car. I've taken it to the Lincoln dealership and they were not able to reproduce it or diagnose anything with it. Nothing shows up on their system as an error. It happens infrequently but I've owned the car since Nov 2024 and it's happened at least 10 times. My husband thinks its an electronic issue because it corrects itself when the car is restarted. It also randomly allows me to turn the wheel but the wheel does not turn back to 12. It stays at 3 but drives straight. This also is corrected by turning off the car and restarting. It has also been looked at by the dealership without any fixes.

We own a 2016 Lincoln MKZ hybrid that is having issues with the backup camera randomly going blank, or significant delays at random times. Ford/Lincoln addressed the exact issue as a software recall in other models under Recall 25S72, but failed to list our vehicle. This is becoming a big issue with safety not having the backup camera working with the way the rear window is placed, it is difficult to see certain areas behind you. Since this was already identified as a software issue by Lincoln/Ford, we would like to see them extend the recall include our vehicle. This randomly has been happening for the last month.

I know there is a bulletin out from Ford about the PCM , where it says recall on the bottom, yet unannounce. This mimics the issues with the torque converter, the ones that I have in my 2019 lincoln nautilus. About two months ago, I felt a kick. where It thought I had been hit by another car, it was so hard. From that point on, the smoothness of the transmission below 35 miles/hr, was jerky and hesitant, kicking and not accelerating properly. The dealer said that it was the torque converter and that it was very bad. The car is too new to have these types of catastrophic issues. It was $9000 to resolve the issue according to the dealer. I had to go somewhere else. Also the screen has problems where it turns blue, and stops working, where the music playing will also stop and you cannot skip to another song. A hard reboot is the solution, but on a daily basis? I know that other models, the Aviator and Corsair, have the same issues. I have the same problem. When contacting Lincoln dealer for the same issue, they state there is no recall. I really like the Lincoln but there seem to be quite a few problems. Will these be placed in a recall list? The fixes so far have been really expensive.

I own a 2017 Lincoln MKC 2.0L EcoBoost that suffered a complete engine failure caused by coolant intrusion into the combustion chambers. The vehicle began to misfire, emit thick white smoke, lose power, and quickly became almost undriveable. Technical Service Bulletin (TSB) 19-2346 (June 2019), which describes coolant entering cylinders due to a flaw in the cylinder head/block design. This failure is not the result of neglect or normal wear and tear — my vehicle has been maintained according to manufacturer recommendations. Despite this, the engine requires complete replacement at a cost of approximately $9,500. The failure occurred well before what should be the normal service life of an engine, and it matches the same defect pattern reported by many other Lincoln and Ford owners with the 2.0L EcoBoost engine in multiple model years. The coolant intrusion defect creates a serious safety hazard because it can cause sudden, unpredictable loss of engine power while driving. If the defect manifests at highway speeds, the driver may experience immediate power loss, inability to accelerate, or complete engine shutdown — increasing the risk of a collision. Ford/Lincoln have issued internal bulletins to dealers acknowledging this problem but have not initiated a public recall. Many owners have been denied coverage due to warranty expiration, despite this being a manufacturing defect. The result is that numerous vehicles with a dangerous and well-documented engine flaw remain in circulation without corrective action. I believe this defect warrants investigation as it poses both a safety risk to drivers and passengers, and a broader consumer protection concern. Premature catastrophic engine failures on relatively low-mileage vehicles undermine public trust and place owners in severe financial hardship. An NHTSA investigation could compel Ford/Lincoln to issue a recall to address this hazard before more vehicles experience unsafe sudden failure

I purchased a 2017 Lincoln MKZ Select which has been a continuous source of mechanical problems. After recently having a new engine installed, the vehicle has now developed significant transmission issues, making it unsafe and difficult to drive. Despite being sold this car under the assumption it was reliable, I am struggling with costly repairs and reduced functionality, effectively driving a “lemon.” I believe the vehicle’s condition and recurring failures qualify it for protection under consumer lemon laws or warranties, and I am seeking resolution or compensation due to these defects that have severely impacted the vehicle’s usability and my safety.

I did an inspection of my exhaust system and saw numerous carbon deposits along both pipes at different joints. I brought this to the attention of the dealer and they repaired only one (1) leaking joint at the tailpipe. They told me the other leaking joints are normal and are of no concern. I have a video, pictures and the dealer inspection/repair forms from two (2) different service dates.