MAZDA Complaints

NOTES FROM SERVICE TO MY CX90 MAZDA FROM HILEY MAZDA OF HUNTSVILLE 256-578-1915 During my last oil change with Maza on Nov. 12, 1pm the dealership noticed my windshield wiper fluid leaking into the radiator. They had to order a new radiator and repair this problem. They gave me a loaner CX90 for a week until a new radiator and parts arrived. On Dec 03 new radiator came in and my Mazda dealership and they replaced the radiator and windshield wiper mechanisms. Now on [XXX] I noticed my coolant reservior was empty while I was filling my windshield washer reservior. I drove my vehicle to the nearest Kelley Car Parts store and they filled the reservior for me and suggested I get the vehicle to Hiley Mazda asap. I called Mazda on Monday March 2 and they said to bring the vehicle in on March 3 at 1pm. They are now keeping my vehicle to find out what the problem is. I believe they never replaced the new radiator properly. I now have been give a CX50 as a loaner while they again try to fix my car. I am [XXX] and should not have to deal with this. A Mazda 2024 CX90 with only 20, 202 miles on it should not be having these issues. I researched and have found out the Mazda CX90s are having major problems with the radiators leaking from the sides and customers have to have their radiators replaced. This problem should not be happening to a vehicle I purchased brand new [XXX]. I believe Mazda should replace my vehicle with a new vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car developed a known recall issue problem, Recall 2818I. Even though Nebraska was not listed as a "salt state", it's obvious that Nebraska has similar conditions to Iowa. Attempts to contact Mazda USA corporate would not even fix the issue, citing cars age and other factors even though the damage is very specific to this particular recall.

My 2019 Mazda CX-5 started to smoke from the engine and I could smell oil burning. My car was due for an oil change so I brough it to a mechanic. After a diagnostic, they determined that there was a major oil leak and that the cylinder head was cracked and suggested I take it to the dealership. I did and they confirmed that there was a cracked cylinder head causing the massive oil leak. The technician even said in a video sent to me that the oil is leaking "in the same place as the others". I was then quoted $5,960.75 to make this repair. I did research and found that this is a manufacturing defect that is long known to Mazda. There is a TSB and a CPS that extends the warranty for this issue but only for turbo engines, not my non-turbo engine. My car is 2 years past the warranty but I only have 32K miles on it. I asked if Mazda could cover all or some of the cost since it is a defect, not caused by anything I did or didn't do. I was then told that because I didn't take my car there regularly for service, that they wouldn't cover it. I regularly took my car in for oil changes and other maintenance to a local shop as the nearest dealership was almost 30 miles away so it was very inconvenient. It's outrageous that Mazda won't issue a recall or extend the warranty for the same issue in the non-turbo engines. Asking me to pay $6K for a defect they caused is unconscionable.

My VIN indicates the 2.5L non-turbo SKYACTIV engine. Many 2019 CX-5 Touring models with this engine used cylinder deactivation, which is the version that has had some cylinder head cracking complaints. The engine type has documented failures my mileage (96k) is not extremely high for an engine The repair cost is very high ($5,500+) Mazda is refusing to help me out of goodwill assistance and ive only had the car for a year. They know this is a problem and fixed it for the turbos but not the non turbos! This is ridiculous, i expected a car to last more than 96k miles this can cause a fire or a stall and can cause a crash

The contact owns a 2013 Mazda CX-9. The contact stated that while driving at an undisclosed speed, the vehicle shuddered abnormally. The check engine warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed, and determined that the lower control arm needed to be replaced. The vehicle was repaired; however, the contact had not received documentation of the repair. The manufacturer was notified of the failure and informed the contact that the vehicle was repaired under an undisclosed recall. The failure mileage was approximately 188,000.

During a one-hour car ride, the front passenger side seat heater burned a hole through the seat, damaging my wife's skirt and leaving a hole in the upholstery. The overheating definitely originated within the seat. We immediately turned the seat heater off and have not used it since. It could have started a fire, which is very scary, or burned my wife, which is a serious safety risk. This issue has been mentioned by other Mazda owners, but I cannot find any recall reports. There were no warnings prior to the burning. The component is being taken to the dealership to be examined today.

I am reporting a premature engine failure on my 2019 Mazda CX-5 with approximately 55,000 miles. The vehicle developed a significant engine oil leak that was diagnosed by a repair facility as a casting failure in the cylinder head behind the timing cover. Due to the location of the leak and the nature of the defect, the entire cylinder head assembly had to be replaced. The total repair cost was $5,262.32, which I paid out of pocket. The repair documentation indicates that Mazda has issued a Technical Service Bulletin addressing this condition, but there is currently no recall or warranty extension covering the issue for my vehicle. A cylinder head casting failure at such low mileage appears premature and not consistent with normal wear and tear on a properly maintained engine. An engine oil leak of this nature could potentially create safety risks, including oil contamination of engine components or the possibility of oil leaking onto hot engine parts. Because this issue appears to be documented by Mazda through technical service guidance and has resulted in a costly major engine repair at relatively low mileage, I believe it should be investigated to determine whether a broader manufacturing defect exists that could affect other vehicles. I am submitting this complaint so that the issue is documented and can be evaluated for potential safety concerns or a future recall if similar failures are occurring in other vehicles.

Just out of warranty passenger headlight is making a humming noise. Many other owners are having same malfunctions. Cost to replace at dealership is around $2,000.00. LED headlight has a cooling fan that is failing. Many have been replaced under warranty. Mine started just outside of the warranty mileage. It’s a known issue that should have a recall issued.

The contact owns a 2021 Mazda CX-5. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The vehicle was taken to the dealer however, the vehicle was not diagnosed or repaired. The contact was advised by the dealer to continue adding oil to the engine as needed. The manufacturer was made aware of the failure. The approximate failure mileage was 46,465.

The I-Activesense camera disables all the time while driving. It disabled cruise control, LKA and LKA warning as well as auto high beams. While driving at highway speeds, when the vehicle drifts slightly over the line it does not get corrected nor do I receive ANY warning. It's almost as if the system knows it's there but doesn't want to turn on. While I was driving one day, it was very windy and the wind blew my car into the other lane slightly and almost collided with a vehicle. If the system was working that would not have happened. The problem was addressed at the dealership and I was told it was "normal". I've watched many videos on this exact model and trim. It is supposed to put my vehicle back into the center of the lane if it drifts over the lines. I will also add that every time this happens, the weather is perfect and nothing is obstructing the camera. The warning lamps that come on are the sensors disabled, auto high beams, forward collision, and cruise control