MINI Complaints

TL* THE CONTACT OWNS A 2011 MINI COOPER. WHILE DRIVING, A BURNING ODOR ENTERED THE VEHICLE THROUGH THE AIR VENTS AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE LIGHT SENSOR AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO RAY CATENA MINI OF WESTCHESTER (LOCATED AT 543 TARRYTOWN RD, WHITE PLAINS, NY 10607, (914) 347-6464) WHERE IT WAS DIAGNOSED THAT THE INTAKE BOOT AND ALL THE CONNECTORS FOR THE TURBO HOSES MELTED. IN ADDITION, A LEAK WAS FOUND IN THE OIL HOSE. THE VEHICLE WAS NOT REPAIRED DUE TO THE REPAIR FEES. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 18V248000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED CASE NUMBER: 11105312. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

OIL FILTER HOUSING AND/OR OIL FILTER HOUSING GASKETS LEAKING DIRECTLY ON EXHAUST DOWNPIPE, AND IN MY OPINION IS A FIRE HAZARD. THE OIL FLLTER HOUSING IS ONLY HELD ON BY A FEW BOLTS, AND ENGINE VIBRATION AND HEAT CAUSE LEAKING. THIS IS A HORRIBLE DESIGN, AND A COMMON PROBLEM ON THE 1.6 ENGINE. THIS IS A VERY EXPENSIVE FIX, AND AGAIN IN MY OPINION, THERE SHOULD BE A SAFETY RECALL. MY MINI ONLY HAS 106K MILES, AND I HAVE NOT YET FIXED IT DUE TO THE EXPENSE. WITH THE OIL DRIPPING DIRECTLY ON THE EXHAUST, THE OIL BURNS AND SMOKES AND IS A FIRE HAZARD. I KNOW THAT THIS HAS BEEN A COMMON COMPLAINT FOR THOUSANDS OF MINI OWNERS.

AIRBAG LIGHT ILLUMINATED AT ALL TIMES. DEALERSHIP REPORTS $1200 TO REPLACE SENSOR FOR PASSENGER SEAT AND MAY IMPACT ALL AIRBAGS IF NOT FIXED.

MY 2018 MINI COOPER COUNTRYMAN S WAS INVOLVED IN A FRONT END COLLISION WITH ANOTHER DRIVER WHO WAS TRAVELING AT APPROXIMATELY 50-60MPH. WE WERE TRAVELING APPROXIMATELY 13 MPH AT TIME OF IMPACT AND THE FRONT, KNEE OR SIDE AIR BAG(S) DID NOT DEPLOY. I HAVE A VIDEO OF THE ACCIDENT AS A DASH CAM WAS IN PLACE AT THE TIME OF THE ACCIDENT.

CAR PULLS TO THE RIGHT AND IS WOBBLY WHILE IN MOTION, ESPECIALLY MORE UNSTABLE IN WET CONDITIONS AND MINI COOPER SAYS IT IS AN UNEVEN TORQUE ISSUE RELATED TO THE ELECTRICAL/GAS ENGINE AND CANNOT BE FIXED. I HAVE DRIVEN THE CAR FOR 11 MONTHS AND THEY STILL HAVEN'T REPLACED THE VEHICLE WITH A SAFER VEHICLE OR EVEN TALKED WITH ME ABOUT WHAT THEY ARE WILLING TO DO TO CORRECT THE DEFECT. THE DEALERSHIP AND BMW HAVE IGNORED ME AFTER SEVERAL ATTEMPTS TO RESOLVE THE MATTER.

WHEN A PASSENGER IS IN THE FRONT SEAT, THE AIRBAG LIGHT GOES ON AND OFF DURING THE COURSE OF TRAVEL OR SITTING STILL. THE PROBLEM CONTINUES, WHETHER IT BE ON A CITY STREET, FREEWAY, ETC.

VEHICLE JERKS/HESTIATES AT LOW SPEED AROUND 10MPH. JERKS DURING STOP AND GO IN TRAFFIC. BE TO A HANDFUL OF AUTO SHOPS AND NO SOLUTION.

MY TURBOCHARGER FAILED IN 2017. I REPLACED WITH A NON OEM TURBOCHARGER. WE RECEIVED A LETTER FROM MIN EXTENDING THE WARRANTY AFTER OUR REPAIR. MINI IS REFUSING TO REIMBURSE PARTS COST AND INSTALL BECAUSE NON OEM PARTS. THIS SHOULD NOT MATTER ACCOUNT PARTS WERE REPLACED PRIOR TO EXTENDED WARRANTY BEING COMMON KNOWLEDGE.

BROUGHT 2012 MINI COUNTRYMAN S ALL4 W/50,033 MILES TO MINI SERVICE CENTER FOR COOLANT LEAK JUNE 2017. THEY REPLACED THERMOSTAT HOUSING, THERMOSTAT ADAPTER, COOLANT HOSE, AND WATER PUMP. 8000 MILES LATER LEAK IS BACK. WHILE TECHNICIAN WAS WORKING ON VEHICLE, HE STATED, 'OIL LEAKING FROM OIL PUMP SOLENOID VALVE. OIL LEAKING THROUGH OIL PUMP SOLENOID WIRING HARNESS.' HE ALSO STATED, 'THE LEAK IS INTERNAL AND NOT VISIBLE. THE OIL IS LEAKING THROUGH THE WIRING SHEATH AND MIGRATING TOWARD THE COMPUTER. IF THE OIL REACHES THE COMPUTER, THE COMPUTER WILL SHORT, CAUSING CATASTROPHIC DAMAGE.' TECHNICIAN REPLACED OIL PUMP SOLENOID AND REPAIRED ENGINE WIRING HARNESS.' DURING THE DAYS PERIOD OF TIME THE VEHICLE REMAINED IN THE SERVICE DEPARTMENT, I DID SOME QUICK RESEARCH. I COULD NOT FIND AN ACTIVE RECALL FOR THIS ISSUE/ITEM; HOWEVER, THE NHTSA PUBLISHED A SERVICE INFORMATION BULLETIN CONCERNING THIS ISSUE (SB-10044680-8464) LOCATED AT THE FOLLOWING LINK: HTTPS://STATIC.NHTSA.GOV/ODI/TSBS/2014/SB-10044680-8464.PDF APPARENTLY, THIS ISSUE WITH THE SOLENOID IS NOT NEW AND HAS BEEN AN ISSUE WITH PREVIOUS MINI MODELS AS WELL. INFORMATION/COMPLAINTS PERTAINING TO PREVIOUS MINI MODELS CAN BE FOUND AT THE FOLLOWING LINK: HTTPS://WWW.NORTHAMERICANMOTORING.COM/FORUMS/R60-COUNTRYMAN-TALK-2010-2015/237021-OIL-PUMP-SOLENOID-LEAK.HTML INFORMATION/COMPLAINTS CONCERNING THIS ISSUE WITH THE SOLENOID FOR CURRENT MINI MODELS CAN BE FOUND AT THE FOLLOWING LINKS: HTTPS://WWW.MINI2.COM/FORUM/SECOND-GENERATION-FAULTS-FIXES/250393-ISSUE-HIGH-PRESSURE-PUMP-OIL-PUMP-SOLENOID-LEAKING.HTML WHEN THE SERVICE/REPAIRS WERE COMPLETE, I SPOKE WITH THE SERVICE CENTER MANAGER CONCERNING THE SOLENOID. HE AGREED WITH MY FINDINGS THAT MINIS HAVE HAD THIS ISSUE FOR A GOOD NUMBER OF YEARS. I ASKED IF IT WAS A RECALL ITEM AND HE RESPONDED NEGATIVELY. IS THIS ON THE NHTSA RADAR FOR POTENTIAL RECALL STATUS?

THE VIN # OF MY 2002 MINI COOPER S WAS NOT INCLUDED IN THE RECALL FOR THE ELECTROHYDRAULIC STEERING FAILURE OF 2002 - 2005 MINI COOPER S BUT I AM EXPERIENCING THE EXACT ISSUE OUTLINED IN THIS RECALL. THE STEERING IS INCREDIBLY HARD TO TURN WHEN PARKED, AS WELL AS WHILE DRIVING. I NOTICED THAT THE RECALL HAD ABOUT 339 COMPLAINTS AND ROUGHLY 85,000 VEHICLES WERE RECALLED, SO MAYBE AT THE TIME NO ONE WITH A SIMILAR VIN AS ME COMPLAINED.