2005 MITSUBISHI LANCER Complaints

The steering column on my 2005 Mitsubishi Lancer ES detached while driving. The entire column dropped down from its mounting brackets, causing loss of control. This is a serious safety hazard. The mount bolts were intact previously, but they came loose or the bracket failed without warning. This could have resulted in a crash and severe injury. I believe this may be a structural or manufacturing defect and could affect other Lancer vehicles of similar year. I performed a temporary repair myself so the vehicle could be moved safely, but this does NOT solve the underlying problem. The original steering column mounting should not have failed under normal use.

TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT STATED THAT THE CUP FROM THE BALL JOINTS, THE FRONT END, TIE ROD, UNKNOWN WIRING HARNESS AND THE DRIVER'S SIDE HEADLIGHT FAILED. THE VEHICLE WAS TAKEN TO AN UNKNOWN MITSUBISHI DEALER HOWEVER, WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT COVERED UNDER THE WARRANTY. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED OUT OF POCKET. ADDITIONALLY, THE INSTRUMENT PANEL WAS ALSO REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

THE SIGNAL LIGHTS STOP WORKING ALSO THE HAZARDS. THE HORN REMAINS ON. A LOT OF PEOPLE SAY THAT IS A PROBLEM OF THE CAR INSIDE BODY THAT TAKE THE CONNECTOR OF THE JUNCTION BLOCK AND CORRODE THEM. A LOT OF PEOPLE HAVE THIS PROBLEMS. THE PROBLEM IS IN MOTION AND STATIONARY.

I SOLD THIS CAR LAST JULY 2018 THROUGH A TRADE-IN. PLEASE STOP SENDING ME ALL OF THESE HORRIFYING REMINDERS. IT IS NOT APPRECIATED. PLEASE REMOVE MY NAME AND ADDRESS FROM ALL MAILING LISTS. I DID NOT GET IT DONE WHEN I OWNED THE CAR AS THE DEALERSHIP WAS QUITE A DRIVE AND I COULD NOT DROP IT OFF. CAR IS SOLD.

TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER. THE CONTACT STATED THAT THE CROSS MEMBER FRACTURED WITHOUT WARNING AND THE FRONT UPPER AND LOWER CONTROL ARMS DETACHED. THE VEHICLE WAS UNABLE TO BE DRIVEN DUE TO THE FAILURE. THE VEHICLE WAS TOWED TO BELL MITSUBISHI (1500 US-1, RAHWAY, NJ 07065, (732) 709-4333) WHERE IT WAS DIAGNOSED THAT THE CROSS MEMBER NEEDED TO BE REPLACED AND FURTHER TESTING WAS NEEDED. THE CONTACT WAS NOT NOTIFIED OF NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE DEALER DID NOT KNOW THEN THE PART WOULD BE AVAILABLE. THE MANUFACTURER PROVIDED A CASE NUMBER AND THE CONTACT WAS INFORMED THAT A CASE MANAGER WOULD FOLLOW-UP WITHIN TEN BUSINESS DAYS. THE CONTACT HAD NOT BEEN CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. PARTS DISTRIBUTION DISCONNECT.

RECEIVED NOTICE OF A RECALL ON THE PASS. SIDE AIRBAG. CALLED LOCAL DEALER, OUT OF BUSINESS (GREENVILLE MITSUBISHI). NEXT CLOSEST DEALER IS 2 COUNTIES AWAY (DON HERRING MITSUBISHI PLANO), SPOKE TO BENNY. SAID IT'S A 5-HOUR REPAIR AND THEY ARE OPEN ON SATURDAY, BUT WILL NOT PERFORM THE RECALL ON SATURDAY. DUE TO THE DISTANCE INVOLVED, IT'S UNREASONABLE TO TOW OR DROP OFF MY VEHICLE, AND LIKE MANY, I DON'T HAVE 8-9 HOURS TO LOSE TO FIX MITSUBISHI'S ISSUE (DRIVE AND REPAIR TIME, PLUS CONSIDERING LIGHT NORTH DALLAS TRAFFIC). I'M UNABLE TO PROVIDE THE EXORBITANT TIME THIS DEALER REQUIRES OF ME TO PHYSICALLY BE PRESENT FOR THE REPAIR, AND I DON'T KNOW WHO WOULD BE. MISSING WORK, PLUS LITERAL EXPENSES FOR SOMETHING I HAD NO PART IN IS WRONG, AS IS THE 50+ MILE CAB OR UBER FAIR THAT WOULD BE REQUIRED TO MAKE THE RETURN TRIP DURING THE REPAIR. AT THAT POINT, THIS BECOMES A BILL, NOT A SAFETY RECALL. AND MY WIFE IS THE ONLY PASSENGER IN THE FRONT SEAT OF THE VEHICLE. RECALL SITE SENT ME HERE TO FILE A COMPLAINT IF THE DEALER WAS UNABLE TO PERFORM THIS RECALL IN A TIMELY MANNER. NEED RESOLUTION ON THIS MATTER THAT DOESN'T COST ME MORE THAN THE REPAIR ITSELF.

WATER HAS MADE ITS WAY THROUGH THE GROMMET IN THE DRIVER SIDE WHEEL WELL, DOWN THE HARNESS, AND RESTS IN THE CONNECTORS BEHIND THE KICK PANEL UNDER THE DASH. WIRES/CONNECTORS HAVE BECOME CORRODED CAUSING SEVERAL PROBLEMS, INCLUDING: LIGHTS WILL NOT TURN OFF, AND NEITHER WILL THE ENGINE AFTER KEYS ARE REMOVED AND EVEN AFTER THE BATTERY IS DISCONNECTED.

TL* THE CONTACT OWNS A 2005 MITSUBISHI LANCER EVOLUTION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V321000 (AIR BAGS) FOR THE FRONT PASSENGER SEAT AIR BAG INFLATOR AND 16V458000 (SUSPENSION) FOR THE LOWER CONTROL ARM. THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

FOUND EXCESSIVE RUST CAUSING STRUCTURAL DAMAGE TO REAR UNI BODY FRAME SIDE MEMBERS. APPEARS TO HAVE RUSTED FROM THE INSIDE OUT, SIMILAR TO THEIR CURRENT FRONT SUB FRAME RUST RECALL. AT THIS TIME NO ACCIDENTS/ DAMAGE CAUSED BUT LIKELY WILL RESULT IN UNI BODY WEAKENING AND POSSIBLE SUSPENSION/ STRUCTURAL FAILURE

WHILE DRIVING I HAD ALL 3 ACD LIGHTS COME ON. UPON FURTHER INVESTIGATING AND A TRIP TO THE DEALERSHIP I WAS TOLD MY ACD PUMP WAS BAD AND I WOULD NEED A NEW ONE. THIS IS A COMMON PROBLEM IN THESE CARS THAT STILL HASN'T BEEN FIXED WITH THE NEWER MODELS. I WAS QUOTED 2400 DOLLARS JUST FOR THE PUMP, NOT INCLUDING LABOR, AND THAT DOESN'T GUARANTEE THAT IT WON'T HAPPEN AGAIN. *TR